lock SAAB 9-3 2001 Manual PDF

208 Car careFront fog lights1 Slightly turn the bulb holder counter-
clockwise.
2 Unplug the connector.
3 Remove the bulb.
Stop lights, taillights and direction
indicators 1 Open the door in the trunk upholstery.
2 Press aside the plastic tab that secures
the bulb holder.
3 Carefully pull the entire bulb holder out
of the lamp unit. Replace the dead bulb.
4 When the bulb holder is being refitted,
check that its plastic catches snap into
place.
WARNING
Never crawl under a car that is
supported only by a jack, use axle stands;
for further information about jacking up
the car, see page 222.
IB905
IB955
Rear light clusters 1 Direction indicators
2 Tail lights/stop lights
3 Reversing lights
4 Rear fog light
5 High-mounted stop light
IB907
ProCarManuals.com

213 Car care
MAXI fusesThe MAXI fuses are housed in the fuse box
under the hood. These fuses can be
checked in the same way as the other fuses.
The MAXI fuses are designed to protect the
car’s electrical system from being dam-
aged. Each MAXI fuse protects a number of
electrical circuits and functions and there-
fore has a higher rating (amperage) than the
standard fuses. No spare MAXI fuses are
supplied with the car.
DICE / TWICEDICE = Dashboard Integrated Central Elec-
tronics
TWICE = Theft-Warning Central Electronics
DICE and TWICE are electronic control
modules.
DICE controls, among other things:
 Front lights and interior lighting.
 Instrument illumination.
 Intermittent wiper operation.
 Electric heating of rear window and door
mirrors.
TWICE controls, among other things:
 Central locking.
 Car alarm (Anti-theft system).
 Engine immobilizer.
 Auto checking of lights.
 Electric heating of rear seat.
 Safety belt reminder.
 Electrically adjustable passenger seat.The DICE and TWICE control modules are
linked to a data bus, which is basically an
information carrier that allows information to
be exchanged between all the control mod-
ules and components connected to the bus.
If a fault occurs in any of these components,
diagnostic faults codes are set in the rele-
vant control module, which enhances fault
diagnosis at the Saab dealer.
The scan tool connector for fault diagnosis
is located under the instrument panel on the
drivers side.
NOTEIf a MAXI fuse blows, it means that there
is a major fault in the electrical system.
Have the car checked without delay by an
authorized Saab dealer.
IB920
MAXI fuse for soft-top system
(Convertible)
ProCarManuals.com

215 Car care
Relay holderUnder the instrument panel next to the steering wheel No. Amp Function
21 10 Switch, manual A/C; soft top (Convertible)
22 15 Direction indicators
23 20 Soft top (Convertible); telephone
24 7.5 Radio
25 30 Central locking; amplifier
26 30 Control module, engine management system
27 15 High beam flash; ACC
28 10 Control module, engine management system
29 10 Right parking light; number-plate lighting
30 10 Left parking light
31 20 Reversing light; windshield wipers; headlight
beam-length adjustment
32 15 Fuel pump
33 15 Electric heating of rear seat
34 10 SID; control module; automatic transmission
35 15 DICE/TWICE; main instrument panel; interior light-
ing
36 10 Relay, starter
37 15 Limp-home
38 25 Oxygen sensor (lambda probe)
39 – –
S–SpareItem Function
A Electric heating of rear seat
B Reversing light, cars with automatic transmission
C1 –
C2 Lock motor, trunk lid
D1 Rear wiper
D2 Rear-window washing
E Ignition switch
F–
G Windshield wipers (intermittent)
H Rear-window heating
IFuel pump
J–
KStart relay
L Main relay (injection system)
ProCarManuals.com

