low beam TOYOTA AVENSIS 2003 Service User Guide

650SR±01


78
9
654 3 2 1
10
11
121314151617I33101
I35771
±
LIGHTING LIGHTING SYSTEM
65±9
AVENSIS REPAIR MANUAL (RM1018E)
INSPECTION
1. HEADLAMP DIMMER SWITCH ASSY
(a) Inspect light control switch continuity.
(1) Check that there is continuity between the terminalsat each switch position as shown in the chart.
Standard:
Switch operationTester connectionSpecified condition
OFF±No continuity
TAIL14 ± 16Continuity
HEAD13 ± 16 ± 14Continuity
(b) Inspect headlight dimmer switch continuity. (1) Check that there is continuity between the terminalsat each switch position as shown in the chart.
Standard:
Switch operationTester connectionSpecified condition
FLASH7 ± 8 ± 16Continuity
LOW BEAM16 ± 17Continuity
HI BEAM7 ± 16Continuity
(c) Inspect turn signal switch continuity. (1) Check that there is continuity between the terminalsat each switch position as shown in the chart.
Standard:
Switch operationTester connectionSpecified condition
Right turn2 ± 3Continuity
Neutral±No continuity
Left turn1 ± 2Continuity
(d) Inspect front fog light switch continuity. (1) Check that there is continuity between the terminalsat each switch position as shown in the chart.
Standard:
Switch operationTester connectionSpecified condition
OFF±No continuity
Front fog switch ON10 ± 11Continuity
Rear fog switch ON10 ± 12Continuity
2. HAZARD WARNING SIGNAL SWITCH ASSY
(a) Check that there is continuity between the terminals at each switch position as shown in the chart.
Standard:
Switch operationTester connectionSpecified condition
OFF1 ± 4No continuity
ON1 ± 4Continuity
Illumination circuit8 ± 9Continuity
http://vnx.su

38AVENSIS (EWD526E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD : 1AZ–FSE]
A5
F6
C6
A10
H2
H6
F11
F9
(*1)
(*2) *1:w/ HID
*2:w/o HID
F10
F2
E4
A6
A4
E5
F5
B1
H1
H5
E2
F7
F8
H9C2H10F16H7C1H8B3B2F13F12
H12A12A3C3A11H3F4H4H11A1A2E1A9F3F1
C5
(A/T)
(*1)
(*2)
(M/T)
A 1 A/C Ambient Temp. Sensor
A 2 A/C Condenser Fan Motor
A 3 A/C Pressure Sensor
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Air Flow Meter
A 9 Airbag Sensor Front LH
A 10 Airbag Sensor Front RH
A 11 Alternator
A 12 Alternator
B 1 Back–Up Light SW
B 2 Brake Booster Pressure Sensor
B 3 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Compressor Assembly
C 5 Counter Gear Speed Sensor
C 6 Crankshaft Position Sensor
E 1 ECT Solenoid
E 2 EFI Water Temp. Sensor
E 4 Electronic Driver Unit
E 5 Electronic Driver Unit
F 1 Front Clearance Light LH
F 2 Front Clearance Light RH
F 3 Front Fog Light LH F 4 Front Fog Light RH
F 5 Front Side Turn Signal Light LH
F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
Headlight Control ECU LH
