inj MITSUBISHI 3000GT 1992 2.G Workshop Manual
[x] Cancel search | Manufacturer: MITSUBISHI, Model Year: 1992, Model line: 3000GT, Model: MITSUBISHI 3000GT 1992 2.GPages: 738, PDF Size: 35.06 MB
Page 28 of 738
Downloaded from www.Manualslib.com manuals search engine 26GENERAL - Harness Connector Inspection
Front holder
\\Z16R1325]
Housing lance7,fiEL,
c
Terminal lance00000400\
RECTANGULAR WATERPROOF CONNECTOR
(1)Disengage front holder by using a screwdriver and remove
it.
(2) Inset-t tip of screwdriver [*0.8 mm (.03 in.) width] into con-
nector in a manner as shown in the figure, push it lightly
to raise housing lance and pull out harness.
*If right size screwdriver is not available, convert a conven-
tional driver to suit the size.
(3) Press contact point of male terminal down by holding a
screwdriver [1.4 mm (.06 in.) width] in a manner as shown
in the figure.
INJECTOR CONNECTOR
(1) Remove waterproof cap.
(2)Insert tip of screwdriver [1.4 mm (.06 in.) width] into connec-
tor in a manner as shown in the figure, press in terminal
lance and pull out harness.
(3) Press contact point of male terminal down by holding a
screwdriver [1.4 mm (.06 in.) width] in a manner as shown
in the figure.
CautionMake sure that lance is in proper condition before
terminal is inserted into connector.
1 TSB Revision
Page 48 of 738
Downloaded from www.Manualslib.com manuals search engine 46CONFIGURATION DIAGRAMS - Engine and Transaxle
ENGINE AND TRANSAXLE
Connector
symbol
B
Front View
B-0: B;lO 53-11B-12R-i?
IB-06 B-07 B-08B-40*’
B-02
------+
B-01B-30
\ 7
I
B-29
- \B-:4B-23
B-25
A36F0176
B-01
B-02
B-03
B-04
B-05
B-06
B-07
B-08
B-09
i*B-25
NOTE
[:I*‘A992 models*2: From 1993 models*s:1994, 1995 models for California and from 1996 models*4: From 1996 models
Engine coolant temperature gauge unit
Engine coolant temperature sensor
Engine coolant temperature switch(for air conditioning circuit)
Crankshaft position sensor and camshaftposition
sensor*’Throttle position sensor
Control wiring harness and oil pressure wiring
harness combination
Control wiring harness and injector wiring
harness combination
Knock sensor
Variable induction servo motor
(with intake control valve position sensor)
B-10
B-11
B-12
B-13
B-14
B-15
B-16
B-17
B-18
B-19
B-20
B-21
B-22
Variable induction servo motor(with intake control valve position sensor)
Injector No. 5
Injector No. 3
Injector No. 1
Ignition coil
Capacitor
Left bank heated oxygen sensor (front)
California and 1996 models>
Generator
GeneratorRight bank heated oxygen sensor (front)
Magnetic clutch
Power Transistor
Power TransistorL)
TSB Revision
Page 49 of 738
Downloaded from www.Manualslib.com manuals search engine B-23
B-24
B-25
B-28
B-29
B-30
B-31
B-32
B-33
Rear View
B-46*4
B-32
B-33
A36F0167
Starter motor
Starter motor
Back-up light switchFuel pump relay
temperature sensor and atmospheric sensor)
Control wiring harness and battery cable
combination
