pre safe TOYOTA HILUX 2021 (in English) Manual Online

5748-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
WARNING
QIf a warning light comes on or a warning buzzer sounds when a warn-
ing message is shown on the multi-information display (vehicles with
multi-information display)
Check and follow the message shown on the multi-information display. Fail-
ure to do so may result in death or serious injury.
Q If both the ABS and the brake system warning lights remain on
Stop your vehicle in a safe place immediately and contact any authorized
Toyota retailer or Toyota authorized r epairer, or any reliable repairer. The
vehicle will become extremely unstable during braking, and the ABS system
may fail, which could cause an accident resulting in death or serious injury.
NOTICE
Q If the malfunction indicator lamp comes on when the boost pressure in
the turbocharger is abnormally high (diesel engine)
Never drive at high speed or race the engine even after the lamp goes off.
Q If the fuel system warning light flashes (diesel engine)
Never drive the vehicle with the warn ing light flashing. Continued driving
with water accumulated in the fuel filter will damage the fuel injection pump.

5778-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
8
When trouble arises
QWarning messages
The warning messages explained below may differ from the actual messages
according to operation conditions and vehicle specifications.
Q If a message about an operation is shown
O If a message about an operation of the engine switch is shown
An instruction for operation of the engine switch is shown when the incor-
rect procedure for starting the engine is performed or the engine switch is
operated incorrectly. Follow the instructions shown on the multi-information
display to operate the engine switch again.
O If a message about a shift lever operation is shown
To prevent the shift lever from being operated incorrectly or the vehicle from
moving unexpectedly, a message that requires shifting the shift lever may
be shown on the multi-information display. In that case, follow the instruc-
tion of the message and shift the shift lever.
O If a message or image about an open/close state of a part or replenishment
of a consumable is shown
Confirm the part indicated by the multi-information display or a warning
light, and then perform the coping method such as closing the open door or
replenishing a consumable.
Q If is shown
The engine oil pressure is too low. (This warning message may be displayed
if the vehicle is stopped on a slope. Move the vehicle to a level surface and
check to see if the message goes off.)
Immediately stop the vehicle in a safe place and contact any authorized
Toyota retailer or Toyota authorized repai rer, or any reliable repairer. Continu-
ing to drive the vehicle may be dangerous.
Q If “Accelerator and Brake Pedals Pressed Simultaneously” is shown
The accelerator and brake pedal are being depressed simultaneously.
( P. 195)
Release the accelerator pedal and depress the brake pedal.
Q If “Windshield washer fluid low” is shown
The washer fluid level is low.
Add washer fluid. ( P. 4 9 8 )

5798-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
8
When trouble arises
QIf a message that indicates the malfunction of front camera is shown
The following systems may be suspended until the problem shown in the
message is resolved. ( P. 271, 566)
O PCS (Pre-Collision System)*
OLDA (Lane Departure Alert With Yaw Assist Function)*
ORSA (Road Sign Assist)*
ODynamic radar cruise control*
*: If equipped
Q If a message that indicates the malfunction of radar sensor is shown
The following systems may be suspended until the problem shown in the
message is resolved. ( P. 271, 566)
O PCS (Pre-Collision System)*
OLDA (Lane Departure Alert With Yaw Assist Function)*
ODynamic radar cruise control*
*: If equipped
Q If “See owner’s manual” is shown
O If the following messages are shown, follow the instructions accordingly.
• “Engine Coolant Temp High Stop in a Safe Place” ( P. 610)
• “Transmission fluid temp high” ( P. 238)
• “Water accumulation in fuel filter” ( P. 499)
• “AdBlue Level Low Fill up AdBlue in 2400 km” ( P. 502)
• “AdBlue level Low No start in 800 km Top up AdBlue” ( P. 502)
• “AdBlue empty Unable to Restart Engine Fill up AdBlue” ( P. 502)
•“DPF full” ( P. 371)
• “Front Camera Temporarily Unavailable” ( P. 271)
O If “Smart Entry & Start System malfunction” is shown, this may be a mal-
function.
Immediately have the vehicle inspected by any authorized Toyota retailer or
Toyota authorized repairer, or any reliable repairer.
O If “Low Braking Power Stop in a Safe Place” is shown, there may be a mal-
function. Immediately stop the vehicle in a safe place and contact any
authorized Toyota retailer or Toyota authorized repairer, or any reliable
repairer. Continuing to drive the vehicle may be dangerous.
O If the following messages are shown, there may be a malfunction. Immedi-
ately stop the vehicle in a safe place and contact any authorized Toyota
retailer or Toyota authorized repairer, or any reliable repairer.
• “Charging System Malfunction Stop in a Safe Place”
• “Oil Pressure Low Stop in a Safe Place”