F 8 Front Turn Signal Light LH Headlight LH (Low)
F 9 Front Turn Signal Light RH Headlight Control ECU RH
F 10 Front Turn Signal Light RH Headlight RH (Low)
F 11 Front Washer Motor
F 12 Front Window Deicer
F 13 Front Wiper Motor
F 16 Fuel Pressure Sensor
H 1 Headlight Beam Level Control Actuator LH
H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 7 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 8 Heated Oxygen Sensor (Bank 1 Sensor 2)
H 9 Heated Oxygen Sensor (Bank 2 Sensor 1)
H 10 Heated Oxygen Sensor (Bank 2 Sensor 2)
H 11 Horn LH
H 12 Horn RH
http://vnx.su

40AVENSIS (EWD526E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD : 1AZ
–FE]
A5
F6
C6
A10
H2
H6
F11
F9(*1)
(*2) *1:w/ HID
*2:w/o HID
F10
F2
F5
A6
A4
B1
H1
E2
H5
F7
F8
A8C2H10A7C1H8B3F13F12
H12A12A3C3A11H3F4H4H11A1A2E1A9F3F1
C5
(A/T)
(*1)
(*2)
(M/T)
A 1 A/C Ambient Temp. Sensor
A 2 A/C Condenser Fan Motor
A 3 A/C Pressure Sensor
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Air Flow Meter
A 7 Air Fuel Ratio Sensor (Bank 1 Sensor 1)
A 8 Air Fuel Ratio Sensor (Bank 2 Sensor 1)
A 9 Airbag Sensor Front LH
A 10 Airbag Sensor Front RH
A 11 Alternator
A 12 Alternator
B 1 Back–Up Light SW
B 3 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Compressor Assembly
C 5 Counter Gear Speed Sensor
C 6 Crankshaft Position Sensor
E 1 ECT Solenoid
E 2 EFI Water Temp. Sensor
F 1 Front Clearance Light LH
F 2 Front Clearance Light RH F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Turn Signal Light LH
F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
Headlight Control ECU LH
F 8 Front Turn Signal Light LH Headlight LH (Low)
F 9 Front Turn Signal Light RH Headlight Control ECU RH
F 10 Front Turn Signal Light RH Headlight RH (Low)
F 11 Front Washer Motor
F 12 Front Window Deicer
F 13 Front Wiper Motor
H 1 Headlight Beam Level Control Actuator LH
H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 8 Heated Oxygen Sensor (Bank 1 Sensor 2)
H 10 Heated Oxygen Sensor (Bank 2 Sensor 2)
H 11 Horn LH
H 12 Horn RH
http://vnx.su

42AVENSIS (EWD526E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD : 1ZZ–FE, 3ZZ–FE]
A5
F6
A12
A10
H2
H6
F11
F9
(*1)
(*2) *1:w/ HID
*2:w/o HID
F10
F2
F5
A6
A4
E2
B1
H1
H5
F7
F8
C2C6C1A11H7B3F13F12
A1H12A3C3H3F4H4H11E1A9F3F1
(*1)
(*2)
A 1 A/C Ambient Temp. Sensor
A 3 A/C Pressure Sensor
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Air Flow Meter
A 9 Airbag Sensor Front LH
A 10 Airbag Sensor Front RH
A 11 Alternator
A 12 Alternator
B 1 Back–Up Light SW
B 3 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Compressor Assembly
C 6 Crankshaft Position Sensor
E 1 ECT Solenoid
E 2 EFI Water Temp. Sensor
F 1 Front Clearance Light LH
F 2 Front Clearance Light RH
