headlights TOYOTA AYGO 2012 (in English) User Guide

302 4-3. Do-it-yourself maintenance
AYGO_WE_99E96E
LED light bulbs
The daytime running lights (if equipped) consist of a number of LEDs. If any
of the LEDs burn out, take your vehicle to any authorized Toyota dealer or
repairer, or another duly qualified and equipped professional to have the
light replaced.
Condensation build-up on the inside of the lens
Contact any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional for more information in the following situations.
Temporary condensation build-up on the inside of the headlight lens does
not indicate a malfunction.
Large drops of water have built up on the inside of the lens.
Water has built up inside the headlight.
When replacing the license plate lights
Be careful not to drop the connector into the installation opening when dis-
connecting it. If the connector drops into the opening, please contact any
authorized Toyota dealer or repairer, or another duly qualified and equipped
professional, because disassembly is required to pick it up.
CAUTION
Replacing light bulbs
Turn off the lights. Do not attempt to replace the bulb immediately after
turning off the lights.
The bulbs become very hot and may cause burns.
Do not touch the glass portion of the light bulb with bare hands. Hold the
bulb by the plastic or metal portion.
If the bulb is scratched or dropped, it may blow out or crack.
Fully install light bulbs and any parts used to secure them. Failure to do so
may result in heat damage, fire, or water entering the headlight unit. This
may damage the headlights or cause condensation to build up on the lens.
To prevent damage or fire
Make sure bulbs are fully seated and locked.

5
329
5-2. Steps to take in an emergency
When trouble arises
AYGO_WE_99E96E
If the engine will not start
If the engine will not start even though correct starting procedures
are being followed (P. 130), consider each of the following points:
The engine will not start even though the starter motor
operates normally.
One of the following may be the cause of the problem:
There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle.
The engine may be flooded.
Try to restart the engine again following correct starting proce-
dures. (P. 130)
There may be a malfunction in the engine immobilizer system.
(P. 7 3 )
The starter motor turns over slowly, the interior lights and
headlights are dim, or the horn does not sound or sounds at
a low volume.
One of the following may be the cause of the problem:
The battery may be discharged. (P. 332)
The battery terminal connections may be loose or corroded.
The starter motor does not turn over, the interior lights and
headlights do not turn on, or the horn does not sound.
One of the following may be the cause of the problem:
One or both of the battery terminals may be disconnected.
The battery may be discharged. (P. 332)
Contact any authorized Toyota dealer or repairer, or another duly
qualified and equipped professional if the problem cannot be
repaired, or if repair procedures are unknown.

5
333 5-2. Steps to take in an emergency
When trouble arises
AYGO_WE_99E96E
To prevent battery discharge
Turn off the headlights and the audio system while the engine is off.
Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic.
Charging the battery
The electricity stored in the battery will discharge gradually even when the
vehicle is not in use, due to natural discharge and the draining effects of cer-
tain electrical appliances. If the vehicle is left for a long time, the battery may
discharge, and the engine may be unable to start. (The battery recharges
automatically during driving.)
Start the engine of the second vehicle. Increase the engine
speed slightly and maintain at that level for approximately 5
minutes to recharge the battery of your vehicle.
Maintain the engine speed of the second vehicle and turn
the engine switch to the “ON” position, then start the vehi-
cle’s engine.
Once the vehicle’s engine has started, remove the jumper
cables in the exact reverse order from which they were con-
nected.
Once the engine starts, have the vehicle inspected at any autho-
rized Toyota dealer or repairer, or another duly qualified and
equipped professional, as soon as possible.

