ECU SKODA FABIA 2006 2.G / 5J Owner's Guide

Inspecting and Replenishing197
Using the systemSafetyDriving TipsGeneral MaintenanceBreakdown assistanceTechnical Data
Inspecting and Replenishing
Engine compartment
Bonnet remote release
Bonnet remote release
– Pull the unlocking lever on the left below the dash panel
⇒ fig. 141.
The bonnet jumps out of its lock as a result of the spring force.
Opening and closing the bonnet.
Fig. 141 Bonnet release lever
Fig. 142 Radiator grille: Fuse
Fig. 143 Securing the bonnet with the bonnet support
NKO A05Fabia 20.book Page 197 Tuesday, September 26, 2006 8:38 AM

Inspecting and Replenishing199
Using the systemSafetyDriving TipsGeneral MaintenanceBreakdown assistanceTechnical Data
•Never spill oil and other fluids over the hot engine. Such fluids (e.g. the antifreeze contained in the coolant) may ignite!
•Avoid short circuits in the electrical system - particularly on the battery.
•Never place your hand into the radiator fan as long as the engine is still warm. The fan might suddenly start running!
•Never open the cap of the coolant expansion bottle as long as the engine is still warm. The co oling system is pressurized!
•Cover over the cap of the coolant expansion reservoir with a large cloth when opening it as protection for your face, hands and arms from hot steam or hot coolant.
•Do not let objects, such as e.g cleaning cloth or tools lie in the engine compartment.
•If you wish to work under the vehicle, you must secure the vehicle from rolling away and support it with suitable supporting blocks: the car jack is not sufficient for this - risk of injury!
•In cases where it be necessary to carry out inspection work when the engine is running there is an additional risk from rotating parts (e.g. the V-ribbed belt, alternator, radiator fan) and from the high-voltage igni- tion system. Please observe in addition the following:
− Never touch the electrical cables of the ignition system.
− Absolutely avoid any jewellery, loose items of clothing or long hair from getting into the rotating part s of the engine - Hazard! Therefore remove any jewellery beforehand, tie up your hair and wear tight fitting clothing.
•Please also comply with the warnin g instructions stated below when carrying out any essential work on th e fuel system or on the electrical system:
− Always separate the car battery from the electrical system.
− Do not smoke.
− Never carry out any work close to naked flames.
− Always keep a working fire extinguisher at hand.
Caution
When replenishing fluids in the engine, always ensure that the fluids are on no account mixed up. This may result in ma jor operating problems and also vehicle damage!
Overview of the engine compartment
The main inspection points.
Fig. 144 Diesel engine 1.9 litre/77 kW
WARNING (continued)WARNING (continued)
NKO A05Fabia 20.book Page 199 Tuesday, September 26, 2006 8:38 AM

Breakdown assistance224
–Engage 1st gear or if your vehicle is fitted with an automatic
gearbox, position the selector lever into position P.
– If a trailer is coupled, uncouple it.
– Take the vehicle tool kit and the spare wheel ⇒page 222 out of
the luggage compartment.
WARNING
•If you find yourself in flowing traffic switch on the hazard warning lights system and place the warning tria ngle on the side of the road at the prescribed distance from your vehicl e while observing all national legal provisions. In this way you are protecting not only yourself but also other road users.
•Never start the engine with the vehi cle sitting on the raised jack - danger of suffering injury!
Caution
If you have to change a wheel on a slope first block the opposite wheel with a stone or similar object in order to secure the vehicle from unexpectedly rolling away.
Note
Comply with the national legal regulations.
Changing a wheel
Always change a wheel on a level surface as far as possible.
– Take off the full wheel trim* ⇒page 225 or the caps ⇒page 226.
– In the case of light alloy wheels remove the wheel trim cap
⇒ page 226.
– Slacken the wheel bolts ⇒page 227.
– Jack up the vehicle until the wheel to be changed is clear of the
ground ⇒page 227.
– Unscrew the wheel bolts and place them on a clean surface (cloth,
paper etc.).
– Take off the wheel.
– Fit on the spare wheel and tighten the wheel bolts slightly.
– Lower the car.
– Tighten the wheel bolts firmly, alternately and diagonally using the
wheel wrench ⇒page 227.
– Mount the full wheel trim/wh eel trim cap or the caps.
Note
•All bolts must be clean and must turn easily.
•You must never grease or oil the wheel bolts!
•When fitting on unidirectional tyres, ensure that the tyres rotate in the correct direction ⇒page 213.
Subsequent steps
After changing the wheel, you must perform the following steps.
NKO A05Fabia 20.book Page 224 Tuesday, September 26, 2006 8:38 AM