222 Car careWhen it is time to raise the car, apply the
jack to one of the four jacking points (front or
rear) located beneath the sills.
If a floor jack is used it can be applied to the
standard jacking points used by the dealer
or centrally under the front of the engine
subframe. If the car is equipped with a trailer
hitch, the jack can also be placed under the
hitch. 1 Put the car in 1st gear (automatic trans-
mission: move selector to the P position)
and apply the parking brake.
Saab 9-3 Viggen: The front and rear
jacking points are located behind covers
that must be removed.
2 Wind the jack up to a suitable height
before placing it under the recess in the
sill.
3 Make sure that the jack fully engages
the recess in the sill and that the base of
the jack is steady and flat on the ground.
4 Turn the jack handle clockwise until it
just begins to lift the car. 5 Remove the wheel cover (where appli-
cable). Loosen the wheel bolts by half a
turn.
6 Turn the jack handle to raise the wheel
clear of the ground. Remove the wheel
bolts and lift off the wheel.
7 Fit the wheel and screw in the bolts in the
sequence shown (opposite pairs).
Tighten the studs enough for the studs
and wheel to be seated correctly.
See page 224 for sequence.NOTEDo not position the jack under the rear
axle or under the rear floor.
IB924
Pos i ti o n for j ack
IB1538
Positioning the jack
ProCarManuals.com

224 Car care
Flat spottingAll tires get hot, especially on long journeys
or when the car is driven hard. After the car
has been parked with hot tires and the tires
have cooled down, a flat spot can form in the
tire, where it is in contact with the ground.
The same can occur if the car has not been
moved for a long time.
Flat spots can cause vibration that can be
felt through the steering wheel, similar to
that experienced when the wheels need bal-
ancing. Flat spots of this type disappear
once the tires get hot again, usually after
10–15 miles (20–25 km) of driving at cruis-
ing speed.
Safety beltsA check should be made periodically to
ensure that the safety belts are working
properly.
 Hold the diagonal strap and pull it sharply.
The safety belt should lock and it should
not be possible to withdraw it further.
A sharp tug on the belt should cause the
inertia reel to lock. Check the floor anchor-
age points for corrosion damage. If a belt is
worn or has any fraying edges, it should be
replaced.
Safety belts must not come into contact with
substances such as polishes, oil or chemi-
cals. If the belts get dirty, wash them with
warm water and a detergent or have them
replaced.
WARNING
Safety belts and belt pretensioners that
were in use in a serious collision must be
replaced even if they are not visibly
damaged.
No attempt must be made to repair, or
modify the function of, safety belts.
IB923
Removing the wheel cover
IB925
Tightening sequence, wheel bolts
ProCarManuals.com

242 Maintenance and owner assistance
Service Intervals **
Miles = U.S. Cars
Kilometers = Canadian Cars
30 day
10,000
(16,000 km)
20,000
(32,000 km)
30,000
(48,000 km)
40,000
(64,000 km)
50,000
(80,000 km)
60,000
(96,000 km)
70,000
(112,000 km)
80,000
(128,000 km)
90,000
(144,000 km)
100,000
(160,000 km)
Service #
1234567891011
Chassis (cont.)
RToe-in"""
R Cabin air filter!!!!!
R Door hinges, stops and locks"" # "" # "" # "
R Airbag system, SRS warning lamp, visual inspection"""""""""""
R Safety belts; operation and visual inspection of belt for
tears and fraying"""""""""""
R Wiper blades"""""""""""
R Washer system: check and top-up"""""""""""
R Reset service indicator""""""""""
Customer programming
R Carry out systems programming per customer request"
Road test
R Check performance of drive train, steering and brakes
and verify tire balance.
Check function of instruments and controls, including
horn, windshield wipers, cruise control and climate sys-
tem.
Note any noises or problems for correction."""""""""""
ProCarManuals.com

