heating VOLKSWAGEN TRANSPORTER 2014 Repair Manual

If and when
Practical tips
Frequently asked questions
If you suspect that a vehicle fault has arisen or your vehicle has been damaged, read and observe the following information before contacting a Volkswagen Commercial Vehicles dealership or
qualified workshop. You may also find useful infor-mation in the index under the headings "Things to note" or "Checklist".
To note Some possible causes Possible solution
Vehicle battery is discharged. -How to jump start =>page 443. -Recharge vehicle battery 362.
Engine does not start. The incorrect vehicle key is be-Use a valid vehicle key 36. ing used.
Fuel level is too low. Fill the tank 340.
Supplementary heating system Switch off the supplementary heating
Smoke is coming from the is running. system 332. wing. Supplementary heater is run-No solution 345. ning.
-Battery in the remote control -Replace the battery 36. Vehicle cannot be locked or key is flat. -Move closer to the vehicle. unlocked with the remote -Located too far away from the -Synchronise the vehicle key =>page 36. vehicle. control key. -Buttons were pressed outside -Lock or unlock the vehicle manually
the range. 413.
Cold engine. brake assist sys-Refer to the index under entries for Unusual noises. tems, supplementary heating "Noises". system.
Assist systems are active. Refer to the index under entries for "As-sist systems". Unusual handling. DSG® dual clutch gearbox is too Stop the vehicle immediately hot. 266.
Front seats cannot be ad-Vehicle battery is discharged. Recharge vehicle battery 362.
justed electrically. Fuse blown. Check fuse and replace as necessary 429.
The vehicle has no vehicle No direct solutions possible as it depends
jack, spare wheel or break-Equipment depends on type of on the equipment level. Contact a Volks-vehicle. wagen Commercial Vehicles dealership if down set. necessary 416.
-Windows or sliding roof are open. The interior monitoring sys--Item attached to the interior Remove any objects that could trigger a tem triggers a false alarm. mirror is moving. false alarm 44. -A mobile telephone is vibrating inside the vehicle.
Functions are not working Settings have been made in the Check and if necessary reset back to fac-as described in the owner's manual. Volkswagen information system. tory settings 24.
410 I If and when

A WARNING (Continued)
• Always follow the instructions In the checklist and observe the general safety pro-
Sealing and inflating tyres
r-"'('n First read and observe the Introductory L-J,.:.U Information and safety warnings & on page 425.
Sealing a tyre
• Unscrew the cap from the tyre valve.
• Use the valve core extractor 302 CD to screw the valve core out of the tyre valve. Place the core on a clean surface.
• Shake the tyre filler bottle 302 ® vigo-rously up and down several times.
• Screw the filler hose 302 @tightly onto the tyre filler bottle in a clockwise direction. The plastic foil on the plug is pierced automatically.
• Remove the plug from the filler hose 302@ and place the open end fully on the tyre valve.
• Hold the bottle upside down and inject the en-tire contents of the tyre filler bottle into the tyre.
• Remove the empty tyre filler bottle from the valve.
• Use the valve core extractor 302 CD to screw the valve core back onto the tyre valve.
Inflating the tyre
• Screw the tyre filler hose 302 ® of the air compressor tightly onto the tyre valve.
• Check that the bleed screw 302 (?) is closed.
• Start the engine and let it run.
• Insert the plug 302 ®into one of the ve-hicle's 12-volt sockets 163.
• Use the on/off switch 302 ®to switch on the air compressor.
• Run the compressor until the tyre pressure has reached 2.0-2.5 bar (29-36 psi I 200-250 kPa) maximum running time is 6 minutes
• Switch off the air compressor.
• If a pressure level of 2.0-2.5 bar (29-36 psi I 200 -250 kPa) cannot be achieved unscrew the tyre filler hose from the tyre valve.
428 I If and when
• Drive (or reverse) the vehicle approximately 1 0 metres so that the sealing compound is more evenly distributed in the tyre.
• Screw the tyre filler hose for the air compressor firmly back onto the tyre valve and inflate the tyre again.
• If the required pressure still cannot be reached, the tyre is too badly damaged. The tyre cannot be sealed with the breakdown set. Do not drive on. Seek expert assistance &.
• Disconnect the air compressor and unscrew the tyre filler hose from the tyre valve.
• Drive the vehicle no faster than 80 km/h (50 mph) once a tyre pressure of 2.0-2.5 bar (29-36 psi I 200-250 kPa) has been reached.
• Check the tyre pressure after driving for 10 mi-nutes 429.
A WARNING
The tyre filler hose and the air compressor can get hot during Inflation.
• Protect your hands and skin from the hot components.
• Do not place the hot tyre filler hose or the hot air compressor on any Inflammable mate-rials.
• Allow the device to cool down fully before stowing.
• If the tyre will not Inflate to at least 2.0 bar (29 psi/ 200 kPa), the tyre Is too damaged. The sealant Is unable to seal the tyre. Do not drive on. Seek expert assistance.
CD
Switch the air compressor off after a maximum of 6 minutes to avoid overheating. Let the air compressor cool down for a few minutes be-fore switching it back on.