Breakdown assistance226
into the wheel, can result in damage to the guide and centering elements of the full wheel trim.
•First check for yourself that the theft-deterrent wheel bolt is located ⇒ page 228, “Securing wheels against being stolen*” in the hole in the area of the valve before fitting the full wheel trim onto a steel wheel which is attached with a theft-deterrent wheel bolt.
Wheel trim caps*
Pulling off
– Carefully ⇒fig. 157 lever off the wheel trim cap using the removal
hook .
Wheel bolts with caps*
The caps are designed to protect the wheel bolts.
Pulling off
–Insert the plastic clip (in the car tool kit) sufficiently far onto the
cap until the inner catches of the clip are positioned at the collar of
the cap.
– Pull the cap off with the plastic clip ⇒fig. 158.
Installing
– Insert the caps onto the bolts.
Fig. 157 Pulling off the wheel trim cap
Fig. 158 Changing a wheel: Pull off cap from the wheel bolt
NKO A05Fabia 20.book Page 226 Tuesday, September 26, 2006 8:38 AM

Breakdown assistance228
– Position the lifting jack below the jacking point and move it up until
its claw is positioned directly below the vertical web of the lower
sill.
– Align the lifting jack so that its claw grasps the web of the lower sill
and the moving base plate of the jack is resting flat against
firm ground.
– Turn the lifting jack up further unt il the wheel is just clear of the
ground.
Ground below the lifting jack which is soft and slippery can cause the vehicle to slip off the jack. It is therefor e always necessary to place the lifting jack on a solid surface or use a wide and stable base. Use a non-slip base (e.g. a rubber foot mat) if the surface is smooth, such as cobbled stones, a tiled floor, etc.
WARNING
•Always raise the vehicle with the doors closed - risk of injury.
•Take suitable measures to prevent the base of the lifting jack from slipping off - risk of injury!
•Place the lifting jack only on a solid and even surface.
•Not positioning the lifting jack at the specified points can result in damage to the vehicle. The jack can also slip off if it does not have suffi- cient grip - risk of injury!
•Never start the engine if the vehicl e is lifted - risk of accident.
•Never lie under the vehicle if the vehicle is only lifted with the vehicle lifting jack.
•It is important to support the vehicle with suitable supporting blocks if you wish to work under the lifted vehicle - risk of injury!
Securing wheels against being stolen*
You need a special adapter for slackening the safety wheel
bolts.
– Pull off the full wheel trim/cap from the wheel hub or cap from the
safety wheel bolt.
– Insert the adapter with its toothed side fully into the inner
toothing of the safety wheel bolt right down in such a way that
only the outer hexagon is jutting out ⇒fig. 161.
– Insert the wheel wrench fully onto the adapter .
– Slacken the wheel bolt, or tighten it firmly ⇒page 227.
– Reinstall the full wheel trim/wheel cap after removing the adapter
or place the cap onto the safety wheel bolt.
AAAB
Fig. 161 Safety wheel bolt with adapter
AB
AA
AB
NKO A05Fabia 20.book Page 228 Tuesday, September 26, 2006 8:38 AM

Fuses and light bulbs242
– For headlights with module (halogen lamp H7) ⇒page 241,
fig. 173 turn the connector with the halogen lamp to the left up to
the stop and remove.
– For headlights with reflector (halogen lamp H4) pull off the
connector from the lamp, release the sprung wire clamp and pull
out the halogen lamp towards the rear.
– Replace the halogen lamp H7, insert the connector with the new
halogen lamp and turn to the right up to the stop.
– Replace the halogen lamp H4, insert into the opening in the
reflector (with the fixing lugs in the recesses), secure with the
sprung wire clamp, position the protective cap and mount the
connector.
– We recommend that you have the headlight setting checked by a
Skoda Service Partner after replacing the light bulb.
Turn signal light (at the front)
– Open the bonnet.
– Turn the lamp holder to the left ⇒page 241, fig. 171 and
remove the lamp holder with the light bulb.
– Replace the defective light bulb.
– Insert the lamp holder with light bulb into the headlight. Secure the
lamp holder by turning it to th e right until it locks in place.
Parking light at the front
– Open the bonnet.
– Remove the protective cap ⇒page 241, fig. 171.
– Grasp the light bulb holder an d pull it out of the headlight.
– Replace the light bulb in the light bulb holder and re-insert into the
headlight.
Fog lights
– Remove the grille next to the fog light (for turning light) or the grille
around the round fog light (for fog light) ⇒page 232.
– Release the screws ⇒fig. 174 and remove the fog light.
AC
AB
Fig. 174 Structure of the light bulb of the fog light
NKO A05Fabia 20.book Page 242 Tuesday, September 26, 2006 8:38 AM

