gearbox Peugeot 206 SW Dag 2002 User Guide

17-06-2002
PRACTICAL INFORMATION
118
CHANGING A WHEEL (saloon) Parking the vehicle
Ð If possible, park the vehicle on
level, stable and non-slippery ground.
Ð Apply the handbrake, engage first or reverse gear (position Pfor the
automatic gearbox).
Access to the spare wheel andthe jack The wheel is located outside the vehicle, under the boot, supported
by a metal carrier.
Ð Remove the wheelbrace 1, secu-
red on the rear right inner panel of the boot. Ð Using the wheelbrace
1, slacken the spare wheel carrier retaining bolt, loca-
ted inside the boot under the carpet.
Ð Lift the carrier to release the hook rearwards, then lower it.
Ð Remove the jack storage box 2located in the spare wheel.
Removing a wheel
Ð Chock the rear of the wheel diagonally opposite the wheel to be changed, using the jack storage box.
Ð Remove the wheel trim using the wheelbrace, by pulling at the valve passage hole.
Ð Slacken the wheel bolts.
Ð Place the jack under the locating point on the sub-frame Ethat is closest to
the wheel to be changed. Ensure that the entire surface of the jack base plate is in contact with the ground.
Ð Extend the jack, completely unscrew the bolts and remove the wheel.

17-06-2002
PRACTICAL INFORMATION119
CHANGING A WHEEL (206 SW) Parking the vehicle
Ð If possible, park the vehicle on
level, stable and non-slippery ground.
Ð Apply the handbrake, engage first or reverse gear, (position Pfor the
automatic gearbox).
Access to the spare wheel andthe jack The wheel is located outside the vehicle, under the boot, supported
by a metal carrier.
Ð Remove the wheelbrace 1secu-
red under the right-hand boot trim. Ð Using the wheelbrace
1, slacken the spare wheel carrier retaining bolt located
inside the boot under the carpet.
Ð Lift the carrier to release the hook rearwards, then lower it.
Ð Remove the jack storage box 2located in the spare wheel.
Removing a wheel
Ð Chock the rear of the wheel diagonally opposite the wheel to be changed, using the collapsible chock located in jack storage box.
Ð Remove the wheel trim using the wheelbrace, by pulling at the valve passage hole.
Ð Slacken the wheel bolts.
Ð Place the jack under the locating point on the sub-frame Ethat is closest to
the wheel to be changed. Ensure that the entire surface of the jack base plate is in contact with the ground.
Ð Extend the jack, completely unscrew the bolts and remove the wheel.

17-06-2002
PRACTICAL INFORMATION
130
Fuse No. Rating
Functions
1 10A Pre-heat unit (diesel) - Water in diesel sensor - Reversing lights switch - Speed sensor - Air flow sensor (diesel)
2 15A Canister solenoid valve - Fuel pump
3 10A ABS control unit
4 10A Automatic gearbox control unit - Engine control unit
5 Ñ Not used
7 20A Headlamp wash pump
8 20A Fan assembly relay - Engine control unit - Diesel injection pump - Diesel high pressure regulator - Engine management solenoid valve
9 15A Left-hand dipped beam
10 15A Right-hand dipped beam 11 10A Left-hand main beam
12 15A Right-hand main beam
13 15A Horns
14 10A Front and rear windscreen wash pumps
15 30A Throttle housing heater - Diesel injection pump - Oxygen sensor - Engine control unit - Air flow sensor - Ignition coil - Engine management solenoid valve - Diesel heater - Injectors
16 30A Air pump relay
17 30A High and low speed windscreen wiper
18 40A Air conditioning fan

17-06-2002
PRACTICAL INFORMATION
128
Fuse No. Rating
Functions
1 15A Heated seat - Alarm
4 20A Multi-function display - Navigation control unit - Boot lighting - Audio equipment
5 15A Automatic gearbox diagnostics
6 10A Coolant level - Automatic gearbox - Audio equipment
7 15A Driving school accessory - Alarm fitted as an accessory
9 30A Rear electric windows
10 40A Rear screen amd mirror demisting 11 15A Rear windscreen wiper
12 30A Front windscreen wiper - Sunroof
14 10A Engine fuse box - Air bags - Steering wheel controls - Rain sensor
15 15A Instrument panel - Multi-function display - Navigation control unit - Air conditioning - Audio equipment
16 30A Locking/unlocking controls for doors, bonnet and boot - Deadlocking controls
20 10A Right-hand brake light
21 15A Left-hand brake light - 3rd brake light
22 30A Front courtesy light and rear courtesy light (206 SW) - Map reading light - Glove box lighting - Lighter - Rear 12 volt socket (206 SW)
S1 Shunt PARC shunt