Vents ............................ 329 Windscreen heating . . . . . . . . . . . . . . . . . 331
Air conditioning system, California . . . . . . 250
Air reclrculation mode . . . . . . . . . . . . . . . . 330 Operation . . . . . . . . . . . . . . . . . . . . . . . . . 330 Switching off . . . . . . . . . . . . . . . . . . . . . . . 330 Switching off temporarily . . . . . . . . . . . . . 330
Alarm system . . . . . . . . . . . . . . . . . . . . . . . . . 43 Alcantara . . . . . . . . . . . . . . . . . . . . . . . . . . . 389
Alternator . . . . . . . . . . . . • . . . . . • . . . . . . . . 364
Aluminium . . . . . . . . . . . . . . . . . . . . . . . . . . 385
Anodised surfaces . . . . . . . . . . . . . . . . . . . 385
Anti-freeze . . . . . . . . . . . . . . . . . . . . • . . . . . 360 Anti-lock brake system (ABS) . . . . . . . . . . 275 Anti-snaking coupling Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Anti-theft alarm . . . . . . . • . . . . . . . . • . . . . . . 43 Anti-tow alarm . . . . . . . . . . . . . . . . . . . . . . 44 Description . . . . . . . . . . . . . . . . . . . . . . . . . 43 Interior monitoring system . . . • . . . . . . . . . 44 Risk of false alarm . . . . . . . . . . . . . . . . . . . 44 Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145 Anti-theft wheel bolts . . . . . . . . . 417, 420, 421
Anti-tow alarm . . . . . . . . . . . . . . 44
Applications . . . . . . . . . . . . • . . . . . 404
Apps ............................... 404 Area monitoring system . . . . . . . . . . . . . . . 307 City Emergency Brake function ......... 311 Displays . . . . . . . . . . . . . . . . . . . . . . . . . . 308 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 308 Radar sensor . . . . . . . . . . . . . . . . . . . . . . 309 System limits . . . . . . . . . . . . . . . . . . . . . . 312
Armrest, 2-seat arrangement, Business Adjusting . . . . . . . . . . . . . . . . . . . . . . . . . 184 Stowage compartment . . . . . . . . . • . . . . . 184
Armrest, 3-seat bench . . . . . . . . . . . . . . . . . . 78
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161 Front. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162 Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162 Removable . . . . . . . . . . . . . . . . . . . . . . . . 162 Assist systems Adaptive chassis control (DCC) . . . . . . . . 317 Adaptive cruise control (ACC) . . . . . . . . . 298 Anti-lock brake system (ABS) . . . . . . . . . 275 Area monitoring system (Front Assist) . . . 307 Automatic Post-Collision Braking System 274 Brake Assist system (BAS) . . . . . . . . . . . 275 ccs ............................. 295 Cruise control system . . . . . . . . . . . . • . . 295 Driver Alert System .. .. .. .. .. . .. .. .. 315 Electronic differential lock (EDL) . . . . . . . 275 Electronic stability control (ESC) . . . . . . . 274 Hill Descent Assist . . . . . . . . . . . . . . . . . . 285 Hill Hold Assist . . . . . . . . . . . . . . . • . . . . . 284 Lane change assist system . . . . . . . . . . . 312 Parking aid . . . . . . . . . . . . . . . . . . . . . . . . 287
466 Index
Parking aid (front and rear) . . . • . . . . . . . 289 Parking aid (only at rear) . . . . . . . . . . . . . 288 ParkPilot . . . . . . . . . . . . . . . . . . . . . . . . . . 287 ParkPilot (front and rear) . . . . . . . . . . . . . 289 ParkPilot (only at rear) . . . . . . . . . . . . . . . 288 Rear Assist (reversing camera) . . . . . . . . 291 Recommendation for rest breaks....... 315 Reversing camera . . . . . . . . . . . . . . . . . . 291 Side Assist (lane change assist system) . 312 Start/stop . . . . . . . . . . . . . . . . . . . . . . . . . 283 Traction control system (TCS) . . . . . 275, 276 Tyre monitoring system . . . . . . . . . . 318, 321
Asymmetrical tyres . . . . . . . . . . . . . . . . . . . 377
Automatic belt retractor . . . . . . . . . . . . . . . . 86 Automatic car wash . . . . . . . . . . . . . . . . . . 381
Automatic gearbox See Dual clutch gearbox . . . . . . . . . . . . . 260 see Dual clutch gearbox DSG . . . . . . . . . 264 Automatic headlight control ............. 110
Automatic Post-Collision Braking System 274
Automatic switch-off for electrical consum-ers .............................. . 366
Auxiliary air heater See Supplementary heater .......... . 332 Auxiliary coolant heater Remote control .................... . See Supplementary heater .......... .
Auxiliary equipment or body parts ..... .
335 332
396
Auxiliary heater Remote control .................... . see Supplementary heater ........... . See Supplementary heater .......... . Switch-off delay ..............•.....
