wheel bolts TATA SAFARI 2015 Owners Manual

125
R RR R
R
epair epairepair epair
epair
ing a ing a ing a ing a
ing a
T TT T
T
yr yryr yr
yr
e ee e
e
•Mark suitability the tyre position (if original colour dot mark is
not visible) with reference to valve stem hole to ensure that the
tyre is refitted in original location.
•Ensure that balancing weights are not disturbed during removal
of tyres.
•Check the balance weight prior to removal of tyre if found loose,
mark its location on rim & refit properly. Balance the wheel after
every dismantling and assembly of tyre on wheel rim.
•Tightening torque of wheel nut is 12-15 mkg.
•While fitting wheels on vehicle ensure that wheel bolts are free
from dust, scratches, dirt, dents, etc.
•Do not apply any oil on the wheel nut or bolt. Wipe off if present.
T TT T
T
YRES YRESYRES YRES
YRESM A I N T E N A N C E
ProCarManuals.com

139
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
PROBABLE CAUSE PROBABLE CAUSEPROBABLE CAUSE PROBABLE CAUSE
PROBABLE CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
3 . Brake pulling to one side Oil on the lining/pad•Clean the pad lining
One side shoe (pad) worn
•Get the shoe pad replaced
Loose brake anchor plate
•Tighten the bolts
Wheel adjustment disturbed
•Adjust
Unequal tyre pressure
•Adjust
One side brake pipe clogged
•Get the brake line cleaned &
bleed the system
4. Brake grab Improperly adjusted parking brake
•Get correctly adjusted
Brake fluid container breather hole
•Clean the hole on the container
clogged
No brake pedal free play/brake pedal
•Adjust brake pedal
not returning fully
Defective tandem master cylinder
•Replace/rectify tandem master
cylinder
5. Brake Squeal Defective brake lining/pad
•Replace
Glazed lining/pad
•Clean or replace lining/pad
Loose rivets
•Install rivets properly
Wrong lining/pad
•Install correct lining/pad
Shoe return spring broken
•Replace
Front pads /Antisqueal shims rubbing
•Get corrected
on the disc
PRELIMINAR PRELIMINARPRELIMINAR PRELIMINAR
PRELIMINAR
Y Y Y Y
Y
TR TRTR TR
TR
OUBLE SHOO OUBLE SHOOOUBLE SHOO OUBLE SHOO
OUBLE SHOO
TING TINGTING TING
TINGPRELIMINARY TROUBLE SHOOTING
ProCarManuals.com

147
S E R V I C E S C H E D U L ESERVICE SCHEDULE SERVICE SCHEDULESERVICE SCHEDULE SERVICE SCHEDULE
SERVICE SCHEDULE
SR SRSR SR
SR
x 1000 km x 1000 kmx 1000 km x 1000 km
x 1000 km
NO NONO NO
NO
OPER OPEROPER OPER
OPER
A AA A
A
TIONS TIONSTIONS TIONS
TIONS
FREQUENCY FREQUENCYFREQUENCY FREQUENCY
FREQUENCY
1-1.5 1-1.51-1.5 1-1.5
1-1.5
15 1515 15
15
30 3030 30
30
45 4545 45
45
60 6060 60
60
75 7575 75
75
90 9090 90
90
105 105105 105
105
9 Change vacuum hoses fotr Vacuum Modulator, Turbocharger, EGR valve & throttle valve 60,000 km x
OR 4 Years whichever is earlier
GEAR BOX GEAR BOXGEAR BOX GEAR BOX
GEAR BOX
1 *Change oil in gear box (First at 45,000 KM, there after every 90,000 KM) x x
2 Change oil in transfer case 45,000 KM x x
3 Clean breather in gear box (also Transfer case in case of 4X4)
Every Oil Changexx
PROPELLER SHAFT PROPELLER SHAFTPROPELLER SHAFT PROPELLER SHAFT
PROPELLER SHAFT
1 Grease propeller shaft with grease gun (at slip joint - splines end) & Check Centre bracket 15,000 km x x x x x x x
mounting bolts for looseness. Tighten if necessary
FRONT AXLE (for 4x4) / REAR AXLE FRONT AXLE (for 4x4) / REAR AXLEFRONT AXLE (for 4x4) / REAR AXLE FRONT AXLE (for 4x4) / REAR AXLE
FRONT AXLE (for 4x4) / REAR AXLE
1 Change oil in axle (First at 15,000 KM, there after every 75,000 KM) x x
2 Clean breather in Axle Every Service x x x x x x x
SUSPENSION & STEERING SUSPENSION & STEERINGSUSPENSION & STEERING SUSPENSION & STEERING
SUSPENSION & STEERING
1 Grease idler arm (seal type idler arm) 15,000 km x x x x x x x
2 Check wheel alignment & balancing, chassis height & adjust if necessary 15,000 km x x x x x x x
3 Check condition of rubber bushes in the following & replace if necessary. 1)Top wishbone 30,000 km x x x
2)Lower wishbone 3)Anti roll bars 4)Rear links 5)Panhard rod 6) Vibration damper
4 Check shock absorber, its bushes & steering damper bushes, replace if necessary 30,000 km x x x
5 Grease steering spindle and sleeve 30,000 km x x x
6 Check & adjust front wheel bearing play & Change grease in front hubs 45,000 km x x
7 Change oil in power steering system & change filter element 75,000 km x
CLUTCH & BRAKES CLUTCH & BRAKESCLUTCH & BRAKES CLUTCH & BRAKES
CLUTCH & BRAKES
1 Check parking brakes, adjust if necessary15,000 km x x x x x x x
2 Check front brake pads & rear brake linings. Replace if necessary 15,000 km x x x x x x x
3 Change Clutch & Brake Fluid (Or 2 years whichever is earlier) 30,000 km x x x
ProCarManuals.com