spark plugs TOYOTA TACOMA 2017 Warranties & Maintenance Guides (in English)

JOBNAME: 2372852-en-2017_TACO PAGE: 15 SESS: 3 OUTPUT: Wed Jul 13 07:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
Maintenance Expense
Normal maintenance services such as:
•Engine tune-ups
•Replacement of fluids and filters
•Lubrication
•Cleaning and polishing
•Replacement of spark plugs and fuses
•Replacement of worn wiper blades,
brake pads/linings and clutch linings
Vehicles With Altered Odometer
Failure of a vehicle on which the odometer
has been altered so that actual vehicle
mileage cannot be readily determined.
Salvage or Total-Loss Vehicles
Any vehicle that has ever been issued a
“salvage” title or similar title under any
state’s law; or has ever been declared a
“total loss” or equivalent by a financial
institution or insurer, such as by payment
for a claim in lieu of repairs because the
cost of repairs exceeded the cash value of
the vehicle. This exclusion does not apply
to the emission control warranties.
Incidental Damages
Incidental or consequential damages
associated with a vehicle failure. Such
damages include but are not limited to
inconvenience; the cost of transportation,
telephone calls and lodging; the loss of
personal or commercial property; and the
loss of pay or revenue.
Disclaimer of Extra Expenses and
Damages
The performance of necessary repairs
and adjustments is the exclusive
remedy under this warranty or any
implied warranty. Toyota does not
authorize any person to create for it any
other obligation or liability in connection
with this vehicle. Toyota shall not be
liable for incidental or consequential
damages resulting from breach of this
written warranty or any implied
warranty. Any implied warranty of
merchantability or fitness for a
particular purpose is limited to the
duration of this written warranty, except
in states where this limitation is not
allowed.
New Vehicle Limited Warranty
WARRANTY
Your Warranties in Detail15

JOBNAME: 2372852-en-2017_TACO PAGE: 19 SESS: 3 OUTPUT: Wed Jul 13 07:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
Exhaust Gas Recirculation
(EGR) System
•EGR gas temperature sensor
•EGR valve
•Associated parts
Ignition System
•Distributor and internal parts
•Ignition coil and ignitor
•Ignition wires
•Spark plugs*
Positive Crankcase Ventilation
(PCV) System
•Oil filler cap
•PCV valve or orifice
Other Parts Used in Above
Systems
•Data link connector (8/80)
•Hoses, clamps, fittings, tubing and
mounting hardware
•Malfunction indicator light and bulb
(8/80)
•Pulleys, belts and idlers
•Sealing gaskets and devices
•Sensors, solenoids, switches and valves
MAINTENANCE
You are responsible for performance of
the required maintenance indicated in the
Owner’s Manualand this booklet. Toyota
will not deny a warranty claim solely
because you do not have records to show
that you maintained your vehicle. However,
any failure or noncompliance caused by
lack of maintenance is not covered by this
warranty.
When maintenance and repairs are paid
for by you, these services may be
performed by you or by any automotive
service provider you choose. Toyota will
not deny a warranty claim solely
because you used a service provider
other than a Toyota dealership for
maintenance and repairs. However, any
failure or noncompliance caused by
improper maintenance or repairs is not
covered by this warranty.
*Warranted until first required maintenance under terms of the California Emission Control Warranty.
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
Federal Emission Control Warranty
WARRANTY
Your Warranties in Detail19

JOBNAME:2372852-en-2017_TACO PAGE:45SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
60,000 milesor72 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsInspect wiperbladesLubricate propellershaft(4WD)Re-torque propellershaftboltReplace cabinairfilter
Replace engineairfilterReplace engineoiland oilfilter1
Replace sparkplugs (2GR-FKS engine
only)4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts6
_Drive shaftboots (4WD)
_ Engine coolant7
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_ Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ Transmission forsigns ofleakage
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)Replace reardifferential oilReplacetransfercaseoil(4WD)Replace transmission fluidoroilTighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Includesoperating onroads which roadsalthasbeen applied.4Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.5Inspectthickness measurement anddisc runout.6Initial inspection at60,000 miles/72 months.Inspectevery15,000 miles/18 monthsthereafter.7Referto“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
8Not allvehicles aredesigned fortowing. RefertoyourVehicle Owner’ sManual fordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog45
JOBNAME:2372852-en-2017_TACO PAGE:45SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
60,000 milesor72 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Lubricate propellershaft(4WD)
Re-torque propellershaftbolt
Replace cabinairfilter Replace
engineairfilter
Replace engineoiland oilfilter1
Replace sparkplugs (2GR-FKS engine
only)4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts6
_Drive shaftboots (4WD)
_ Engine coolant7
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear
differential oil
_ Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ T