335 251 332 334 Awning ............................. 226 Closing . . . . . . . . . . . . . . . . . . . . . • . . . . . 227 Opening . . . . . . . . . . . . . . . . . . . . . . . . . . 227 Removing and fitting . . . . . . . . . . • . . . . . 228
Axle weight rating . . . . . . . . . . . . . . • . . . . . 450
8
Ball coupling Fitting . . . . . . . . . . . . . . . . . . . . . . • . . . . . 142 Mounting . . . . . . . . . . . . . . . . . . . . . . . . . 142 Ready position . . . . . . . . . . . . . . . . . . . . . 142 Removing . . . . . . . . . . . . . . . . . . . . . . . . . 144
BAS see Brake support systems . . . . . . . . . . . 275 Battery Discharge . . . . . . . . . . . . . . . . . . . . . . . . . 339 Remote control (supplementary heating sys-tem) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 337 Replacing in remote control key . . . . . . . . . 38 see Vehicle battery . . . . . . . . . . . . . . . . . . 362
Battery charger . . . . . . . . . . . . . . . . • . . . . . 24 7
Bed extension . . . . . . . . . . . . . . . . . . . . . . . . 77

Standards . . . . . . . . . . . . . . . . . . . . . . . . . . 98 Switching off the front passenger front air-bags............................. 93 Weight classes . . . . . . . . . . . . . . . . . . . . . . 98 Chrome ............•................ 385
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . 163
Circuit breaker . . . . . . . . . . . . . . . . . . . . . . . 247
City Emergency Brake function .......... 311
Cleaning see Vehicle care . . . . . . . . . . . . . . . . . . . . 380
Cleaning the drain . . . . . . . . . . . . . . . . . . . . 241
Cleaning the vehicle interior Cupboards . . . . . . . . . . . . . . . . . . . . . . . . 253 Display of the central control panel, Califor-nia . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254 Gas cooker . . . . . . . . . . . . . . . . . . . . . . . . 253 Refrigerator box, California . . . . . . . . . . . 242 Sink .....................•....... 253
Climatic see Air condilioning system . . . . . . . . . . . 322
Climatic, California . . . . . . . . . . . . . . . . . . . 250
Climatronic see Air condilioning system . . . . . . . . . . . 322
Cllmatronic, California . . . . . . . . . . . . . . . . 250 Clock ................................ 20
Closing Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 Electric sliding door . . . . . . . . . . . . . . . . . . 47 Sliding/tilting roof . . . . . . . . . . . . . . . . . . . . 59 Sliding door . . . . . . . . . . . . . . . . . . . . . . . . 46 Sliding windows . . . . . . . . . . . . . . . . . . . . . 58 Taiigate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 Vehicle . . . . . . . . . . . . . • . . . . . . . . . . . 40, 42 Windows ...........•.............. 56 Wing doors . . . . . . . . . . . . . . . . . . . . . . . . . 54
Coasting function . . . . . . . . . . . . . . . . . . . . 266
Cockpit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Code number . . . . . . . . . . . . . . . . . . . . . . . . 417
Combined curtain and side alrbags see Airbag system . . . . . . . . . . . . . . . . . . . 94 Coming Home function ................. 112
Communication window ................ 116 Consumables . . . . . . . . . . . . . . . . . . . . . . . . 395
Consumer Information . . . . . . . . . . . . . . . . 404
Controls 2-seat arrangement . . . . . . . . . . . . . . . . . 183
Control units . . . . . . . . . . . . . . . . . . . . . . . . 398 Reprogramming . . . . . . . . . . . . . . . . . . . . 399
Convenience closing Electric windows . . . . . . . . . . . . . . . . . . . . 57 Sliding/tilting roof . . . . . . . . . . . . . . . . . . . . 59
Convenience functions Reprogramming . . . . . . . . . . . . . . . . . . . . 399
Convenience opening Electric windows . . . . . . . . . . . . . . . . . . . . 57
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 358 Checking the coolant level . . . . • . . . . . . . 361 Filler opening . . . . . . . . . . . . . . . . . . . . . . 361 G 12 plus-plus . . . . . . . . . . . . . . . . . . . . . 360 Indicator lamp . . . . • . . . . . • . . • . . . . . . . 359 Refilling . . . . . . . . . . . . . . . . . . . . . . . . . . 361 Specification . . . . . . . . . . . . . . . • . . • . . . . 360 Temperature display . . . . . . . . . . . . • . . . . 359 Warning lamp . . . . . . . . . . . . . . . . . . . . . . 359
Cool box . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158 Battery monitor . . . . . . . . . . . . . . . . . . . . . 158 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 393
1W Fitting the adapter plate . . . . . . . . . . . . . . 159 Removing . . . . . . . . . . . . . . . . . . . . . . . . . 159 Removing the adapter plate . . . . . . . . . . . 159 Switching on and off.. . . . . . . . . . . . . . . . 161
Cooling and heating box . . . . . . . . . . . . . . . 158
Countdown timer Programming . . . . . . . . . . . . . . . . . . . . . . 207
Cruise control system . . . . . . . . . . . . . . . . . 295
Cruise control system (CCS) Indicator lamp . . . . . . . . . . . . . . . . . 296 Using . . . . . . . . . . . . . . • . . . . . . . . . 297
Cupboards Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 253
Curtain airbags see Airbag system . . . . . . . . . . . . . . . . 94. 95
D
Darkening the interior of the vehicle California . . . . . . . . . . . . . . . . . . . . . . . . . 215 Multivan . . . . . . . . . . . . . . . . . . . . . . . . . . 175
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Airbag system . . . . . . . . . . . . . . . . . . 87, 392 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 392
Data Link Connector (DLC) . . . . . . . . . . . . . 399 Data recorders . . . . . . . . . . . . . . . . . . . . . . . 398 Daytime running lights . . . . . . . . . . . . . . . . 109