F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Turn Signal Light LH
F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
Headlight Control ECU LH
F 8 Front Turn Signal Light LH
Headlight LH (Low)
F 9 Front Turn Signal Light RH Headlight Control ECU RH
F 10 Front Turn Signal Light RH
Headlight RH (Low)
F 11 Front Washer Motor
F 12 Front Window Deicer
F 13 Front Wiper Motor
H 1 Headlight Beam Level Control Actuator LH
H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 7 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 11 Horn LH
H 12 Horn RH
http://vnx.su

44AVENSIS (EWD526E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[LHD : 1CD
–FTV]
E5
F6
A5
A10
E7
C6
E4
H2
H6
F11
F9(*1)
(*2) *1:w/ HID
*2:w/o HID
*3:Power Heater
(Hot Gas Type)
*4:Power Heater
(Electrical Type)
F10
F2
G2
A4
A6
F5
H1
H5
F7
F8
A12C1A11G1F18E3E2F16F17F15B3F13F12
H12C3A3A3
(*3) (*4)C4H3F4H4H11A1A2D1A9F3F1
B1
(*2) (*1)
F14
A 1 A/C Ambient Temp. Sensor
A 2 A/C Condenser Fan Motor
A 3 A/C Pressure Sensor
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Air Flow Meter
A 9 Airbag Sensor Front LH
A 10 Airbag Sensor Front RH
A 11 Alternator
A 12 Alternator
B 1 Back–Up Light SW
B 3 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 3 Compressor Assembly
C 4 Condenser Assembly
C 6 Crankshaft Position Sensor
D 1 Diesel Throttle Control Motor
E 2 EFI Water Temp. Sensor
E 3 EGR Valve Control Motor
E 4 Electronic Driver Unit
E 5 Electronic Driver Unit
E 7 Engine Oil Level Sensor
F 1 Front Clearance Light LH
F 2 Front Clearance Light RH
F 3 Front Fog Light LH
F 4 Front Fog Light RH F 5 Front Side Turn Signal Light LH
F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
Headlight Control ECU LH
F 8 Front Turn Signal Light LH Headlight LH (Low)
F 9 Front Turn Signal Light RH Headlight Control ECU RH
F 10 Front Turn Signal Light RH Headlight RH (Low)
F 11 Front Washer Motor
F 12 Front Window Deicer
F 13 Front Wiper Motor
F 14 Fuel Filter Warning SW
F 15 Fuel Heater
F 16 Fuel Pressure Sensor
F 17 Fuel Pump
F 18 Fuel Temp. Sensor
G 1 Glow Plug
G 2 Glow Plug Relay
H 1 Headlight Beam Level Control Actuator LH
H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 11 Horn LH
H 12 Horn RH
http://vnx.su

58AVENSIS (EWD526E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[RHD : 1AZ–FSE]
A5
F6
C6
A10
A11
H2
H6
F11
F9
(*1)
(*2) *1:w/ HID
*2:w/o HID
F10
F2
E4
A6
A4
E5
F5
B1
H1
E2
H5
F7
F8
F13B3C2B2H9F16H10C1H7H8
A1E6H12A12C3H3F4H4A2H11A3E1A9F3F1
C5
(A/T)
(*1)
(*2)
(M/T)
A 1 A/C Ambient Temp. Sensor
A 2 A/C Condenser Fan Motor
A 3 A/C Pressure Sensor
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Air Flow Meter
A 9 Airbag Sensor Front LH
A 10 Airbag Sensor Front RH
A 11 Alternator
