disc TOYOTA RAIZE 2023 Service Manual
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 2023, Model line: RAIZE, Model: TOYOTA RAIZE 2023Pages: 516, PDF Size: 44.62 MB
Page 339 of 516

3376-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
WARNING
⬛When replacing wheels
⚫Do not use wheels that are a different size from those recommended in the
Owner’s Manual, as this may result in a loss of handling control.
⚫Never use an inner tube in a leaking wheel which is designed for a tubeless
tire. Doing so may result in an accident, causing death or serious injury.
⬛When installing the wheel nuts
⚫Be sure to install the wheel nuts wi th the tapered ends facing inward.
( ➞ P. 402) Installing the nu ts with the tapered ends facing outward can
cause the wheel to break and eventual ly cause the wheel to come off while
driving, which could lead to an acciden t resulting in death or serious injury.
⚫Never use oil or grease on the wheel bolts or wheel nuts.
Oil and grease may cause the wheel nuts to be excessively tightened, lead-
ing to bolt or disc wheel damage. In addition, the oil or grease can cause the
wheel nuts to loosen and the wheel ma y fall off, causing an accident and
resulting in death or serious injury. Re move any oil or grease from the wheel
bolts or wheel nuts.
⬛Use of defective wheels prohibited
Do not use cracked or deformed wheels.
Doing so could cause the tire to leak air during driving, possibly causing an
accident.
NOTICE
⬛Replacing tire pressure warning valves and transmitters (vehicles with a
tire pressure warning system)
⚫Because tire repair or replacement ma y affect the tire pressure warning
valves and transmitters, make sure to have tires serviced by your Toyota
dealer or other qualified service shop . In addition, make sure to purchase
your tire pressure warning valves and transmitters at your Toyota dealer.
⚫Ensure that only genuine Toyota wheels are used on your vehicle.
Tire pressure warning valves and transmitters may not work properly with
non-genuine wheels.
RAIZE_OM_General_BZ358E.book 337 ページ 2022年5月17日 火曜日 午後1時59分
Page 349 of 516

3476-3. Do-it-yourself maintenance
RAIZE_OM_General_BZ358E✽
: If equipped
Maintenance and care
6
WARNING
⬛Battery precautions
Observe the following precautions.
Failure to do so may result in death or serious injury.
⚫Do not swallow the battery. Doing so may cause chemical burns.
⚫A coin battery or button battery is used in the wireless remote control✽ or
the electronic key
✽. If a battery is swallowed, it may cause severe chemical
burns in as little as 2 hours and may result in death or serious injury.
⚫Keep away new and removed batteries from children.
⚫If the cover cannot be firmly closed, st op using the wireless remote control✽
or the electronic key✽ and stow the key in the place where children cannot
reach, and then contact your Toyota dealer.
⚫If you accidentally swallow a battery or put a battery into a part of your body,
get emergency medical attention immediately.
⬛To prevent battery explosion or leakage of flammable liquid or gas
⚫Replace the battery with a new battery of the same type. If a wrong type of
battery is used, it may explode.
⚫Do not expose batteries to extremely low pressure due to high altitude or
extremely high temperatures.
⚫Do not burn, break or cut a battery.
NOTICE
⬛Important points when replacing the batteries
Before you replace the battery, make sure to discharge static electricity from
your body and clothing. Static electricity could damage the key. To discharge
static electricity, prepare items that can remove static electricity in advance or
touch metal parts with your hands.
⬛To make it function properly after the replacement
Observe the following precautions.
⚫Never replace the batte ry with wet hands
Doing so could cause rusting.
⚫Do not touch or move the parts except the battery
⚫Do not bend the electrodes
RAIZE_OM_General_BZ358E.book 347 ページ 2022年5月17日 火曜日 午後1時59分
Page 367 of 516

365
7
RAIZE_OM_General_BZ358E
When trouble arises
7-1. Essential information
Emergency flashers .................. 366
If your vehicle has to be stopped in an emergency ......................... 367
Fire extinguisher........................ 369
If the vehicle is submerged or water on the road is rising ... 371
7-2. Steps to take in an emergency
If your vehicle needs to be towed ........................................ 372
If you think something is wrong ........................................ 377
Fuel pump shut off system ..... 378
If a warning light turns on....... 379
When warning messages are displayed .................................. 387
If you have a flat tire ................. 396
If the engine does not start .... 405
If the electronic key does not work properly (vehicles with key-free
system) ...................................... 406
If the vehicle battery is discharged ............................... 408
If your vehicle overheats ......... 412
If the vehicle has become stuck .......................................... 415
RAIZE_OM_General_BZ358E.book 365 ページ 2022年5月17日 火曜日 午後1時59分
Page 368 of 516