DCC see Adaptive chassis control . . . . . . . . . . 317
De-icing door lock cylinders . . . . . . . 387
Declaration of conformity . . . . . . . . . . 188, 406 Decorative film Caring for . . . . . . . . . . . . . . . . . . . . . . . . . 385 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 385
Default settings of the mobile telephone Rear-seat telephony . . . . . . . . . . . . . . . . . 190
Diagnostic connection . . . . . . . . . . . • . . . . 399 Diesel .............................. 345 Biodiesel . . . . . . . . . . . . . . . . . . . . . . . . . 346 Filling the tank . . . . . . . . . . • . . . . . . . . . . 342 Filter preheater . . . . . . . . . . . . . . . . . . . . . 345 Fuel gauge . . . . . . . . . . . . . . . . . . . . . . . . 341
Index 469

Electrical consumer . . . . . . . . . . . . . . . . . . 244
Electrical consum-ers ....... 145,164,242,244,331,339,412 Business . . . . . . . . . . . . . . . . . . . . 186
Electrical equipment . . . . . . . . . . . . . . . . . . 164
Electrical sockets . . . . . . . . . . . . . . . . . . . . 163
Electric lumbar support adjustment . . . . . . 66
Electric pop-up roof, California . . . . . . . . . 221 Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . 223 Opening . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Electric sliding doors Disabling . . . . . . . . . . . . . . . . . . . . . . . . . . 47 Opening and closing . . . . . . . . . . . . . . . . . 47 Roll-back function . . . . . . . . . . . . . . . . . . . 48 Electric windows . . . . . . . . . . . . . . . . . . . . . . 55 Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 Convenience closing . . . . . . . . . . . . . . . . . 57 Convenience opening . . . . . . . . . . . . . . . . 57 Fault .........................•.... 57 One-touch function . . . . . . . . . . . . . . . . . . . 56 Opening ........................... 56 Roll-back function . . . . . . . . . . . . . . • . . . . 57
Electrolyte . . . . . . . . . . . . . . . . . . . . . . . . . . 365
Electronic differential lock (EDL) . . . . . . . . 275
Electronic Immobilizer . . . . . . . . . . . . . . . . 260
Electronic stability control (ESC) . . . . . . . . 274
Emergency ........................... 411 Breakdown . . . . . . . . . . . . . . . . . . . . • . . . 412 Checklist . . . . . . . . . . . . . . . . . . . . . . . . . 412 Fire extinguisher . . . . . . . . . . . . . . . . . . . 413 First aid kit . . . . . . . . . . . . . . . . . . . . . . . . 413 Hazard warning lights . . . . . . . . . . . . . . . 412 Making you and your vehicle safe 412 Warning triangle . . . . . . . . . . . . . . 413
Emergency brake . . . . . . . . . . . . . . . . . . . . 412
Emergency brake lights . . . . . . . . . . . 412 Emergency breakaway cable . . . . . . . 141, 145
Emission control system for diesel vehi-cles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 346
Engine Noises . . . . . . . . . . . . . . . . . . . . . . . • . . . 259 Not running smoothly . . . . . . . . . . . . • . . . 343 Running in . . . . . . . . . . . . . . . . . . . . 394
Engine and ignition . . . . . . . . . . . . . . . . . . . 257 12-volt sockets . . . . . . • . . . . . . . . . . 164, 243 Ignition lock . . . . . . . . . . . . . . . . . . . . . . . 258 Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . 260 Non-authorised vehicle key . . . . . . . . . . . 258 Preheating . . . . . . . . . . . . . . . . . . . 258 Starting the engine . . . . . . . . . . . . . . . . . . 258 Stopping the engine . . . . . . . . . . . . . . . . 259 Engine and transmission guard . . . . . . . . . . 33
Engine code Finding . . . . . . . . . . . . . . . . . . . . . . . . . . . 451
Engine compartment ................. . Cleaning ........................ . Coolant .......................... . Engine oil ........................ . Plenum chamber .................. . Preparation ...................... . Vehicle battery .................... . Engine coolant see Coolant ................. .
Engine fault ................... .
Engine idling speed increased ........................ . Engine management system .....•..... Indicator lamp .................... .
Engine oil .....................•..... Changing ........................ . Checking the engine oil level ......... . Consumption ................•..... Dipstick ......................... . Filler opening ..................... . Indicator lamp .................... . Refilling ......................... . Specification ...................... . Warning lamp ..................... .
Engine specifications ................ . Entering password Rear-seat telephony ......... .
Entering PIN code Rear-seat telephony ................ . Equipment Business ........................ . California ........................ . Multivan ... .
ESC ....... . ESP
350 387 358 353 387 352 362
358
407
366 407 407
353 357 356 357 356 356 354 356 354 354
450
190
190
180 192 175
274
see Electronic stability control (ESC) . . . . 274 Event data recorder . . . . . . . . . . . . . . . . . . . 399
Event memory Connector . . . . . . . . . . . . . . . . . . . . . . . 399 Reading . . . . . . . . . . . . . . . . . . . . . . . . . . 399 Exhaust purification system . . . . . . . . . . . 407 Indicator lamp . . . . . . . . . . . . . . . . . . . . . 407 Exterior mirrors . . . . . . . . . . . . . . . . . . . . 123 Aerial . . . . . . . . . . . . . . . . . . . . . . . . 124,406 Automatic anti-dazzle . . . . . . . . . . . . . . 123 Driving with a trailer . . . . . . . . . . . . . . . . 142 .............. ·····•········ Folding in . . . . . . . . . . . . . . . . . . . . . . . . . 123 Vehicle care . . . . . . . . . . . . . . . . . . . . . . . 382
Exterior views . . . . . . . . . . . . . . . . . • . . . . . . . 5
External aerial . . . . . . . . . . . . . . . . . . . . . . . 398 External socket 230-volt power supply 245