ransmissionforsigns ofleakage
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)
Replace reardifferential oil
Replace transfercaseoil(4WD)
Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Includesoperating onroads which roadsalthasbeen applied.4Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.5Inspectthickness measurement anddisc runout.6Initial inspection at60,000 miles/72 months.Inspectevery15,000 miles/18 monthsthereafter.7Referto“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
8Not allvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog45
JOBNAME:2372852-en-2017_TACO PAGE:45SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
60,000 milesor72 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Lubricate propellershaft(4WD)
Re-torque propellershaftbolt
Replace cabinairfilter Replace
engineairfilter
Replace engineoiland oilfilter1
Replace sparkplugs (2GR-FKS engine
only)4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts6
_Drive shaftboots (4WD)
_ Engine coolant7
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear
differential oil
_ Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ T

ransmissionforsigns ofleakage
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)
Replace reardifferential oil
Replace transfercaseoil(4WD)
Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
Maintenance Log
MAINTENANCE
MaintenanceLog45
137077_WMG_Tacoma_x-tions.indd 457/19/16 3:23 PM

JOBNAME:2372852-en-2017_TACO PAGE:53SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsInspect wiperbladesLubricate propellershaft(4WD)Re-torque propellershaftboltReplace cabinairfilter
Replace engineairfilterReplace engineoiland oilfilter1
Replace sparkplugs4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts
_ Drive shaftboots (4WD)
_ Engine coolant
6
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_ Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ Transmission forsigns ofleakage
_ Vacuum pumpforbrake booster (except
for off-road package models)
7
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)Replace reardifferential oilReplacetransfercaseoil(4WD)Replace transmission fluidoroilTighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Includesoperating onroads which roadsalthasbeen applied.4Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.5Inspectthickness measurement anddisc runout.6Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
7If blade/vane requiresreplacement, useanew blade/vane. Neverreusetheblade/vane.8Not allvehicles aredesigned fortowing. RefertoyourVehicle Owner’ sManual fordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog53
JOBNAME:2372852-en-2017_TACO PAGE:53SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Lubricate propellershaft(4WD)
Re-torque propellershaftbolt
Replace cabinairfilter Replace
engineairfilter
Replace engineoiland oilfilter1
Replace sparkplugs4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts
_ Drive shaftboots (4WD)
_ Engine coolant
6
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ T
ransmissionforsigns ofleakage
_ Vacuum pumpforbrake booster (except
for off-road package models)
7
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)
Replace reardifferential oil
Replace transfercaseoil(4WD)
Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
Maintenance Log
MAINTENANCE
MaintenanceLog53
JOBNAME:2372852-en-2017_TACO PAGE:53SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Lubricate propellershaft(4WD)
Re-torque propellershaftbolt
Replace cabinairfilter Replace
engineairfilter
Replace engineoiland oilfilter1
Replace sparkplugs4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts
_ Drive shaftboots (4WD)
_ Engine coolant
6
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ T
ransmissionforsigns ofleakage
_ Vacuum pumpforbrake booster (except
for off-road package models)
7
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)
Replace reardifferential oil
Replace transfercaseoil(4WD)
Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Includesoperating onroads which roadsalthasbeen applied.4Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.5Inspectthickness measurement anddisc runout.6Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
7If blade/vane requiresreplacement, useanew blade/vane. Neverreusetheblade/vane.8Not allvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog53
137077_WMG_Tacoma_x-tions.indd 537/19/16 3:23 PM

JOBNAME: 2372852-en-2017_TACO PAGE: 57 SESS: 3 OUTPUT: Wed Jul 13 07:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
Spark Plugs
Replace at specified intervals. Install new
plugs of the same type as originally
equipped. A qualified technician should
perform this operation.
Steering Gear
Inspect for signs of leakage. If you
discover any leakage, have it repaired
immediately by a qualified technician.
Steering Linkage and Boots
With the vehicle stopped, check for
excessive freeplay in the steering wheel.
Inspect the linkage for bending and
damage and the dust boots for
deterioration, cracks and damage. Replace
any damaged parts. A qualified technician
should perform these operations.
Tire Rotation
Tires should be rotated according to the
instructions in the
Owner’s Manual. When
rotating tires, check for damage and
uneven wear. Replace if necessary.
Transfer Case Oil
Inspect or replace at specified intervals.
When performing inspections, check for
signs of leakage. If you discover any
leakage, have it repaired by a qualified
technician immediately.
Vacuum Pump For Brake
Booster (Except for Off-Road
Package Models)
Replace at specified intervals. A qualified
technician should perform this operation.
Wiper Blades
The wiper blades should not show any
signs of cracking, splitting, wear,
contamination or deformation. The wiper
blades should clear the windshield without
streaking or skipping.
Explanation of Maintenance Items
Maintenance Log57
MAINTENANCE