Fuses and light bulbs243
Using the systemSafetyDriving TipsGeneral MaintenanceBreakdown assistanceTechnical Data
– Turn the connector with the light bulb up to the stop towards the
left and remove.
– Change the light bulb, put the co nnector back into the headlight
and secure by turning to the right.
– Put the fog light in place with the catch on the side opposite the
grille and then press in the opposite part. Applies to turning light,
for round fog light screw in the 3 screws.
– Screw in the screws ⇒page 242, fig. 174 and re-insert the grille
⇒ page 232.
Storage compartment lighting*
We recommend having the light bulb replaced by a Škoda Service
Par tner.
– Push in a knife or similar from the side between the light and the
glove compartment ⇒fig. 175. Lever out the light carefully.
– Disconnect the plug connector.
– Replace the defective light bulb.
– Recreate the plug connection.
– Press the light into the glove compartment from below.
Interior light and reading light*
– Pull the diffusion disk (see arrow) downwards from the housing
⇒ fig. 176.
– Take the faulty light bulb out of the interior light and insert a new
one.
Fig. 175 Remove lighting in storage compartment on front passenger side
Fig. 176 Remove interior light
NKO A05Fabia 20.book Page 243 Tuesday, September 26, 2006 8:38 AM

Index253
R
Radiator fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 205
Radio
Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Radio systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Raise vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Rear fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Rear mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Rear seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Rear window heater . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Recharge battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Recirculated air mode
Air conditioning system . . . . . . . . . . . . . . . . . . . . 97
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Remote control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Synchronisation . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Replacing bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239
Replacing fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 235
Replacing the wiper blades . . . . . . . . . . . . . . . . . . . . 66
Roof aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
Running in the car . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
S
Safe securing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Safety information
Engine compartment . . . . . . . . . . . . . . . . . . . . . 198
Saving electrical energy . . . . . . . . . . . . . . . . . . . . . . 175
Seat belt height adjuster . . . . . . . . . . . . . . . . . . . . . 142
Seat belt warning light . . . . . . . . . . . . . . . . . . . . . . . 141
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
fastening . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Height adjustment . . . . . . . . . . . . . . . . . . . . . . . 142
Safety information . . . . . . . . . . . . . . . . . . . . . . . 140
taking off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Selector lever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Selector lever positions . . . . . . . . . . . . . . . . . . . . . . 113
Service Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Service Interval Display . . . . . . . . . . . . . . . . . . . . . . . 16
Setting temperature
Air conditioning system . . . . . . . . . . . . . . . . . . . 95
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Setting the clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Shifting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Side airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
Side lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Snow chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Spare wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Stability programme (ESP) . . . . . . . . . . . . . . . . . . . . 165
Starting the engine . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Diesel engines . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Petrol engines . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Steering force assistance . . . . . . . . . . . . . . . . . . . . . 170
Storage compartment
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Storage compartments . . . . . . . . . . . . . . . . . . . . . . . . 84
Storage facilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Sun visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Switch in the driver door
Power windows . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Switching lights on and off . . . . . . . . . . . . . . . . . . . . 56
Switching off the engine . . . . . . . . . . . . . . . . . . . . . 106
T
Tailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Taking care of your vehicle . . . . . . . . . . . . . . . . . . . 185
TCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Telephone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Temperature
outside . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
the first 1 500 kilometres . . . . . . . . . . . . . . . . . . . . . 173
The roof luggage rack system . . . . . . . . . . . . . . . . . . 79
Thickness of brake pads
Warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Tilting roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Tiptronic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
NKO A05Fabia 20.book Page 253 Tuesday, September 26, 2006 8:38 AM