Index 471

Gear-change Indicator . . . . . . . . . . • . . . . . 268
Glasses compartent . . . . . . . . . . . . . . . . . . 152
Glove compartment Lights ............................. 114 see Stowage areas . . . . . . . . . . . . . . . . . 151
Gross vehicle weight rating . . . . . . . . . . . . 450
Guide rail system In the rear vehicle floor Business . . . . . . . . . . . . . . . . . . . . . . . . . 133 California . . . . . . . . . . . . . . . . . . . . . . . . . 133 Multivan . . . . . . . . . . . . . . . . . . . . . . . . . . 133
H
Handbrake
Hands-free system in the passenger com· partment
271
See Rear-seat telephony . . . . . . . . . . . . . 187 Hazard warning lights . . . . . . . . . . . . . . . . . 412
Headlight range control ............. 11,113 Dynamic headlight range control . . . . . . . . 113
Headlights . . . . . . . . . . . . . . . . . . . . . . . . . . 108 Cleaning system . . • . . . . . . . . . . . . . . . . . 118 Driving abroad . . . . . . . . . . . . . . . . . . . . . . 111 Headlight (LED) . . . . . . . . . . . . . . . . . . . . . . 434
Head restraints . . . . . . . . . . . . . . . . . . . . . . . 67
Heat-insulating glass windscreen . . . . . . . . . . . . . . . . . . . . . . . . . 116
Heated seats . . . . . . . . . . . . . . . . . . . . . . . . . 69
Heating and fresh air system Controls . . . . . . . . . . . . . . . . . . . . . . . . . . 327
High-pressure cleaner . . . . . . . . . . . . . . . . 382
High-visibility waistcoat . . . . . . . . . . . . . . . 413
Hill Descent Assist . . . . . . . . . . • . . • . . . . . 285
Hill Hold Assist . . . . . . . . . . . . . . . . . . . . . . 284
Horn ................•................ 11
Hubcaps . . . . . . . . . . . . . . . . . . . . . . . . 417, 420 Centre cover . . . . . . . . . . . . . . . . . . . . . . 418 Wheel bolt caps . . . . . . . . . . . . . . • . . . . . 419 Wheel cover . . . . . . . . . . . . . . . . . . . . . . . 419
ICC 173
Identification number . . . . . . . . . . . . . . . . . 451
If and when.......................... 410
Ignition see Engine and ignition . . . . . . . . . . . . . . 257
Ignition key see Key . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Ignition lock . . . . . . . . . . . . . . . . . . . . 258 Non-authorised vehicle key . . . . . . . . . . . 258 Withdrawal lock . . . . . . . . . . . . . . . . . . . . 258
Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . . . 260 Fault ............................. 257 In-car communication system . . . . . 173
Indicator lamp Adaptive chassis control (DCC) 317 Adaptive cruise control (ACC) . . . . • . . . . 300 AdBiue . . . . . . ............. 347 Airbag system . . . . . . . . . . . . . . . . . . . . . . 89 Brake pad wear indicator . . . . . . . . . . . . . 270 Brake system . . . . . . . . . . . . . . . . . . . . . . 270 Catalytic converter . . . . . . . . . . . . . . . . . . 407 Changing bulbs . . . . . . . . . . . . . . . . . . . . 433 Changing gear . . . . . . . . . . . . . . . . . . . . . 261 Checking the oil level . . . . . . • . . . . . . . . . 354 Coolant . . . . . . . . . . . . . . . . . • . . . . . . . . . 359 Cruise control system . . . . . . . . . . . . . . . 296 Depress brake . . . . . . . . . . . . . . . . . . . . . 270 Diesel particulate filter . . . . . . . . . . . . . . . 407 Engine management system . . . . . . . . . . 407 Engine oil sensor . . . . . . . . . . . . . . . . . . . 354 ESC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270 Exhaust purification system . . . . . . . . . . . 407 Filling the tank . . . . . . . . . . . . . . . . . . . . . 341 Fuel level . . . . . . . . . . . . . . . . . . . . . . . . . 341 In the driver door . . . . . . . . . . . . . . . . . . . . 43 Lane change assist system . . . . . . . . . . . 313 Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106 Overview . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Remote control key . . . . . . . . . . . . . . . . . . 38 Seat belt . . . . . . . . . . . . . . . . . . . . . . . . . . . 80 Tyre monitoring system . . . . . . . . . . . . . . 319 Windscreen washer fluid level . . . . . . . . . . 117
Indirect ventilation . . . . . . . . . . . . . . . . . . . . 329
Information stored in the control units . . . 398 Infrared-reflecting windscreen . . . . . . . . . . . 116
Instrument cluster . . . . . . . . . . . . . . . . . . . . . 16 Displays . . . . . . . . . . . . . . . . . . . . . 20, 21, 25 Indicator lamps . . . . . . . . . . . . . . . . . . . . . . 16 Instruments . . . . . . . . . . . . . . . . . . . . . . . . 20 Menu structure . . . . . . . . . . . . . . . . . . . . . . 25 Service interval display . . . . . . . . . . . . . . . 22 Symbols ........................... 16 Using menus . . . . . . . . . . . . . . . . . . . . . . . 27 Warning lamps . . . . . . . . . . . . . . . . . . . . . . 16 Instruments . . . . . . . . . . . . . . . . . • . . . . . . . . 20
Integrated child seat . . . . . . . . . . . . . . . . . . 102 Seat belt routing . . . . . . . . . . . . . . . . . . . . 1 05
Interior lights ................ , ........ 114
Interior lights, California . . . . . . . . . . . . . . . 208 Living area . . . . . . . . . . . . . . . . . . . . . . . . 209 Pop-up roof . . . . . . . . . . . • . . . . . . . . • . . 21 0 Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . 122
Interior monitoring system . . . . . . . . . . . . . . 44 ISOFIX.............................. 100 see Child seat . . . . . . . . . . . . . . . . . . • . . . 96
Index 473

Manual closing or opening Unlocking the selector lever lock manually
Manual gearbox ..................... . Refer also to Changing gears ........ . Towing .......................... .
Manual opening Driver door ...................... .