251 Technical data
Suspension
SteeringBrake systemSpring type, front and rear ____________ Coil springs
Maximum deflection of springs:
front, Coupé/5-door/Convertible _______ 6.4" (163 mm)
front, Viggen ______________________ 6.5” (165 mm)
rear, Coupé/5-door/Convertible _______ 8.3" (212 mm)
rear, Viggen ______________________ 7.9” (200 mm)
Dampers, front and rear ______________ Gas-filled tele-
scopic shock
absorbers
Steering __________________________ Power-assisted
steering gear of
rack-and-pinion
type with tele-
scopic, universal
joint steering- col-
umn shaft
Number of turns, lock to lock __________ 3.0
Oil type ___________________________ Power Steering
Fluid CHF 11S Footbrake (ABS) ___________________ Hydraulic disc
brakes with vacuum
servo, diagonally
split circuits
Parking brake ______________________ Acts on rear wheels
Brake fluid ________________________ DOT 4
Do not use DOT 5
Disc diameter:
front, Coupé/5-door/Convertible _______ 11.4" (288 mm)
front, Viggen ______________________ 12.0” (306 mm)
rear ____________________________ 11.3" (286 mm)
Total friction area of brake pads:
front, Coupé/5-door/Convertible _______ 34.4 in² (224 cm²)
front, Viggen ______________________ 35.9 in² (234 cm²)
rear ____________________________ 14.2 in² (92 cm²)
ProCarManuals.com

255 Technical data
Several of the systems in your Saab
car may be adjusted to better fit your
individual needsSome functions are governed by legal
requirements and cannot therefore be
reprogrammed.
Consult an authorized Saab dealer for fur-
ther information.
Car alarm/central locking system:
 The level of the siren when locking/
unlocking, HIGH or LOW.
 The number of blinks when locking/
unlocking, 1 to 7.
 Automatic locking of the trunk when the
car is driven, 1 to 8 mph (2-14 km/h), YES
or NO.
 Preclude the unlocking of the trunk while
the car is driven, YES or NO.
 Automatic locking of the trunk after
1 second-4 minutes if it has not been
opened, YES or NO.
 Automatic locking of the trunk when it is
closed, YES or NO.Saab Information Display (SID):
 Outdoor temperature display can be
adjusted.
Miscellaneous:
 Select the on-time for heated rear seat.
 Coolant temperature gauge adjustment
can be increased/decreased.
 Fuel level gauge adjustment can be
increased/decreased.
 Additional sweep of the wipers after wind-
shield washer function (ON or OFF).
 Courtesy Headlight Feature (follow-me
home) on-time can vary from 20 to
50 seconds.
 Night panel illumination deactivation
speed for the speedometer can be
adjusted.
Following adjustments can be done
by the driver:Automatic Climate Control (ACC):
To alter the preprogrammed “AUTO“ start
up mode with your own preferences you can
manually select the desired settings for:
 Temperature.
 Fan speed.
Air distribution.
See “Programming I” on page 90 and “Pro-
gramming II” on page 91.
ProCarManuals.com