Injector No. 2
Injector No. 4
Injector No. 6
B-34
B-35
B-36
B-37
B-38
B-40
B-41
B-44
B-45B-46
Speed sensor
Idle air control motor (stepper motor)
Oil pressure gauge unit
Oil pressure switch
Power steering pressure switch
Camshaft position
sensor*2
Crankshaft position sensor*2Right bank heated oxygen sensor
(rear)*3Left bank heated oxygen sensor
(rear)*3Manifold differential pressure
sensor*4
CONFIGURATION DIAGRAMS - Engine and Transaxle
TSB Revision
Page 50 of 738
Downloaded from www.Manualslib.com manuals search engine 48CONFIGURATION DIAGRAMS - Ennine and Transaxle
ENGINE AND TRANSAXLE
Front View
By ‘-[ i”i 7741e2
B-06 B-07 B-06 *\ I I /A /
B-05\ \IB-30
-
B-04*’B-03
-
B-02B-01
-
B-29
*B-24A36F0176
/ m \ i-42*2
B-20I
1IB-27 B-26*’ B-26*2 B-43*2
NOTE
[:I 1:: zif ~$$‘~ode~s
(3) l ?1994, 1995 models for California and from 1996 models
(4)
*4:From 1996 models
B-01
B-02
B-03
B-04
B-05
B-06
B-07
B-08
B-09
Engine coolant temperature gauge unit
Engine coolant temperature sensor
Air conditioning engine coolant temperature switch
Crankshaft position sensor and camshaftposition
sensor*’
Throttle position sensor
Control wiring harness and oil pressure wiring
harness combinationControl wiring harness and injector wiring
harness combination
Knock sensor
Variable induction servo motor(with intake control valve position sensor)
B-10
B-11
B-12
B-13
B-14
B-15
B-16
B-17
B-l 8
B-l 9
B-20
B-21
Variable induction servo motor
(with intake control valve position sensor)
Injector No. 5
Injector No. 3
Injector No. 1
Ignition coil
CapacitorLeft bank heated oxygen sensor
(front)*3
Generator
Generator
Right bank heated oxygen sensor (front)
Magnetic clutch
Power transistor
I-- ~~~TSB Revision
Page 51 of 738
Downloaded from www.Manualslib.com manuals search engine B-22
B-23
B-24
B-26
B-27
B-29
B-30
B-31
B-32
B-33
B-34
Rear View
B-46*4 B-328~33
CONFIGURATION DIAGRAMS - Engine and Transaxle 49 ~
I
A36F0169
Power transistor
Starter motor
Starter motor
Inhibitor switchELC-4
A/T control solenoid valve
Volume air flow sensor (with intake air
temperature sensor and atmospheric sensor)Control wiring harness and battery cable
combination
Injector No. 2Injector No. 4
Injector No. 6
Speed sensor
B-35
B-36
B-37
B-38
B-40
B-41
B-42
B-43
B-44
B-45
B-46
Idle air control motor (stepper motor)
Oil pressure gauge unit
Oil pressure switch
Power steering pressure switch
Camshaft position
sensor*2
Crankshaft position sensor*2
Kickdown servo switch*2AA fluid temperature
sensor*2Right bank heated oxygen sensor
(rear)*3Left bank heated oxygen sensor
(rear)*3
Manifold differential pressure sensor*4
TSB Revision
Page 89 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - MFI Circuit
MFIRELAY
0.85R1.25R 1 1.25GI‘10.85RIR0
1.25R1.25R1.25R
IDLE AIRCONTROL..2,\ 5MOTORI\,\r
I f-1
/1.25G 1.25R-W
II I
1. 2511.251
I. 85G-J
1.25R
).85G-B
VV
lm
n INJECTOR
13
i
-I-
iA--__--------_-_--_ ________---_----__
5853110
1091