.4.15
263 263 447
414
Manual opening and closing . . . . . . . . . . 413 Sliding/tilting roof . . . . . . . . . . . . . . . . . . 415 Tailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . 414
Manual operation of the pop-up roof Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . 225 Preliminary work . . . . . . . . . . . . . . . . . . . 224 Securing the pop-up roof manually from out-side the vehicle . . . . . . . . . . . . . . . . . . . 225
Mattress, 3-seat bench Components . . . . . . . . . . . . . . . . . . . . . . . 198 Long bed . . . . . . . . . . . . . . . . . . . . . . . . . 201 Medium-length bed . . . . . . . . . . . . . . . . . 199 Short bed . . . . . . . . . . . . . . . . . . . . . . . . . 198 Stowing . . . . . . . . . . . . . . . 203
Mattress, bench seat bed California . . . . . . . . . . . . . . 197 Mattress, California, bench seatlbed . . 196
Maximum speed . . . . . . . . . . . . . . . . . . . . . 450
MEDIA-IN socket . . . . . . . . . . . . . . . . . . . . . . 14
Memory seats . . . . . . . . . . . . . . . . . . . . . . . . 70
Metal-coated windscreen . . . . . . . . . . . . . . . . . . . . . . . . . 116
Metal-coated windscreen .....•......... 116
Mileage display . . . . . . . . . . . . . . . . . . . . . . . 20
Mirror mode . . . . . . . • . . . . . . . . • . . . . . . . . 171
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . 121 Blind spot . . . . . . . . . . . . . . . . . . . . . • . . . 121 Exterior mirrors . . . . . . . . . . . . . . . . . . . . 123 Folding in the mirrors . . . . . . . . . . . . . . . . 124 Interior mirror . . . . . . . . . . . . . • . . . . • • . . 122 Mobile online services see Volkswagen Car-Net . . . . . . . . . . . . . 402
Mobile telephone Rear-seat telephony................. 187 Use without an external aerial . . . . . . . . . 399
Modifications . . . . . . . . . . . . . . . . . . . . . . . . 396 Modifications to the vehicle . . . . . . . . • . . . 394 Plates . . . . . . . . . . . . . . . . . . . . . . . . . . . 405
Move 3-seat bench ..... . ............. 74
Moving 2-seat arrangement, Business . . . . . . . . . 185 3-seat bench . . . . . . . . . . . . . . . . . . . . . . . 74 Bench seatlbed, California . . . . . . . . . . . . 195
Multi-flex board . . . . . . . . . . . . . . . . . . . . . . . 77
Multifunction steering wheel 27
Multivan
N
Assembling opaque shades for the wind-screen and the rear window . . . . . . . . . 176 Components of the opaque shades kit . . 175 Darkening the interior of the vehicle . . . . 175 Equipment . . . . . . . . . . . . . . . . . . . . . . . . 175 Fitting opaque shades for the windscreen and the rear window . . . . . . . . . . . . . . . 177 Fitting the opaque shades to the side win-dows . . . . . . . . . . . . . . . . . . . . . . . . . . . 178 Removing and stowing the opaque shades .1.79
Net partition . . . . . . . . . . . . . . . . . . . . . . . . 136
New engine . . . . . . . . . . . . . . . • . . . . . . . . . 394
New tyres . . . . . . . . . . . . . . . . . . . . . . . . . . 370
Noises Adaptive cruise control (ACC) . . . . . . . . . 299 Brake support systems . . . . . . . . . . . . . . 276 Engine . . . . . . . . . . . . . . . . . . . . . . . 259, 345 Rear axle differential lock . . . . . . . . . . . . . 286 Regeneration . . . . . . . . . . . . . . . . . . . . . . 409 Supplementary heating system . . . • . . . . 339 Tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . 378
Number of seats . . . . • . . . . . . . . . . . . . . . . . 64 Business . . . . . . . . • . . . . . . . . . . . . . . . . 180 California ..... , . . . . . . . . . . . . . . . . . . . 193 Multivan ........................... 64
Number plate light (LED) . . . . . . • . . . . . . . 434
0
Octane number . . . . . . . . . . . . . . . . . . . . . . 344
Odometer . . . . . . . . . . . . . . . • . . . . . . . . . . . . 20
Oil see Engine oil . . . . . . . . . . . . . . . . . . . . . 353
Oil dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . 356 Old tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . 368 On-Board Diagnostic System (OBD) . . . . . 399
On line services see Volkswagen Car-Net . . . . . . . . . . . . . 402
Opaque shades Cleaning . . . . . . . . . . . • . . . . . . . . • . . . . . 393
Opaque shades kit Fabric shade . . . . . . . . . . . . . . . . . . . . . . 216 Roller blind . . . . . . . . . . . . . . . . . . . . . . . . 217 Sliding blind . . . . . . . . . . . . . . . . . • . . . . . 217
Opaque shades kit, California Integrated . . . . . . . . . . . . . . . . . . . • . . . . . 217 Removable . . . . . . . . . . . . . . . . . . . . . . . . 216
Opaque shades kit, Multivan Assembling opaque shades for the wind-screen and the rear window . . . . . . . . . 176 Components . . . . . . . . . . . . . . . . . . . . . . . 175
Index I 475

Push-starting . . . . . . . . . . . . . . . . . . . . . . . . 257
R
Radar sensor . . . . . . . . • . . . . . . . . . . . 301, 309
Radio reception Aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . 406 Fault .........•...........•....... 406
Rail transport . . . . . . . . . . . . . . . . . . . . . . . . 405
Rain sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 119 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Ratchet straps . . . . . . . . . . . . . . . . . . . . . . . 128
Reading lights ...............•........ 114