354 6-1. Specifications
AYGO_WE_99E96E
Light bulbs
A: H4 halogen bulbs
B: H11 halogen bulbs
C: Single end bulbs (clear)
D: Single end bulbs (amber)
E: Wedge base bulbs (clear)
Light BulbsWTy p e
ExteriorHeadlights 60/55 A
Front turn signal lights 21 D
Front position lights 5 E
Front fog lights (if equipped) 55 B
Side turn signal lights 5 —
Rear turn signal lights 21 C
Stop/tail lights 21/5 C
License plate lights 5 E
Back-up lights 21 C
Rear fog lights 21 C
High mounted stoplight 5 E
Interior Interior light 5 E

361 Alphabetical index
AYGO_WE_99E96E
If your vehicle becomes
stuck ................................... 339
If your vehicle has to be
stopped in an emergency ... 341
If your vehicle needs to be
towed .................................. 305
If your vehicle overheats ....... 336
Engine
Compartment ........................ 260
Engine switch ........................ 130
Hood ..................................... 254
How to start the
engine ................................. 130
Identification number............. 344
If the engine will not start ...... 329
Ignition switch ....................... 130
Overheating .......................... 336
Engine coolant
Capacity ................................ 350
Checking ............................... 264
Preparing and checking
before winter ....................... 163
Engine immobilizer system ...... 73
Engine oil
Capacity ................................ 347
Checking ............................... 261
Preparing and checking
before winter ....................... 163
Engine switch........................... 130
EPS............................................ 158
Floor mat .................................. 238
Fluid
Washer.................................. 269
Fog lights
Replacing light bulbs ............. 292
Switch ................................... 152
Wattage................................. 354
Front fog lights
Replacing light bulbs ............. 292
Switch ................................... 153Wattage ................................ 354
Front passenger’s seat belt
reminder light ........................ 316
Front position lights
Replacing light bulbs............. 292
Switch ................................... 148
Wattage ................................ 354
Front seats
Adjustment .............................. 52
Front turn signal lights
Replacing light bulbs............. 292
Switch ................................... 140
Wattage ................................ 354
Fuel
Capacity ................................ 347
Fuel gauge ............................ 143
Fuel pump shut off system.... 311
Gas station information ......... 368
Information ............................ 355
Refueling................................. 69
Type ...................................... 347
Fuel door .................................... 69
Fuel filler door............................ 69
Fuel pump shut off system ..... 311
Fuses ........................................ 282
Gas station information .......... 368
Gauges ..................................... 143
Hands-free phone system....... 214
Hazard lights
Switch ................................... 304
Head restraints
Adjusting ................................ 57
Headlights
Replacing light bulbs............. 292
Switch ................................... 148
Wattage ................................ 354
Hood ......................................... 254
Horn .......................................... 142
F
G
H

362 Alphabetical index
AYGO_WE_99E96E
Identification
Engine ................................... 345
Vehicle .................................. 344
Ignition switch.......................... 130
Indicator lights ......................... 145
Inside rear view mirror .............. 64
Interior light
Interior light ........................... 229
Switch ................................... 229
Wattage................................. 354
iPod ........................................... 206
Jack
Positioning a floor jack .......... 257
Vehicle-equipped
jack ..................................... 318
Jack handle .............................. 318
Keys
Engine switch ........................ 130
If you lose your keys ............. 331
Ignition switch ....................... 130
Key number............................. 34
Keys ........................................ 34
Wireless remote control key.... 36
License plate lights
Replacing light bulbs ............. 292
Wattage................................. 354
Light bulbs
Replacing .............................. 292
Wattage................................. 354
Lights
Emergency flasher switch ..... 304
Fog light switch ..................... 152
Hazard light switch ................ 304
Headlights switch .................. 148
Interior light switch ................ 229
Replacing light bulbs ............. 292
Turn signal lever ................... 140
Wattage................................. 354Lock steering column ............. 131
Maintenance
Do-it-yourself maintenance ... 251
Maintenance data ................. 344
Maintenance requirements ... 248
Manual air conditioning
system .................................... 170
Manual headlight leveling
dial .......................................... 149
Manual transmission ............... 138
Meter ......................................... 143
Mirrors
Inside rear view mirror ............ 64
Side mirrors ............................ 65
Vanity mirrors........................ 233
MP3 disc ................................... 200
Multi-mode manual
transmission .......................... 133
Odometer.................................. 143
Oil
Engine oil .............................. 261
Opener
Back door................................ 48
Hood ..................................... 254
Outside rear view mirrors
Adjusting and folding .............. 65
Overheating, Engine................ 336
Parking brake ........................... 141
Power outlets ........................... 237
Power windows.......................... 66I
J
K
L
M
O
P