transmission oil Ram ProMaster 2014 Owner's Manual

ENGINE BREAK-IN RECOMMENDATIONS
A long break-in period is not required for the engine and
drivetrain (transmission and axle) in your vehicle.
Drive moderately during the first 300 miles (500 km).
After the initial 60 miles (100 km), speeds up to 50 or
55 mph (80 or 90 km/h) are desirable.
While cruising, brief full-throttle acceleration within the
limits of local traffic laws contributes to a good break-in.
Wide-open throttle acceleration in low gear can be detri-
mental and should be avoided.
The engine oil installed in the engine at the factory is a
high-quality energy conserving type lubricant. Oil changes
should be consistent with anticipated climate conditions
under which vehicle operations will occur. For the recom-
mended viscosity and quality grades, refer to “Mainte-
nance Procedures” in “Maintaining Your Vehicle”.
CAUTION!
Never use Non-Detergent Oil or Straight Mineral Oil
in the engine or damage may result.
NOTE: A new engine may consume some oil during its
first few thousand miles (kilometers) of operation. This
should be considered a normal part of the break-in and
not interpreted as a problem.
SAFETY TIPS
Transporting Passengers
NEVER TRANSPORT PASSENGERS IN THE CARGO
AREA.
2
THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 63

WARNING!(Continued)
•TIREFIT Sealant solution contains latex. In case of
an allergic reaction or rash, consult a physician
immediately. Keep TIREFIT out of reach of children.
If swallowed, rinse mouth immediately with plenty
of water and drink plenty of water. Do not induce
vomiting! Consult a physician immediately.
Sealing A Tire With TIREFIT
(A) Whenever You Stop To Use TIREFIT:
1. Pull over to a safe location and turn on the vehicle’s Hazard Warning flashers.
2. Verify that the valve stem (on the wheel with the deflated tire) is in a position that is near to the ground.
This will allow the TIREFIT Hoses (6) and (7) to reach
the valve stem and keep the TIREFIT kit flat on the ground. This will provide the best positioning of the
kit when injecting the sealant into the deflated tire and
running the air pump. Move the vehicle as necessary to
place the valve stem in this position before proceeding.
3. Place the transmission in PARK (auto transmission)
or in Gear (manual transmission) and turn Off the
ignition.
4. Set the parking brake.
(B) Setting Up To Use TIREFIT:
1. Push in the Mode Select Knob (5) and turn to the Sealant Mode position.
2. Uncoil the Sealant Hose (6) and then remove the cap from the fitting at the end of the hose.
3. Place the TIREFIT kit flat on the ground next to the deflated tire.
290 WHAT TO DO IN EMERGENCIES

4. Remove the cap from the valve stem and then screwthe fitting at the end of the Sealant Hose (6) onto the
valve stem.
5. Uncoil the Power Plug (8) and insert the plug into the vehicle’s 12 Volt power outlet.
NOTE: Do not remove foreign objects (e.g., screws or
nails) from the tire.
(C) Injecting TIREFIT Sealant Into The Deflated Tire:
• Always start the engine before turning ON the TIRE-
FIT kit.
NOTE: Manual transmission vehicles must have the
parking brake engaged and the shift lever in NEUTRAL.
• After pressing the Power Button (4), the sealant (white
fluid) will flow from the Sealant Bottle (1) through the
Sealant Hose (6) and into the tire. NOTE:
Sealant may leak out through the puncture in the
tire.
If the sealant (white fluid) does not flow within0–10
seconds through the Sealant Hose (6):
1. Press the Power Button (4) to turn Off the TIREFIT kit. Disconnect the Sealant Hose (6) from the valve stem.
Make sure the valve stem is free of debris. Reconnect
the Sealant Hose (6) to the valve stem. Check that the
Mode Select Knob (5) is in the Sealant Mode position
and not Air Mode. Press the Power Button (4) to turn
On the TIREFIT kit.
2. Connect the Power Plug (8) to a different 12 Volt power outlet in your vehicle or another vehicle, if
available. Make sure the engine is running before
turning ON the TIREFIT kit.
3. The Sealant Bottle (1) may be empty due to previous use. Call for assistance.
6
WHAT TO DO IN EMERGENCIES 291

MAINTAINING YOUR VEHICLE
CONTENTS
ENGINE COMPARTMENT — 3.6L ..........321

ONBOARD DIAGNOSTIC SYSTEM — OBD II . . .322
▫ Loose Fuel Filler Cap Message ............323
 EMISSIONS INSPECTION AND
MAINTENANCE PROGRAMS .............323
 REPLACEMENT PARTS ..................325
 DEALER SERVICE ..................... .325
 MAINTENANCE PROCEDURES ...........325
▫ Engine Oil ......................... .327
▫ Engine Oil Filter ..................... .329▫
Engine Air Cleaner Filter ................329
▫ Exhaust System ..................... .330
▫ Maintenance-Free Battery ...............332
▫ Air Conditioner Maintenance .............334
▫ Body Lubrication .....................336
▫ Windshield Wiper Blades ...............337
▫ Cooling System ..................... .338
▫ Brake System ....................... .344
▫ Automatic Transmission
(3.6L Gasoline Engine Only) ..............346
7