i-l
G-YI/I IBI II I
WI II I
BG-W1G-B1B-L
------L
G-i
2---_
cl-1
1Emo
II
VARIABLE INDUCTION
CONTROL MOTOR
1.25B
1
0
EGR
TEMPERATURE
SENSOR (~-22)KNOCK
SENSOR
TSB Revision
Page 101 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - MFI Circuit
MFIRELAY
:F) 1. 25R 1;$.251(Fj0.85R
(F)O. 85ROR
4F (F>1.25!1.25(
IDLE SPEEDpr&oL
(B-35)rr”
25R 1
i
:F)G ;(F) (F)(F)G-R G-B GR-L 6": (
518-__--_L___=~4---~2- ,\ ,\
d&-&d
?>1.25FFj'l.2511.25R-W1. 25F
l(B-33) j-
7$x
22
0. 85W0.85BF
---------___?3
ti
1a
n INJECTOR
II1
F).85G
I
I
2
:F)).85G-k
(F)0. 85G-'3--------_-___-
A_---____-_--_-__-_------------------
--------------------Y
5853110109103
ri/I(F)G-YI I
(F)BI II,,I.+
I
111 m
w; I
4:
(F>B-W' jE
2d,1 (B-08)
E
'l.25EA
hKNOCKEGRTEMPERATURE
SENSORSENSOR (A-P~)
VARIABLE INDUCTION
CONTROL MOTOR
(B-lo) (B-11) CFm @ml Fm Em-2) Gm (8-35)(2 (8-07) (B-08) (8-09)12
@j~~r@~~@JJl@EJ@J@J
TSB Revision
HROBMO IBB
Page 114 of 738
Downloaded from www.Manualslib.com manuals search engine 112CIRCUIT DIAGRAMS - MFI Circuit
MFI CIRCUIT (1994 MODELS)
MFI RELAY
31. 25RFl1.25F(F)1.25R
F)1.25F
3-13)
I
1
1 !1
:F)1.25
(F>1.25RIT
(F)1.25R0
(F10.85R(F)O.85R(F>1.25R
(F>1.25R (F)‘l.25R
(B-40) 13 %SORCKP,.3 SENSORISC5MOTOR r
KNOCK
SENSOR
pdeellINJECTORI
(F)B(F>B
I
:)BI
F)L-H
rH
(F)(F)(F)F)G-B GR-L (F)G-Y (F)(i0.85G-k0.85G-I
117518_____-___----------.Y Y Y,(c-5;r-----
e
t(F)L-A(F)G-E
jg:139:2
5vGNDGND
VV------
1326 (c-52)ENGINE
1.25B1.25BimEL
I!’B
1.2581.25B
hdNOTE:l:FEDERAL
6 0
z2:CALIFORN
(B-08)--(c-53):1
IA
(c-54)*2
HR05M02CA
1 TSB RevisionI
Page 115 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - MFI Circuit
113 i
LEFT BANKRIGHT BANK
HEATED OXYGENLEFT BANKHEATED OXYGEN SENSORCREAR)HEATED OXYGEN
SENSOR(FRONT)
(CALIFORNIA>SENSOR(REAR)
(CALIFORNIA>
(c-55):l (B-16):2 (B-44)(8-45)
y-r------
RIGHT BANK
HEATED OXYGEN
SENSOR(FRONT)(CALIFORNIA>
(F)O.85R
(F) 1.25I
1.25(1.25R
1.25C1.25R-W
INJECTOR
r
1
lI
II;
2
(B-3.
0.85Bl
i
(8-07)1-----3_---__
(F)F)0.85G-W.85G(F)1.85Y-i-R (
(c-52)6_--_
t
15----_
IIIIIIII
IIi B;B' i
IIIIII '
2 /--A
IIII---J
.-JB--
BI
0
(F>B (F)B
(F)1.25Bcc-53):1
(c-54):2
14g:: g::57:177:2 i:---- ------ ---_174z2 gy2
v vvYV
ENGINECONTROLMODULE
NOTEXl:FEDERAL:E:CALIFORNIA
HR05M02CB
TSB Revision
Page 122 of 738
Downloaded from www.Manualslib.com manuals search engine 120CIRCUIT DIAGRAMS - MFI Circuit
MFI CIRCUIT (1994 MODELS)
MFI RELAY
C
(F) 'I- 25R(F) 1. 25R(F) 0. 85R,1
(F> 1.25R (F) 1.25RRESISTOR (A-69)
.r
(F)0.85R(F> 0.85R8
(F>
0. 85
G-R
1
r.
jl1
:B-12:
(F)
0. 85
G-Y
I-----
2
(F)
Os8E
6
_----
1.25R-W
1
m
I[
&E
0. 85
3.----
(F)
“$!$
16_---.
I5Q5 7
(F)
“$3
j,,4 INJECTOR.---- --7I/81.25
IR /
3--:$2--i
(F) (8-07)
“;I”g
1514 (C-52)_---
Y
6
(F)0. 8:G-k
1
ni
ILii3
(F)0. 8EG-E
3:---
1
(F>
“i;“$
1
vI
21. 2:
r
(B-33:
0. 05Y-W
(F>
Og;
3-----
-r
I
I /
Di
‘:
>
I- :
:F)G-1(FG
5._---_18---
1
(F)L-I(F)GI
18 _ _ _ _ _ _ _ _39
I
ti
(F>B7 (I
I.4-
ilI“1ti
GNDGNDVV
1.25B
1.25B
h
1.25B
HR05M07CA
TSB Revision