Rear-seat telephony . . . . . . . . . . . . . . . . . . 187 Components . . . . . . . . . . . . . . . . . . . . . . . 189 First user pairing . . . . . . . . . . . • . . . . . . . 190 Function . . . . . . . . . . . . . . . . . . . . . . . . . . 190 Pairing . . . . . . . . . . . . . . . . . . . • . . . . . . . 190 Private mode . . . . . . . . . . . . . . . . . . . . . . 191 Telephone handset . . . . . . . . . . • . . . . . . . 191 User pairing . . . . . . . . . . . . . . . . . . . . . . . 190
Rear-view mirror . . . . . . . • . . . . . . . . . . . . . 122
Rear Assist Reversing camera . . . . . . . . . . . . . . . . . . 291
Rear axle differential lock . . . • . . . . . . . . . . 286 Functioning principle . . . . . . . . . . . . . . . . 286 Noises ........................... 286 Not switching on . . . . . . . . . . . . . . . . . . . . 286 Switching off . . . . . . . . . . . . . . . . . . . . . . . 286 Switching on . . . . . . . . . . . . . . . . . . . . . . . 286 Tyre wear . . . . . . . . . . . . . . . . . . . . . . . . . 286
Rear seat entertainment system . . . . . . . . 165 Care and protection . . . . . . . . . . . . . . . . . 165 Changing the language . . . . . . • . . 171 Components . . . . . . . . . . . . . . . . . . . . . . . 166 Controls on the LCD screen . . . . . . . . . . . 168 DVD player. . . . . . . . . . . . . . . . . . . . . . . . 167 Folding the LCD screen out and in . . . . . 167 Folding the screen out and in . . . . . . . . . . 167 Function settings . . . . . . . . . . . . . . . . . . . 171 Image settings . . . . . . . . . . .. . . . . . . . . . . 171 Main menu (DVD player) . . . . . • . . . . . . . 171 Main menu (screen) . . . . . . . . . . . . . . . . . 171 Remote control . . . . . . . . . . . . . . . . . . . . . 169 Settings on the DVD player . . . . . . . . . . . 171 Settings on the LCD screen . . . . . . . . . . . 170
Rear view camera system Camera .......................... 293 Camera lens . . . . . . . . . • . . . . . . . . . . . . . 293 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 293 General information . . . • . . . . . . . . . . . . . 292 Operating . . . . . . . . . . . . . . . . . . . . . . . . . 294 Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . 295 Requirements . . . . . . . . • . . . . . . . . . . . . . 292 Settings . . . . . . . . . . . . . . . . . . . . . . . . . . 292 Switching on and off . . . . . . . . . . . . . . . . . 294 Rear window heating . . . . . . . . . . 324, 326, 328
Recommendation for rest breaks . . . . . . . 315 Function . . . . . . . . . . . . . . . . . . . . . • . . . . 316 Operation by the user . . . . . . . . . . . . . . . 316 Switching on and off................. 316
Recording data during a journey . . . . . . . . 398
Rectifying faults on the camping equip-ment .............................. 254
Recycling end-of-life vehicles . . . . . . . . . . 407 Refitting . . . . . . . . . . . . . . . . . . . . . . . . 396, 405
Refrigerator box, Business . . . . . . . . . . . . 186 Battery monitor . . . . . . . . . . . . . . . . . . . . . 187 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 187 Refrigerator box, California . . . . . . . . . . . . 241 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Refuelling E10 . . . . . . . . . . . • . . . . . . . . • . . . . . . . . . 344
Regeneration . . . . . . . . . . . . . . . . . . . . . . . . 409
Remote control Rear seat entertainment system . . . . . . . 169
Remote control key Indicator lamp . . . . . . . . . . . • . . . . . . . . . . 38 see Key . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 Synchronising . . . . . . . . . . . . . . . . . . . . . . 39
Remote control (supplementary heating system) . . . . . . . . . . . . . . . . . . . . . . . . . . . 335 Auxiliary coolant heater . . . . . . . . . . . . . . 335 Auxiliary heater . . . . . . . . . . . . . . . . . . . . 335 Replacing the battery . . . . . . . . . . . . . . . . 337
Removable ashtray . . . . . . . . . . . . . . . . . . . 162
Remove and Install Single seats in the passenger compartment .7.3
Removing and Installing 3-seat bench . . . . . . . . . . . . . . . . . . . . . . . 74 Bench seaUbed, California . . . . . . . . . . . . 195 Single seats in the passenger compartment .7.3
Removing Ice . . . . . . . . . . . . . . . . . . . . . . . . 383
Removing snow . . . . . . . . . . . . . . . . . . . . . . 383 Removing wax . . . . . . . . . . . . . . . . . . . . . . . 383 Renewing parts . . . . . . . . . . . . . . . . . . . . . . 394
Repairing stone chips (note) Windscreen . . . . . . . . . . . . . . . . . . . . . . . 396
Repairs . . . . . . . . . . • . . . . . . . . . . . . . . 394, 396 Airbag system . . . . . . . . . . . . . . . . . . . . . 397 Lifting platform . . . . . . . • . . . . . . . . . . 401 Plates . . . . . . . . . . . . . . • . . . . . . . . . . . . . 405 Stickers . . . . . . . . . . . . . . . . . . . . . . . . . 405 Windscreen . . . . . . . . . . . . . . . . . . . . . . . 396 Replacement key see Key . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 Replacement parts . . . . . . . . . . . . . . . . . . . 395
Reprogramming control units . . . . . . . . . . 399
Requirements Rear view camera system . . . . . • . . . . . . 292
Index 477

Residual current circuit breaker . . . . . . . . 247 California Beach . . . . . . . . . . . . . . . . . . . . 247 California Coast and Ocean . . . . . . • . . . . 247
Retrofitting Car telephone . . . . . . . . . . . . . • . . . . . . . 398 Rear seats, Business . . . . . . . . . . . . . . . . 180 Rear seats, California . . . . . . . . . . . . . . . 193 Rear seats, Multivan . . . . . • . . . . . . . . . . . 64 seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 Two-way radio . . . . • . . . . . • . . • . . . . . . . 398