A 12 Alternator
B 1 Back–Up Light SW
B 2 Brake Booster Pressure Sensor
B 3 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Compressor Assembly
C 5 Counter Gear Speed Sensor
C 6 Crankshaft Position Sensor
E 1 ECT Solenoid
E 2 EFI Water Temp. Sensor
E 4 Electronic Driver Unit
E 5 Electronic Driver Unit
E 6 Engine Hood Courtesy SW
F 1 Front Clearance Light LH
F 2 Front Clearance Light RH F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Turn Signal Light LH
F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
Headlight Control ECU LH
F 8 Front Turn Signal Light LH Headlight LH (Low)
F 9 Front Turn Signal Light RH Headlight Control ECU RH
F 10 Front Turn Signal Light RH
Headlight RH (Low)
F 11 Front Washer Motor
F 13 Front Wiper Motor
F 16 Fuel Pressure Sensor
H 1 Headlight Beam Level Control Actuator LH
H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 7 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 8 Heated Oxygen Sensor (Bank 1 Sensor 2)
H 9 Heated Oxygen Sensor (Bank 2 Sensor 1)
H 10 Heated Oxygen Sensor (Bank 2 Sensor 2)
H 11 Horn LH
H 12 Horn RH
http://vnx.su

62AVENSIS (EWD526E)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[RHD : 1ZZ–FE, 3ZZ–FE]
A5
F6
A12
A10
H2
H6
F11
F9
(*1)
(*2) *1:w/ HID
*2:w/o HID
F10
F2
F5
A4
A6
B1
H1
H5
F7
F8
C2C6F13B3C1A11H7E2
A1E6H12C3H3F4H4H11A3E1A9F3F1
(*1)
(*2)
A 1 A/C Ambient Temp. Sensor
A 3 A/C Pressure Sensor
A 4 ABS Speed Sensor Front LH
A 5 ABS Speed Sensor Front RH
A 6 Air Flow Meter
A 9 Airbag Sensor Front LH
A 10 Airbag Sensor Front RH
A 11 Alternator
A 12 Alternator
B 1 Back–Up Light SW
B 3 Brake Fluid Level Warning SW
C 1 Camshaft Position Sensor
C 2 Camshaft Timing Oil Control Valve
C 3 Compressor Assembly
C 6 Crankshaft Position Sensor
E 1 ECT Solenoid
E 2 EFI Water Temp. Sensor
E 6 Engine Hood Courtesy SW
F 1 Front Clearance Light LH
F 2 Front Clearance Light RH
F 3 Front Fog Light LH
F 4 Front Fog Light RH
F 5 Front Side Turn Signal Light LH
F 6 Front Side Turn Signal Light RH
F 7 Front Turn Signal Light LH
Headlight Control ECU LH
F 8 Front Turn Signal Light LH Headlight LH (Low)
F 9 Front Turn Signal Light RH Headlight Control ECU RH
F 10 Front Turn Signal Light RH Headlight RH (Low)
F 11 Front Washer Motor
F 13 Front Wiper Motor
H 1 Headlight Beam Level Control Actuator LH
H 2 Headlight Beam Level Control Actuator RH
H 3 Headlight Cleaner Control Relay
H 4 Headlight Cleaner Motor
H 5 Headlight LH (High)
H 6 Headlight RH (High)
H 7 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 11 Horn LH
H 12 Horn RH
http://vnx.su

222AVENSIS (EWD526E)
Headlight (w/ Daytime Running Light)
23
From Power Source System
(
See Page 120 )
7. 5A
ECU–B 2
6
CC
10
CD
3DB 1625A
DOOR
W–R
W–RB
1
2
B A