6088-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
WARNING
QWhen removing the battery terminals
Always remove the negative (-) terminal first. If the positive (+) terminal con-
tacts any metal in the surrounding area when the positive (+) terminal is
removed, a spark may occur, leading to a fire in addition to electrical shocks
and death or serious injury.
Q Avoiding battery fires or explosions
Observe the following precautions to prevent accidentally igniting the flam-
mable gas that may be emitted from the battery:
O Make sure each jumper cable is connected to the correct terminal and that
it is not unintentionally in contact with any other than the intended terminal.
O Do not allow the other end of the jumper cable connected to the “+” termi-
nal to come into contact with any other parts or metal surfaces in the area,
such as brackets or unpainted metal.
O Do not allow the + and - clamps of the jumper cables to come into contact
with each other.
O Do not smoke, use matches, cigarette lighters or allow open flame near
the battery.
Q Battery precautions
The battery contains poisonous and corrosive acidic electrolyte, while
related parts contain lead and lead compounds. Observe the following pre-
cautions when handling the battery:
O When working with the battery, always wear safety glasses and take care
not to allow any battery fluids (acid) to come into contact with skin, clothing
or the vehicle body.
O Do not lean over the battery.
O In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
O Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
O Do not allow children near the battery.

662Alphabetical index
HILUX_OM_OM0K513E_(EE)
Child safety ................................ 64
Airbag precautions .................. 47
Battery precautions ....... 497, 608
Child restraint system ............. 65
How your child should
wear the seat belt ................. 42
Installing child restraints.... 90, 93
Power window lock
switch.................................. 186
Power window precautions ... 188
Rear door child-protectors .... 156
Removed key battery
precautions ......................... 518
Seat belt precautions .............. 44
Seat heater precautions ........ 450
Child-protectors ....................... 156
Cleaning............................ 472, 476
Exterior.................................. 472
Interior ................................... 476
Seat belts .............................. 477
Wheels .................................. 473
Clock ......................................... 465
Clutch........................................ 637
Coat hooks ............................... 469
Condenser ................................ 493
Console box ............................. 457
Cooling system
Engine overheating ............... 610
Cruise control
Cruise control ........................ 317
Dynamic radar cruise
control................................. 301
Cup holders .............................. 458
Curtain shield airbags ............... 45
DAC ........................................... 364
Daytime running light
system .................................... 252
Deck hooks .............................. 463
Defogger
Outside rear view
mirrors ........................ 435, 444
Rear window ................. 435, 444
Windshield .................... 435, 443
Differential
Oil ......................................... 637
Dimension ................................ 620
Display
Cruise control........................ 317
Dynamic radar cruise
control................................. 301
LDA (Lane Departure
Alert with Yaw Assist
Function) ............................ 290
Multi-information
display ................................ 135
Trip information ..................... 137
Do-it-yourself maintenance .... 482
Doors
Door glasses ......................... 185
Door lock............................... 153
Open door warning light........ 570
Outside rear view mirrors...... 182
Rear door child-protectors .... 156
Side doors............................. 153
Downhill assist control
system .................................... 364
DPF (Diesel Particulate Filter)
system .................................... 369
Warning message ................. 578
Drive-Start Control .................. 195
Driver’s seat belt
reminder light ........................ 570
D