257 Index
Index
AA/C system, fault diagnosis
________ 232
A/C system, maintenance _________ 232
ACC
__________________________ 84
ACC, useful tips
_________________ 92
Adjustment, steering wheel
________ 137
Air conditioning (A/C), fault diagnosis
and maintenance
______________ 232
Airbag
_________________________ 28
Alarm __________________________ 41
Alarm functions
__________________ 44
Alarm signals
___________________ 44
Anti-corrosion treatment
__________ 228
Anti-theft system
_________________ 41
Ashtray
_______________________ 141
Audio System
___________________ 93
Automatic climate control (ACC)
_____ 84
Automatic transmission
___________ 162
BBattery
________________________ 201
Boost starting from donor battery
___ 187
Brake fluid, check
_______________ 200
Brake fluid, grade _______________ 251
Brake pad wear indicators
____ 170
, 200Brakes
________________________ 170
Braking _______________________ 170
Bulb table _____________________ 211
CCD changer
____________________ 105
CD player
_____________________ 103
CHECK messages
_______________ 72
CHECKING
_____________________ 72
Cabin lighting __________________ 139
Calibration, ACC _________________ 90
Car alarm
______________________ 41
Car phone, installation
___________ 113
Care of safety belts
______________ 224
Cassette player
_________________ 100
Central locking __________________ 36
Change of address notification
_____ 238
Changing a wheel
_______________ 221
Changing bulbs
_________________ 206
Changing the coolant
____________ 199
Changing the engine oil __________ 196
Changing the key battery __________ 39
Changing the wheels round _______ 218
Changing wiper blades
___________ 204
Chassis number
________________ 253
Child car seats
__________________ 19
Child safety
_____________________ 19
Child safety locks, rear doors
_______ 39
Child seats
_____________________ 19
Cigar lighter ____________________ 141Cleaning the soft top, Convertible
____ 57
Climate-control system, manual
_____ 80
Compact spare wheel
____________ 220
Condensation water, A/C __________ 82
Condensation water, ACC __________ 85
Convertible
_____________________ 47
Coolant
_______________________ 198
Courtesy Headlight Feature
________ 76
Cruise Control
__________________ 169
Cup holder
_____________________ 140
DDICE/TWICE
___________________ 213
Date code, tires _________________ 220
Dim low beam
___________________ 75
Dimmer
________________________ 78
Direction indicators
_______________ 76
Direction-indicator stalk
____________ 76
Dome lighting
__________________ 139
Door mirrors
___________________ 143
Drive belt
______________________ 203
Driving in deep water
_____________ 185
Driving in hot weather ____________ 179
Driving technique
________________ 176
Driving with a compact spare wheel
_ 190
Driving with a load
_______________ 184
Driving with a roof load
___________ 182
Driving with the trunk lid open
______ 185
ProCarManuals.com

258 IndexEEconomical motoring
____________ 176
Electrical system, technical data
____ 250
Electrical window
_______________ 136
Electrically adjustable seats
_______ 133
Electrically heated front seats ______ 135
Electrically heated rear seat
_______ 135
Electrically heated rear window _____ 83
Electronic starting interlock
_________ 37
Emergency opening, fuel filler door
_ 150
Emergency operation of the soft top,
Convertible
____________________ 52
Emergency operation of the sunroof
_ 138
Emission control systems
_________ 194
Engine bay
____________________ 193
Engine bay, cleaning
_____________ 226
Engine break-in period _______ 161
, 176
Engine number
_________________ 253
Engine oil, changing
_____________ 196
Engine oil, checking _____________ 196
Engine oil, grade
________________ 247
Engine oil, volume _______________ 247
Engine variants
_________________ 249
Engine, description ______________ 194
Engine, technical data ____________ 247
FFault codes, Audio System
________ 115
Flat spot
______________________ 224Folding the soft top, Convertible
_____ 49
For long trips
___________________ 190
Front fog lights __________________ 77
Fuel filler door, emergency opening
_150
Fuel gauge
_____________________ 68
Fuel grade _____________________ 249
Fueling
_______________________ 157
Fuel-tank capacity
_______________ 249
Fuse table
_____________________ 214
Fuses
________________________ 212
GGearbox number
________________ 253
Gearbox oil, checking
____________ 197
Gearbox oil, grade
_______________ 250
General particulars ______________ 244
General safety instructions, Convertible
48
Glove compartment
______________ 141
HHandbrake
_____________________ 174
Hazard warning lights
_____________ 76
Head restraint
___________________ 18
Headlight flasher _________________ 75
Hood
_________________________ 192
Horn signal
____________________ 137
IIf the car does not start
___________ 153
Ignition switch
__________________ 152
Immobilizer
_____________________ 37
Important considerations concerning
cars with catalytic converters
_____ 156
Important considerations for driving
_ 154
Indicator lights
___________________ 60
Instrument lighting
________________ 78
Integrated booster seat
____________ 26
Interior equipment
_______________ 129
Interior lighting
__________________ 139
Interior lighting, Convertible
_________ 58
Interior rearview mirror
___________ 143
JJump starting
___________________ 187
KKey
___________________________ 36
Key, removing
__________________ 152
LLATCH (child safety)
______________ 21
Labels and plates
_______________ 253
ProCarManuals.com