17-06-2002
PRACTICAL INFORMATION133
Without lifting (four wheels on the ground)
You must always use a tow bar. Saloon From the front or the rearAttach the tow bar to the towing eye. 206 SW From the front , attach the tow bar to the towing eye.
From the rear:
- unclip the cover using a coin,
- screw the towing eye (located in the jack storage compartment) as far as it will go. By lifting (two wheels only on the ground) It is preferable to lift the vehicle by the wheels.
Special features of the automatic gearbox When towing with all four wheels on the ground, the following rules mustbe adhered to:
Ð gear lever in position N,
Ð tow the vehicle at a speed less than 50 km/h over a distance of not more than 50 km,
Ð do not add oil to the gearbox.
Saloon rear towing eye
206 SW rear towing eye
Never use the radiator crossmember.
TOWING YOUR VEHICLE

17-06-2002
TECHNICAL DATA
138
PETROL
Models2CHFX 2CK6D 2CKFW 2CNFU 2ANFU
2CRFN
Model codes 2AHFX 2AK6D 2AKFW 2HNFU 2ENFU 2ARFN
2SHFX 2EKFW 2KNFU 2ERFN 2EHFX
ENGINES 1.1 litre 1.4 litre 1.4 litre 1.6 litre 16V 2 litre 16V Cubic capacity (cm 3
) 1 124 1 360 1 360 1 587 1 997
Bore x stroke (mm) 72 x 69 75 x 77 75 x 77 78,5 x 82 85 x 88
EU standard maximum power (kW) 44,1 55 55 80 100
Maximum power at engine speed (rpm) 5 500 5500 5500 5 800 6 000
EU standard maximum torque (Nm) 94 118 120 147 190
Maximum torque at engine speed (rpm) 2 700 2 800 2 800 4000 4 100Fuel Unleaded Leaded Unleaded Unleaded Unleaded
Catalytic converter Yes No Yes Yes Yes Gearbox Manual Manual Manual Automatic Manual Automatic Manual
(5 speed) (5 speed) (5 speed) (4 speed) (5 speed) (4 speed) (5 speed)
Oil capacity (in litres) Engine (with cartridge replacement) 3,2 (2) - 3,4 (3) 3 (2) - 3,25 (3) 3 (2) - 3,25 (3) 3 (2) - 3,25 (3)3,2 (2) - 3,4 (3) 3,2 (2) - 3,4 (3) 4,25
Gearbox-Final drive 2 2 2 _ 2 _ 1,9
ENGINES AND GEARBOXES
(2) Draining by gravity - (3) Draining by suction

17-06-2002
TECHNICAL DATA139
DIESEL
2C8HX 2CWJY
Models 2A8HX 2AWJY 2CRHY 2ERHY 2CRHYU
Model codes 2S8HX 2SWJY 2ARHY 2KRHY 2ARHYU 2E8HX 2TWJY 2HRHY
ENGINES 1.4 litre Turbo HDI1.9 litre 2 litre Turbo HDI
2 litre Turbo HDI (ECO)
Cubic capacity (cm3
) 1 398 1 867 1 997 1 997
Bore x stroke (mm) 73,7 x 82 82,2 x 88 85 x 88 85 x 88
EU standard maximum power (kW) 50 51 66 66
Maximum power at engine speed (rpm) 4 000 4 600 4 000 4 000
EU standard maximum torque (Nm) 150 125 205 205
Maximum torque at engine speed (rpm) 1 750 2 500 1 900 1 900Fuel Diesel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes Yes Gearbox Manual Manual Manual Manual
(5 speed) (5 speed) (5 speed) (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 3,8 4,8 4,5 4,5
Gearbox-Final drive 2 1,9 1,9 1,9
ENGINES AND GEARBOXES