AC
IC2
15
C2
HRLY
R–Y
R–Y
R–Y
J 6 (
A )
, J 7 (
B )
I14
(
A )
W–B
E
25
DA
9
R–Y
∗
2 : 1CD–FTV
∗
1 : Gasoline
1
1DN 1
2
5
3
7. 5A PANEL
13
TRLY
TAIL Relay
INTB
15
DJ
9
DB
19
1
(∗ 1 )
B–G (
∗ 2 )
ED1
1
14D
140A ALT
120A ALT (
∗ 3 )
100A ALT (
∗ 4 )
FL MAIN
3. 0W
Battery
2
W
1
2
3
(∗ 1 )
B–G
1
B
34
B
(
∗ 2 ) B–L
( ∗ 2 )
G–W
IJ
W–B
BIntegration Relay
Junction
Connector
∗
3 : 1AZ–FSE, 1AZ–FE
∗ 4 : 1ZZ–FE, 3ZZ–FE
AVENSIS (EWD526E) 223
R–B
E 1
R–Y 2
W–L
1
1
From Power Source System
(
See Page 120 )
40A
MAIN
W–B
W–B
W–R
J 2
W–B
R–B
( w/o HID )
W–B
W–B
( w/ HID )
W–B
( w/o HID )
W–B W–B
(w/o HID ) R
( w/o HID )
( w/ HID )
A
A 1
2
EC
1
2 2 15A
H–LP RH
15A
H–LP LH
(
w/ HID )
R–B
2
(
w/ HID )
R
1
2
W–B
F 9 F 7
1
22
W–R W–R
R–L
R–B R–L
W–R
R–Y
DIM Relay H–LP Relay
J 3(
A )
, J 4 (
B )
14 A
22
DIM
22
6IB1
32
51
22
W–L
22
1
EA
DB
3
52
I14 (
A )
1 2
1
2
F10 F 8
Integration Relay
Headlight Control ECU LH Headlight LH (
Low )
Headlight Control ECU RH
Headlight RH (
Low )
Junction
Connector
Junction
Connector
224
AVENSIS (EWD526E)
Headlight (w/ Daytime Running Light)
J 6
(
A )
, J 7 (
B )
H 5
H 6
W–B W–B R–B
18
R–W
W–B R–Y
R–W
R–Y
R–W
R–Y
( w/ HID )
R–Y
( w/ HID )
R–Y
( w/o HID )
R–L
W–B W–B R–Y
HH
F
HU
3IC3
9IC3
7
13 8
Head Tail
OFFLight
Control SW
16 DA
28 A
6A 13
EA
AB
EB DA
DA
EB
2
3
2
3 2
10A
H–LP
HI RH
2 2
10A
H–LP
HI LH
1
R–W
J 3(
A )
, J 4 (
B )
R–L
1
22
Flash
Dimmer S WHighLow
I14
(
A )
C12Integration Relay
Combination SW
Headlight LH (
High )
Headlight RH (
High )
Junction Connector
Junction Connector
IL : ∗2
IO : ∗ 1 W–B
W–B
AVENSIS (EWD526E) 225
HB
A IP
6CA 6CK
13 A
5B
A
2B 21
A
14 B
20
A6B
12 6CD 7CA
HB FA
1
W–B
22
J1 6
R–WW–B W–B
R–W
A
BEAN
I/F
P–BGR
E 9
(
A )
, E10 (
B )
,
E11 (
C )
, E12 (
D )
A1 3(
A )
, A15 (
B )
10
C10 (
A )
, C11 (
B )
J 8 (
A )
, J 9 (
B )
CPU
IC1
MPX1
W–R
High Beam
IC1
MPX2
MPX2
P–B
P–B
W–R R–W
MPX1 MPX–
MPX+
From Power Source System
(
See Page 120 )
4
11 A
A9
P
∗ 8 : Automatic A/C
∗
7 : Except Automatic A/C
∗
4 : 1ZZ–FE, 3ZZ–FE (
∗ 7 )
DB
B
10 (
∗ 8 )
B
18
A
23 (
∗ 5 )
A
20 (
∗ 2 ) A
21 (
∗ 2 )
A
29 (
∗ 5 )
B
29 (
1AZ–FSE )
7. 5A
RAD
NO. 1
B
20 (
∗ 8 )
A
29
10A
GAUGE1
DB
7
GR
(
∗ 7 )
P
P
AF
R–W
7. 5A
DOME
6
1
2
∗ 2 : 1CD–FTV RL
C
21 (
1AZ–FSE )
B
28 (
1AZ–FE )
A
27 (
∗ 4 )
( ∗ 2 )
9D
IK1
9
ACC IG
21 22
I14
(
A )
Y
Y
Y
(∗ 6 )
(
∗ 5 )
(
∗ 5 )
4
A1 1L
∗
6 : 1AZ–FSE, 1CD–FTV
J1 0 (
A )
, J11 (
B )
P
Alternator
A/C Control Assembly
Integration Relay
Combination Meter
Engine and ECT ECU (
A/T )
Engine ECU (
M/T ) Junction
Connector
Junction
Connector
Junction
Connector ∗
1 : Gasoline
∗ 5 : 1AZ–FE, 1ZZ–FE, 3ZZ–FE
W–B A
http://vnx.su

222AVENSIS (EWD526E)
Headlight (w/ Daytime Running Light)
23
From Power Source System
(
See Page 120 )