366
RAIZE_OM_General_BZ358E
7-1. Essential information
Emergency flashers
Use the emergency flashers to warn other drivers when the vehicle
has to be stopped in the road due to a breakdown or other reason.
Press the switch
All the turn signal lights will flash.
To turn them off, press the switch once
again.
NOTICE
⬛Emergency flashers
If the emergency flashers are used for a long time while the engine is not oper-
ating, the battery may discharge.
KBRO710201E
RAIZE_OM_General_BZ358E.book 366 ページ 2022年5月17日 火曜日 午後1時59分
Page 386 of 516

3847-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E ✽
: If equipped
⬛If the open door warning light✽ comes on
To avoid battery discharge, the warning light will automatically turn OFF after
about 10 minutes with the engine switch in “ACC” or “OFF”, and the door left
open.
⬛When the tire pressure warning light comes on (vehicles with a tire
pressure warning system)
Inspect the appearance of the tire to check that the tire is not punctured.
If the tire is punctured: ➞P. 3 9 6
If the tire is not punctured:
Carry out the following procedure after the tire temperature has lowered suffi-
ciently.
⚫Check the tire inflation pressure and adjust to the appropriate level.
⚫If the warning light does not go out even after several minutes, check that
the tire inflation pressure is at the sp ecified level and carry out initialization.
The warning light may come on again if the above operations are conducted
without first allowing the tire temperature to lower sufficiently.
⬛The tire pressure warning light may come on due to natural causes
(vehicles with a tire pressure warning system)
The tire pressure warning light may come on due to natural causes such as
natural air leaks and tire inflation pressure changes caused by temperature.
In this case, adjusting the tire inflatio n pressure will turn off the warning light
(after a few minutes).
⬛When a tire is replaced with a spare tire (vehicles with a tire pressure
warning system)
The spare tire is also equipped with a tire pressure warning valve and transmit-
ter. The tire pressure warning light will tu rn on if the tire inflation pressure of
the spare tire is low. If a tire goes flat, the tire pressure warning light will not
turn off even though the flat tire has been replaced with the spare tire. Replace
the spare tire with the repaired tire an d adjust the tire inflation pressure. The
tire pressure warning light will go off after a few minutes.
⬛If the tire pressure warning system is not functioning✽
The tire pressure warning system will be disabled in the following conditions:
(When the condition becomes normal, the system will work properly.)
⚫If tires not equipped with tire pressure warning valves and transmitters are
used
⚫If the ID code on the tire pressure warning valves and transmitters is not reg-
istered in the tire pressure warning computer
⚫If the tire inflation pressure is higher than the specified tire air pressure.
RAIZE_OM_General_BZ358E.book 384 ページ 2022年5月17日 火曜日 午後1時59分
Page 394 of 516

3927-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
⬛Warning messages
The displayed warning message in this document may be different from the
actual display depending on the use co nditions or vehicle specifications.
⬛Warning message display
⚫By pressing the RETURN switch when the engine switch is “ON”, the warning
message will disappear.
⚫Even when you hide the warning message by pressing the RETURN switch,
the following warning messages wi ll appear in a few seconds.
⦁ Low brake fluid
⦁ Brake system malfunction
⦁ Charging system malfunction
⦁ Low engine oil pressure
⦁ High temperature of engine coolant
⬛When the “Open” warning message is displayed
To avoid battery discharge, the message will automatically disappear after
approx. 10 minutes with the door open when the engine switch is “ACC” or
“OFF”.
“Oil Deterioration
Warning Oil Mainte-
nance Required Soon”
―
The engine oil replacement is due soon✽
➞ Have the vehicle inspected at your Toy-
ota dealer.
“Oil Deterioration
Warning Oil Mainte-
nance Required Visit
Your Dealer”
―
The engine oil is deteriorated✽
➞Have the vehicle inspected at your Toy-
ota dealer immediately.
Warning messages
Indicators/
Warning lights
Warning content/Action to take
RAIZE_OM_General_BZ358E.book 392 ページ 2022年5月17日 火曜日 午後1時59分
Page 403 of 516