17-06-2002
TECHNICAL DATA
140
SALOON CONSUMPTION
Fuel consumption values correct at time of printing.
In accordance with directive 99/100 in M.P.G. (litres/100 km)
Engine Gearbox Model Urban driving Inter- Mixed Emission of codes urban CO 2 by weight
g/Km
1.1 litre Manual HFXF 8,2 5 6,2 148
1.1 litre Manual HFXU / A 8,4 5,2 6,3 151
1.4 litre Manual K6D2 9,4 5,5 7 162
1.4 litre Manual KFWF 8,4 5 6,3 149 KFWA 8,5 5,2 6,3 151
1.4 litre Automatic KFWR 9,5 5,4 6,9 165
1.6 litre 16V Manual NFUF 8,6 5,1 6,4 153 HNFUF 8,7 5,7 6,8 161
1.6 litre 16V Automatic NFUR 9,9 5,5 7,1 171 HNFUR 10,2 5,8 7,5 179
2 litre 16V Manual RFNF 10,7 6,1 7,7 185
1.4 litre Turbo HDI Manual 8HXF 5,5 3,6 4,3 113
1.9 litre Diesel Manual WJYF 7,4 4,4 5,5 144 WJYU 7,8 4,6 5,8 153
2 litre Turbo HDI Manual RHYF 6,6 4,1 5 136 HRHYF 6,9 4,4 5,3 144
2 litre Turbo HDI (ECO)Manual RHYU 5,8 3,8 4,5 120

17-06-2002
TECHNICAL DATA141
206 SW CONSUMPTION
In accordance with directive 99/100 In M.P.G. (litres/100 km)
Engine Gearbox Model Urban Inter- Mixed Emission of codes driving urban CO 2 by weight
g/Km
1.1 litre Manual 2EHFXF Ñ Ñ Ñ Ñ
1.4 litre Manual 2EKFWF 8,5 5,2 6,4 153 2EKFWA 8,5 5,2 6,4 153
1.6 litre 16V Manual 2ENFUF 8,6 5,1 6,4 153 2KNFUF 8,7 5,5 6,7 159
1.6 litre 16V Automatic 2ENFUR 9,9 5,5 7,1 171 2KNFUR 10,2 5,8 7,5 179
2 litre 16V Manual 2ERFNF Ñ Ñ Ñ Ñ
1.4 litre Turbo HDI Manual 2E8HXF 5,6 3,8 4,4 117
2 litre Turbo HDI Manual 2ERHYF 6,8 4,1 5,1 138 2KHHYF 6,9 4,4 5,3 144
Fuel consumption values correct at time of printing.

17-06-2002
TECHNICAL DATA
142
3 and 5 DOOR
Engine
1.1 litre 1.4 litre 1.4 litre 1.6 litre 16V 1.6 litre 16V 2 litre 16V
GearboxManual Manual Automatic Manual Automatic Manual
Model codes: HFX KFWF / A KFWR NFUF NFUR RFN K6D
¥ Kerb weight 985 1 025 1 055 1 100 1 055 1 125
¥ Gross vehicle weight (GVW) 1 405 1 450 1 480 1 567 1 614 1 560
¥ Gross train weight (GTW)* 1 920 2 365 2 395 2 467 2 504 2 475
¥ Unbraked trailer 485 510 525 550 550 560
¥ Braked trailer (within GTW) 700 1100 1 100 1 100 1 100 1 100
WEIGHTS AND TOWING LOADS (IN KG) * In the case of a towing vehicle, the speed is limited to 100 km/h.
3 and 5 DOOR VANS
Engine
1.4 litre HDI 1.9 litre D 2 litre HDI2 l. HDI (ECO)1.1 litre 1.4 litre HDI 1.9 litre D
GearboxManual Manual Manual Manual Manual Manual Manual
Model codes: 8HX WJY RHY RHYU HFXU 2S8HXF WJYU 2SHFX 2SWJY
¥ Kerb weight 1 061 1 084 1 145 1 145 900 1 049 1 000
¥ Gross vehicle weight (GVW) 1 525 1 525 1 585 1 585 1 405 1 525 1 525
¥ Gross train weight (GTW)* 2 425 2 440 2 500 2 500 1 920 2 425 2 440
¥ Unbraked trailer 530 540 570 500 485 524 540
¥ Braked trailer (within GTW) 1 100 1 100 1 100 1 100 700 1 100 1 100