669Alphabetical index
HILUX_OM_OM0K513E_(EE)
Seats
Adjustment ............................ 170
Adjustment precautions ........ 171
Child seats/child restraint
system installation ................ 65
Cleaning ................................ 476
Head restraint ....................... 175
Properly sitting in the seat....... 38
Raising the bottom
cushion ............................... 172
Removing the rear seat
cushions ............................. 172
Seat heaters.......................... 450
Sensor
Automatic headlight
system ................................ 252
LDA (Lane Departure
Alert with Yaw Assist
Function)............................. 284
Toyota parking
assist-sensor ...................... 321
Toyota safety sense .............. 267
Service reminder
indicators ............................... 122
Shift lever
Automatic transmission ......... 231
If the shift lever cannot be
shifted from P ..................... 237
Manual transmission ............. 239
Shift lock system ..................... 236
Side airbags ............................... 45
Side doors ................................ 153
Side mirrors.............................. 182
Adjusting and folding............. 182
Heaters ......................... 435, 444
Side turn signal lights
Replacing light bulbs............. 549
Turn signal lever ................... 246
Smart entry & start system ..... 163
Antenna location ................... 163
Entry functions ...................... 153
Starting the engine................ 223
Warning message ................. 575
Snow tires ................................ 374
“SOS” button ..................... 98, 110
Spare tire
Inflation pressure .................. 639
Storage location .................... 581
Spark plug ................................ 635
Specifications .......................... 620
Speedometer ............................ 131
Steering
Column lock release ..... 222, 228
Fluid ...................................... 639
Steering wheel
Adjustment ............................ 178
Audio switches ...................... 379
Heated steering wheel .......... 450
Meter control switches .......... 136
Stop & Start system ................ 345
Stop lights
Replacing light bulbs..... 542, 549
Wattage ................................ 642
Storage feature ........................ 456
Storage precautions ................ 456
Stuck
If your vehicle becomes
stuck ................................... 615
Sun visors ................................ 464

670Alphabetical index
HILUX_OM_OM0K513E_(EE)
Switch
Audio remote control
switches*............................ 379
Cruise control switch ............. 317
Door lock switch .................... 155
Driving mode select
switches...................... 233, 240
Emergency flashers switch ... 554
Engine switch ................ 220, 223
Fog light switch ..................... 255
Front-wheel drive control
switch.................................. 331
Heated steering wheel
switch.................................. 450
Ignition switch ............... 220, 223
LDA (Lane Departure
Alert with Yaw Assist
Function)............................. 290
Light switches ....................... 248
Meter control switches .......... 136
Outside rear view mirror
switches.............................. 182
Power door lock switch ......... 155
Power heater switch...... 436, 444
Power window switch ............ 185
Rear differential lock
switch.................................. 341
Rear window and outside
rear view mirror
defoggers switch......... 435, 444
Seat heater switches............. 450
“SOS” button ................... 98, 110
Telephone switches*............ 413
Toyota parking
assist-sensor ...................... 322
VSC OFF switch ................... 357
Window lock switch ............... 186
Windshield wipers and
washer switch ..................... 258
Tachometer .............................. 131
Tailgate ..................................... 160
Tail lights
Light switch ........................... 248
Replacing light bulbs..... 542, 549
Wattage ................................ 642
Talk switch*
Telephone switches*.............. 413
Theft deterrent system
Alarm .................................... 117
Engine immobilizer system ... 115
Tire inflation pressure
Maintenance data ................. 639
Tires .......................................... 507
Chains................................... 375
Checking ............................... 507
If you have a flat tire ............. 581
Inflation pressure .......... 510, 639
Replacing .............................. 581
Rotating tires......................... 508
Size ....................................... 639
Snow tires ............................. 374
Spare tire .............................. 581
Tools ......................................... 584
Towing
Emergency towing ................ 559
Towing hook ......................... 561
Trailer towing ................ 206, 207
Toyota parking
assist-sensor ......................... 321
Toyota Safety Sense ............... 266
Traction control ....................... 355
Trailer towing ................... 206, 207
Transmission
Automatic transmission......... 231
If the shift lever cannot be
shifted from P ..................... 237
Manual transmission ............. 239
T