4017-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
dTurn part A of the jack by hand
and hook the jack groove firmly
to the jack set position (between
2 notches)
e Raise the vehicle until the tires
are slightly off the ground
Use the jack handle together with the
wheel nut wrench, as shown in the
illustration.
fRemove all nuts and remove the
tire
When placing the tire directly on the
ground, make sure the wheel surface
faces up to avoid scratching it.
WARNING
⬛Replacing a flat tire
⚫Observe the following precautions.
Failure to do so may result in serious injury:
⦁Do not touch the disc wheels or the area around the brakes immediately
after the vehicle has been driven.
After the vehicle has been driven the disc wheels and the area around the
brakes will be extremely hot. Touching these areas with hands, feet or
other body parts while changing a tire, etc., may result in burns.
A
KBRO720409N
KBRO720410N
KBRO720411N
RAIZE_OM_General_BZ358E.book 401 ページ 2022年5月17日 火曜日 午後1時59分
Page 407 of 516

4057-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
If the engine does not start
If the engine does not start even though correct starting procedures
are being followed ( ➞P. 184), consider each of the following points:
The engine does not start even though the starter motor operates
normally
One of the following may be the cause of the problem:
⚫There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle.
⚫The engine may be flooded.
Try to restart the engine again fo llowing correct starting procedures
( ➞ P. 1 8 4 ) .
⚫There may be a malfunction in th e engine immobilizer system. (➞P. 72)
The starter motor runs slowly, the interior light and headlights are
dim, or the horn does not so und or sounds at a low volume
One of the following may be the cause of the problem:
⚫The battery may be discharged. ( ➞P. 408)
⚫The battery terminal connections may be loose.
If the starter does not operat e (vehicles with key-free system)
⚫There may be an issue in the electrical system, such as a disconnected
electrical component or blown fuse. Depending on the cause, you may
be able to start the engine using temporary measures. ( ➞P. 406)
⚫There may be a malfunction in the steering wheel lock system.
The starter motor does not run, the interior light and headlights do
not turn on, or the horn does not sound
One of the following may be the cause of the problem:
⚫There may be a disconnected battery terminal.
⚫The battery may be discharged. ( ➞P. 408)
Contact your Toyota dealer if the procedures are not clear, or if the engine does not
start even after the measures have been taken.
RAIZE_OM_General_BZ358E.book 405 ページ 2022年5月17日 火曜日 午後1時59分
Page 410 of 516

4087-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
If the vehicle battery is discharged
If the battery is discharged, you can start the engine by following the
steps below.
You can also call your Toyota deal er or a qualified repair shop.
If you have a booster cable and a second vehicle with a 12 V battery, you
can start your vehicle by following the steps below.
a Open the cover of the positive (+) battery terminal
Hold down the claw and open it.
bConnect the jumper cables accord ing to the following procedure:
a Connect a positive jumper cable clamp to the positive (+) battery ter-
minal on your vehicle.
b Connect the clamp on the other end of the positive cable to the pos-
itive (+) battery terminal on the second vehicle.
c Connect a negative cable clamp to the negative (-) battery terminal
on the second vehicle.
d Connect the clamp at the other end of the negative cable to a solid,
stationary, unpainted metallic point away from the battery and any
moving parts, as show n in the illustration.
▶WA-VE engine
4
1
32
KBRO720901N
RAIZE_OM_General_BZ358E.book 408 ページ 2022年5月17日 火曜日 午後1時59分
Page 411 of 516

4097-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
▶1KR-VET engine
c Start the engine of the second ve hicle. Increase the engine speed
slightly and maintain at that level for approximately 5 minutes to
recharge the battery of your vehicle.
d Maintain the engine speed of the second vehicle and turn the engine
switch to “ON”.
e Once the vehicle’s engine has started, remove the jumper cables in the
exact reverse order from which they were connected.
f Close the cover of the positive (+) battery terminal
Even if you are able to start the engine, have the vehicle inspected at your
Toyota dealer as soon as possible.
⬛Starting the engine when the battery is discharged
For this vehicle, the engine c annot be started by push-starting.
⬛If the vehicle battery is discharged
The data stored in the comp uter will be erased. If your vehicle’s battery dis-
charges, have the vehicle insp ected at your Toyota dealer.
⬛Charging the battery
The electricity stored in the battery will discharge gradually even when the
vehicle is not in use, due to natural discharge and the draining effects of cer-
tain electrical appliances. If the vehicle is left for a long time, the battery may
discharge, and the engine may be unable to start. (The battery recharges auto-
matically during driving)
4
1
32
KBRO720901
RAIZE_OM_General_BZ358E.book 409 ページ 2022年5月17日 火曜日 午後1時59分