7. 5A
ECU–B 2
6
CC
10
CD
3DB 1625A
DOOR
W–R
W–RB
1
2
B A
AC
IC2
15
C2
HRLY
R–Y
R–Y
R–Y
J 6 (
A )
, J 7 (
B )
I14
(
A )
W–B
E
25
DA
9
R–Y
∗
2 : 1CD–FTV
∗
1 : Gasoline
1
1DN 1
2
5
3
7. 5A PANEL
13
TRLY
TAIL Relay
INTB
15
DJ
9
DB
19
1
(∗ 1 )
B–G (
∗ 2 )
ED1
1
14D
140A ALT
120A ALT (
∗ 3 )
100A ALT (
∗ 4 )
FL MAIN
3. 0W
Battery
2
W
1
2
3
(∗ 1 )
B–G
1
B
34
B
(
∗ 2 ) B–L
( ∗ 2 )
G–W
IJ
W–B
BIntegration Relay
Junction
Connector
∗
3 : 1AZ–FSE, 1AZ–FE
∗ 4 : 1ZZ–FE, 3ZZ–FE
AVENSIS (EWD526E) 223
R–B
E 1
R–Y 2
W–L
1
1
From Power Source System
(
See Page 120 )
40A
MAIN
W–B
W–B
W–R
J 2
W–B
R–B
( w/o HID )
W–B
W–B
( w/ HID )
W–B
( w/o HID )
W–B W–B
(w/o HID ) R
( w/o HID )
( w/ HID )
A
A 1
2
EC
1
2 2 15A
H–LP RH
15A
H–LP LH
(
w/ HID )
R–B
2
(
w/ HID )
R
1
2
W–B
F 9 F 7
1
22
W–R W–R
R–L
R–B R–L
W–R
R–Y
DIM Relay H–LP Relay
J 3(
A )
, J 4 (
B )
14 A
22
DIM
22
6IB1
32
51
22
W–L
22
1
EA
DB
3
52
I14 (
A )
1 2
1
2
F10 F 8
Integration Relay
Headlight Control ECU LH Headlight LH (
Low )
Headlight Control ECU RH
Headlight RH (
Low )
Junction
Connector
Junction
Connector
224
AVENSIS (EWD526E)
Headlight (w/ Daytime Running Light)
J 6
(
A )
, J 7 (
B )
H 5
H 6
W–B W–B R–B
18
R–W
W–B R–Y
R–W
R–Y
R–W
R–Y
( w/ HID )
R–Y
( w/ HID )
R–Y
( w/o HID )
R–L
W–B W–B R–Y
HH
F
HU
3IC3
9IC3
7
13 8
Head Tail
OFFLight
Control SW
16 DA
28 A
6A 13
EA
AB
EB DA
DA
EB
2
3
2
3 2
10A
H–LP
HI RH
2 2
10A
H–LP
HI LH
1
R–W
J 3(
A )
, J 4 (
B )
R–L
1
22
Flash
Dimmer S WHighLow
I14
(
A )
C12Integration Relay
Combination SW
Headlight LH (
High )
Headlight RH (
High )
Junction Connector
Junction Connector
IL : ∗2
IO : ∗ 1 W–B
W–B
AVENSIS (EWD526E) 225
HB
A IP
6CA 6CK
13 A
5B
A
2B 21
A
14 B
20
A6B
12 6CD 7CA
HB FA
1
W–B
22
J1 6
R–WW–B W–B
R–W
A
BEAN
I/F
P–BGR
E 9
(
A )
, E10 (
B )
,
E11 (
C )
, E12 (
D )
A1 3(
A )
, A15 (
B )
10
C10 (
A )
, C11 (
B )
J 8 (
A )
, J 9 (
B )
CPU
IC1
MPX1
W–R
High Beam
IC1
MPX2
MPX2
P–B
P–B
W–R R–W
MPX1 MPX–
MPX+
From Power Source System
(
See Page 120 )
4
11 A
A9
P
∗ 8 : Automatic A/C
∗
7 : Except Automatic A/C
∗
4 : 1ZZ–FE, 3ZZ–FE (
∗ 7 )
DB
B
10 (
∗ 8 )
B
18
A
23 (
∗ 5 )
A
20 (
∗ 2 ) A
21 (
∗ 2 )
A
29 (
∗ 5 )
B
29 (
1AZ–FSE )
7. 5A
RAD
NO. 1
B
20 (
∗ 8 )
A
29
10A
GAUGE1
DB
7
GR
(
∗ 7 )
P
P
AF
R–W
7. 5A
DOME
6
1
2
∗ 2 : 1CD–FTV RL
C
21 (
1AZ–FSE )
B
28 (
1AZ–FE )
A
27 (
∗ 4 )
( ∗ 2 )
9D
IK1
9
ACC IG
21 22
I14
(
A )
Y
Y
Y
(∗ 6 )
(
∗ 5 )
(
∗ 5 )
4
A1 1L
∗
6 : 1AZ–FSE, 1CD–FTV
J1 0 (
A )
, J11 (
B )
P
Alternator
A/C Control Assembly
Integration Relay
Combination Meter
Engine and ECT ECU (
A/T )
Engine ECU (
M/T ) Junction
Connector
Junction
Connector
Junction
Connector ∗
1 : Gasoline
∗ 5 : 1AZ–FE, 1ZZ–FE, 3ZZ–FE
W–B A
http://vnx.su

222AVENSIS (EWD526E)
Headlight (w/ Daytime Running Light)