WARNING!(Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that has
been in a tightly closed container. Keep the master
cylinder reservoir cap secured at all times. Brake
fluid in a open container absorbs moisture from the
air resulting in a lower boiling point. This may
cause it to boil unexpectedly during hard or pro-
longed braking, resulting in sudden brake failure.
This could result in a collision.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
(Continued)
WARNING! (Continued)
•Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Automatic Transmission (3.6L Gasoline Engine
Only)
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer’s specified transmission fluid.
Refer to “Fluids, Lubricants, and Genuine Parts” in this
section for fluid specifications. It is important to maintain
346 MAINTAINING YOUR VEHICLE

Clean Air Gasoline....................... .256
Cold Weather Operation ....................195
Compact Disc (CD) Maintenance ..............185
Compact Spare Tire ....................... .241
Console, Overhead ........................114
Contract, Service ......................... .385
Coolant Pressure Cap (Radiator Cap) ...........342
Cooling System .......................... .338
Adding Coolant (Antifreeze) ...............340
Coolant Capacity ...................... .370
Coolant Level ......................... .339
Disposal of Used Coolant .................343
Drain, Flush, and Refill ...................339
Inspection ........................... .343
Points to Remember .....................343
Pressure Cap ......................... .342
Radiator Cap ......................... .342
Selection of Coolant (Antifreeze) .............339
Corrosion Protection ...................... .348Cruise Light
............................ .131
Cupholders ..............................119
Customer Assistance ...................... .383
Data Recorder, Event .......................51
Dealer Service ........................... .325
Defroster, Windshield .......................66
Diagnostic System, Onboard .................322
Dimmer Control ...........................91
Dimmer Switch, Headlight ...................93
Dipsticks Automatic Transmission ..................348
Oil (Engine) .......................... .327
Power Steering .........................211
Disabled Vehicle Towing ....................316
Disposal Antifreeze (Engine Coolant) ................343
Door Locks ..............................21
Door Locks, Automatic ......................23
394 INDEX

Engine Oil Viscosity...................... .328
Engine Oil Viscosity Chart ...................328
Entry System, Illuminated ....................18
Ethanol ............................... .256
Event Data Recorder ........................51
Exhaust Gas Caution ........................64
Exhaust System ...........................64
Exterior Lighting ..........................91
Exterior Lights ............................67
Fabric Care ............................. .352
Filters Air Cleaner .......................... .329
Air Conditioning ...................... .335
Engine Oil ........................... .329
Engine Oil Disposal .....................329
Flashers Hazard Warning ....................... .283
Turn Signal ............................67 Flooded Engine Starting
....................195
Fluid Capacities ......................... .370
Fluid Leaks ..............................68
Fluid Level Checks Automatic Transmission ..................348
Brake ............................... .345
Cooling System ........................ .339
Power Steering .........................211
Fluids, Lubricants and Genuine Parts ...........371
Fog Lights ...............................93
Four-Way Hazard Flasher ...................283
Freeing A Stuck Vehicle .....................314
Fuel .................................. .255
Adding ............................. .260
Additives ............................ .258
Clean Air ............................ .256
Ethanol ............................. .256
Filler Cap (Gas Cap) .....................260
Gasoline ............................. .255
396 INDEX

Traction Control......................... .216
Traction Control Switch .....................216
Trailer Sway Control (TSC) ..................222
Trailer Towing .......................... .264
Cooling System Tips .....................279
Hitches ............................. .267
Minimum Requirements ..................272
Tips................................ .278
Trailer and Tongue Weight .................271
Wiring .............................. .276
Trailer Towing Guide ...................... .268
Trailer Weight ........................... .268
Transaxle Automatic .............................12
Transmission Automatic ........................... .196
Fluid ............................... .346
Transmitter Battery Service (Remote Keyless Entry) . .20
Tread Wear Indicators ..................... .244Trip Odometer
.......................... .129
Turn Signals ............................ .128
Uniform Tire Quality Grades .................389
Unleaded Gasoline ....................... .255
Untwisting Procedure, Seat Belt ................33
Upholstery Care ......................... .352
Vehicle Certification Label ...................262
Vehicle Identification Number (VIN) .............6
Vehicle Loading ......................... .232
Vehicle Modifications/Alterations ...............7
Vehicle Storage .......................... .365
Viscosity, Engine Oil ...................... .328
Wait to Start Light ........................ .130
Warning Lights (Instrument Cluster Description) . . .128
Warnings and Cautions .......................6
Warranty Information ..................... .386
10
INDEX 405