Retrofitting seats Business . . . . . . . . . . . • . . . . . . . . . . . . . 180 California . . . . . • . . . . . . . . . . . . . . . . . . . 193 Multivan . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Reversing camera . . . . . . . . . . . . . . . . . . . . 291
Rims .......................•....... 369 Bolted-on rings . . . . . . . . . . . . . . . . . . . . . 369 Bolted-on trims . . . . . . . . . . . . . • . . . . . . . 370 Identification . . . . . . . . . • . . • . . . . . • . . . . 370
Roll-back function Electric sliding door . . . . . . • . . . . . • . . . . . 48 Electric windows . . . . . • . . . . . . . . • . . . 57 Sliding/tilting roof . . . . . • . . • . . . . . . . . . . . 60
Rolling road test bed . . . . . . . • . . • . . . . . . . 286
Roof carrier . . . . . . . . . . . • . . . . . • . . . 137. 139
Roof ventilator . . . . . . . . . . . . . . . . . . . . . . . 331
Rotating front seats . . . . . • . . . . . . • . • . . . . . 71
RSE . . . . . . . . . . . . . . . . . . . . . • . . • . . . . . . . 165
Rubber seals . . . . • . . . . . • . . . . . . . . . . . . . 386
Running in
5
Brake pads . . . . . . . . . . . . . . . . . . . . . . . . 272 Engine ........................... 394 see Brakes . . . . . . . . . . . . . . . . . . . . . . . . 272 The first kilometres . . . . • . . . . . . . . . . . . . 394 Tyres . . . . . . . . . . . . . . . . . . . . . . . • . . . . 370
SAFELOCK mechanism . . . . . . . . . . . . . . . . 42
SAFE shown In the display . . . . . . . . . . . . . 260
Safety equipment. . . . . . . . . . . . . . . . . . . . . . 91
Scrapping . . . . . . . . . . . . . . . . . . . . . . . . . . . 407
Screen Changing the language . . . . . . . . . . . . . . 171 Folding in/out . . . . . . . . . . . . . . . . . . . . . . 167 Function settings . . . . . . . . . . . . . . . . . . . 171 Image settings . . . . . . . . . . . . . . . . . . . . . 171 Main menu . . . . . . . . . . . . . . . . . . . . . . . . 171 Settings . . . . . . . • . . • . . . . . . . . . . . . . . . 170 Screen mode . . . . . . . . . . . . . . . . . . . . . . . . 171
Seat adjustment Business . . . . . . . . . . . . . . . . . . . . . . . . . 182
Seat belt protection . . . . . . . . . . . . . . . . . . . . 83
Seat belt routing . . . . . . . . . . . . . . . . . . . . . . 85
478 I Index
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79 Automatic belt retractor . . . . . . • . . . . . • . . 86 Belt height adjuster . . . . . . • . . • . . . . . • . . 86 Belt status display . . . . . . . . . . • . . . . . . . . 80 Belt tensioner . . . . . . . . . . . . . . • . . . . . . . . 86 Checklist . . . . . . . . . . . . . . . . . • . . . . . . . . 83 Cleaning . . . . . . . . . . . . . . . • . . . . . . . . . . 392 Fastening . . . . . . . . . . . . . . • . . • . . . . . . . . 84 Not fastened . . . . . . . . . . . . . . . . . . . . . • . . 82 Seat belt routing . . . . . . . . . . . . • . . . . . • . . 85 Twisted seat belt . . . . . . . . . . . . . . . . . . . . 83 Unfastening . . . . . . . . . . . . . . . • . . . . . . . . 84 Using . . . . . . . . . . . . . . . . . . . . . . . . . . • . . 83 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 80
Seat belt warning lamp . . . . . . . . . . . . . . . . . 80
Seat covers . . . . . . . . . . . . . . . . . . . . . . . . . 388 Checklist . . . . . . . . . . . . . . . . . . . . . . . . . 389 Cleaning Alcantara . . . . . . . . . . . . . . . . . . 389 Cleaning and caring for natural leather . . 391 Cleaning cloth seat covers . . . . . . . . . . . . 389 Cleaning fabric trim . . . . . . . . . . . . . . . . . 389 Handling seat covers . . . . . . . . • . . . . . . . 389 Leatherette . . . . . . . . . . . . . . . . . . . . . . . . 392
Seat functions front . . . . . . . . . . . . . . . . . . . . . • . . . . . . . . 69 Passenger compartment . . . . . . . . . . . . . . 72 rear. . . . . . . . . . . . . . . . . . . . . . • . . . . . . . . 72
Seat functions, rear Business . . . . . . . . . . . . . . . . . . . . . • . . . 182 California . . . . . . . . . • . . . . . . . . . . . • . . . 193
Seat heating . . . . . . . . . • . . . . . . . . . . . . . . . . 69 Seat rails Business . . . . . . . . . . . . . . . • . . . . . . . . . 133 California . . . . . . • . . . . . . . . . . . . . . • . . . 133 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 393 Multivan . . . . . . . . . . . . . • . . . . . . . . . . . . 133
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . • . . . . 64 3-seat bench . . . . . . . . . . . . . . . . . . . . . . . 74 Adjusting head restraints . . . . . . . . . . . . . . 67 Adjusting the steering wheel position . . . . . 68 Electrically adjustable front seat . . . . . . . . 66 Electric lumbar support adjustment . . . . . . 66 Fitting head restraints . . . . . . . . . . . . . . . . 67 Mechanical front seats . . . . . . . . . . . . . . . . 65 Memory seats . . . . . . . . . . . . . . . . . • . . . . 70 Multivan ......................•.... 64 Number of seats . . . . . . . . . . . . . . . . . . . . . 64 Number of seats, Business . . . . . . . . . . . 180 Number of seats, California . . . . . . . • . . . 193 Removing head restraints . . . . . . . . . . . . . 67 Rotating front seats . . . . . . . . . . . . . . . . . . 71 Seat heating . . . . . . . . . . . . . . . . . . . . . . . . 69 Single seats in the passenger compartment .7.3
Securing straps Buckle straps . . . . . . . . . . . . . . . . . . . . . . 128 Ratchet straps . . . . . . . . . . . . . . . . . . . . . 128