23
From Power Source System
(
See Page 120 )
7. 5A
ECU–B 2
6
CC
10
CD
3DB 1625A
DOOR
W–R
W–RB
1
2
B A
AC
IC2
15
C2
HRLY
R–Y
R–Y
R–Y
J 6 (
A )
, J 7 (
B )
I14
(
A )
W–B
E
25
DA
9
R–Y
∗
2 : 1CD–FTV
∗
1 : Gasoline
1
1DN 1
2
5
3
7. 5A PANEL
13
TRLY
TAIL Relay
INTB
15
DJ
9
DB
19
1
(∗ 1 )
B–G (
∗ 2 )
ED1
1
14D
140A ALT
120A ALT (
∗ 3 )
100A ALT (
∗ 4 )
FL MAIN
3. 0W
Battery
2
W
1
2
3
(∗ 1 )
B–G
1
B
34
B
(
∗ 2 ) B–L
( ∗ 2 )
G–W
IJ
W–B
BIntegration Relay
Junction
Connector
∗
3 : 1AZ–FSE, 1AZ–FE
∗ 4 : 1ZZ–FE, 3ZZ–FE
AVENSIS (EWD526E) 223
R–B
E 1
R–Y 2
W–L
1
1
From Power Source System
(
See Page 120 )
40A
MAIN
W–B
W–B
W–R
J 2
W–B
R–B
( w/o HID )
W–B
W–B
( w/ HID )
W–B
( w/o HID )
W–B W–B
(w/o HID ) R
( w/o HID )
( w/ HID )
A
A 1
2
EC
1
2 2 15A
H–LP RH
15A
H–LP LH
(
w/ HID )
R–B
2
(
w/ HID )
R
1
2
W–B
F 9 F 7
1
22
W–R W–R
R–L
R–B R–L
W–R
R–Y
DIM Relay H–LP Relay
J 3(
A )
, J 4 (
B )
14 A
22
DIM
22
6IB1
32
51
22
W–L
22
1
EA
DB
3
52
I14 (
A )
1 2
1
2
F10 F 8
Integration Relay
Headlight Control ECU LH Headlight LH (
Low )
Headlight Control ECU RH
Headlight RH (
Low )
Junction
Connector
Junction
Connector
224
AVENSIS (EWD526E)
Headlight (w/ Daytime Running Light)
J 6
(
A )
, J 7 (
B )
H 5
H 6
W–B W–B R–B
18
R–W
W–B R–Y
R–W
R–Y
R–W
R–Y
( w/ HID )
R–Y
( w/ HID )
R–Y
( w/o HID )
R–L
W–B W–B R–Y
HH
F
HU
3IC3
9IC3
7
13 8
Head Tail
OFFLight
Control SW
16 DA
28 A
6A 13
EA
AB
EB DA
DA
EB
2
3
2
3 2
10A
H–LP
HI RH
2 2
10A
H–LP
HI LH
1
R–W
J 3(
A )
, J 4 (
B )
R–L
1
22
Flash
Dimmer S WHighLow
I14
(
A )
C12Integration Relay
Combination SW
Headlight LH (
High )
Headlight RH (
High )
Junction Connector
Junction Connector
IL : ∗2
IO : ∗ 1 W–B
W–B
AVENSIS (EWD526E) 225
HB
A IP
6CA 6CK
13 A
5B
A
2B 21
A
14 B
20
A6B
12 6CD 7CA
HB FA
1
W–B
22
J1 6
R–WW–B W–B
R–W
A
BEAN
I/F
P–BGR
E 9
(
A )
, E10 (
B )
,
E11 (
C )
, E12 (
D )
A1 3(
A )
, A15 (
B )
10
C10 (
A )
, C11 (
B )
J 8 (
A )
, J 9 (
B )
CPU
IC1
MPX1
W–R
High Beam
IC1
MPX2
MPX2
P–B
P–B
W–R R–W
MPX1 MPX–
MPX+
From Power Source System
(
See Page 120 )
4
11 A
A9
P
∗ 8 : Automatic A/C
∗
7 : Except Automatic A/C
∗
4 : 1ZZ–FE, 3ZZ–FE (
∗ 7 )
DB
B
10 (
∗ 8 )
B
18
A
23 (
∗ 5 )
A
20 (
∗ 2 ) A
21 (
∗ 2 )
A
29 (
∗ 5 )
B
29 (
1AZ–FSE )
7. 5A
RAD
NO. 1
B
20 (
∗ 8 )
A
29
10A
GAUGE1
DB
7
GR
(
∗ 7 )
P
P
AF
R–W
7. 5A
DOME
6
1
2
∗ 2 : 1CD–FTV RL
C
21 (
1AZ–FSE )
B
28 (
1AZ–FE )
A
27 (
∗ 4 )
( ∗ 2 )
9D
IK1
9
ACC IG
21 22
I14
(
A )
Y
Y
Y
(∗ 6 )
(
∗ 5 )
(
∗ 5 )
4
A1 1L
∗
6 : 1AZ–FSE, 1CD–FTV
J1 0 (
A )
, J11 (
B )
P
Alternator
A/C Control Assembly
Integration Relay
Combination Meter
Engine and ECT ECU (
A/T )
Engine ECU (
M/T ) Junction
Connector
Junction
Connector
Junction
Connector ∗
1 : Gasoline
∗ 5 : 1AZ–FE, 1ZZ–FE, 3ZZ–FE
W–B A
http://vnx.su