oil VOLVO 700 1982 Service Owner's Guide

Bosch N1 14 V 31/100 A
Max amperage ........................... .................. .
Max output ............................................. 00 •••
Max speed ........................... 0 •••••••••••••••• 0 •••••
Direction of rotation ................ ............ 0 •••••••••••••
Diameter, slip rings, new ..................................... .
min (after machining) .
................ 0 •••• •
Max permissible run-out, slip rings ........................ 0 • 0 ••
rotor body .... o •••••••••••••••••• 0 ••••
Carbon brush spring force ............................. 0 • • 0 •• •
Min length, carbon brushes .................................. .
Tightening torque, attaching screws .
.......................... .
pulley nut .......... o ••••••••••••••••• o •••••
Test values
Resistance, rotor winding .................................... .
( stator ................. 0 ••••••••••••••••••••••• • ••
Amperage at 14 V (min value) ..................... ........ .. 0 •
• A low range ohm meter should be used .
Bosch NC 14 V 60 /120 A
Volvo PiN ............ ................... 0 •••••• ••• ••••••••••
Bosch number ........................... 0 •••••••••• 0 ••••••••
Max amperage ............................................ . .
Max output
................................ 0 •••••••••••••••••
Max speed ......................................... 0" 0 •••••
Direction of rotation ................................ 0 ••• ••••••
Diameter , slip rings, new ........ . 0 ••••••••••••••••••\
••••• •••••
min (after machining) ...................... .
Max permissible run-out,
slip rings ................. 0 •••••••••••
rotor body ........................... .
Carbon brush spring force ...
........................... ..... .
Min length, carbon brushes ... 0 • •••••••••• 0 ••••••• 0' 00.00 •••••
Tightening torque, attaching screws ................. 0 ••••• 0 ••••
pulley nut ........... 0 ••••••••••• 0 •• 0 0 • 0 ••••
Test va lues
Resistance, rotor winding ................... .... 0 •• •••••••••••
stator ..................................... ...... .
Amperage
at 14 V (min value) .................. 0 ••••••••• 0 ••••
Nippon Denso 80 A
Volvo PiN ............. ..................................... .
Nippon Denso number .
................ 0 •••••• 0 ••••• 0 •••••••• •
Max amperage .............. ............................... .
Max output .................... ............................. .
Max speed ............................... 0 ••• ••••••• •••• ••••
Direction of rotation ..... 0 •••••• 0 •••••••••••••••••• 0 ••••••••••
70019401960 Specifications
Section
3 E lectrical system
100A
1400W
250 rls (15000 rpm)
Clockwise
28 mm
27 mm
0.03 mm
0.05 mm
3-4N
5 mm
4 Nm
45-55 Nm
2 .6
n
ca 0.05 n
1 .063 in
0.0012 in
0.0019 in
0 .6-0.9Ib
0.2 in
3 ft Ib
33-40 ft Ib
31 A at 25 rls (1 500 rpm)
100 A at 100 rls (6000 rpm)
3523420
0120465 006
120A
1680W
300 rls (18000 r/min)
Clockwise
15 mm (0.59 in)
14
mm (0. 55 in)
0,003 mm (0.0001 in)
0,005 mm (0.0002 in)
3-5 N (0.3-0.5 kp)
5 mm (0.2 in)
4 Nm (3 ft Ib)
45-55 Nm (33-40 ft Ib)
2,6 n
0,02 n
60 Avid 30 rls (1 800 r/min)
120 Avid 100 rls (6000 r/min)
1398327
100211-8370
80A
1120W
300 rls (18000 r/min)
Clockwise
121
I
III II III II III -II III oil III
j

7001940;'960 Specifications
Section 3 Electrical System
Group 37 Fuses
1982-1983
Fu se Circuits protected
num -
ber Fuse
rating
30 + feed (c ir cu its alw ays live, ig nition off)
1 * Fuel pumps E-engines (fuel injection
B23ET) ........................... ...... 25A (via fuel pump relay)
2* Four-way hazard warning lamps ........ . 25A Headlight flasher (via fuses 17 and 18) Central locking system
3 Extra
lights (spot/fog lamps in air dam/
4
5
front spoiler) ............................ 15A
Brake lights ............. ................ 15A
Clock .......................... ......... 15A Vanity mirror lamp
Glove compartment lamp Engine and luggage compartment lamps
Interior lamp
Power aerial Door warning lamps
Radio
15 + feed (ignition II & III)
(fu ses 6 a 7 via relay)
6 Electric cooling fan ...................... 25A
7 Power windows .................. ....... 30A
8 Direction indicators ...................... 15A Constant idling (E & F engines) Solenoid valve (carb)
Hot start valve (carb)
Overdrive relay
Relay glow plugs , Diesel
9 Electrically heated rear window. . . . . . . . .. 30 A
Power sun roof
10 Instrumentation ...................... , .. 25A Reversing (back-up) lights Heated front seats
Seat belt reminder Spade terminals + 15 in central electrical
unit:
-Relay fuel pump -Relay power windows/electric cooling
fan
-Oil level sensor Delay valve AC Bulb failure warning
Seat belt reminder (USA & Canada)
11 Day running lights ...................... 25A Cruise control
128
Heater fan, CU low speed
ACC
1982-1983
Fuse Circuits protected
num -
ber
X-feed (ign ition I & II)
Fuse rating
12 Cigar lighter ... ......................... 15A Radio
Power door mirrors
Power seats
13 Horn ................................ ... 25A Windshield wash/wipe (intermittent relay)
Headlamp wash/wire
14 Heater fan, other speeds. . . . . . . . . . . . . . . .. 30 A
15 Tank pump E and F-engines via fuse number 1 .............................. . (only in circuit when starting and when en­gine is running)
Ma in and dipped beams
16 Rear fog lamps ......... .................
17 Indicator lamp, main beam .............. Main beam, left
18 Main beam, right. ....................... Relay, spot lights
19 Dipped beam, left .......................
20 Dipped beam, right ......................
Feed from light switch (58 )
15A
15A
15A
15A
15A
15A
21 Instrument and control lighting, front ..... 15A Tail and parking lights, left Number (license) plate light Light warning buzzer
22 Seat belt lock and ashtray light, rear ...... 15A Lighting, switches on trans tunnel
Tail and parking lights, right Relay, fog lamp (Sweden)
* Applies to 1983 models.
1982 models:
Four-way hazard warning lamps ......... 25A Headlight flasher (via fuses 17 and 18) Central locking system
2
Fuel pumps E-engine .................... 25A (via fuel pump relay)

(

1984
Fuse Circuits protected Fuse
num-rating
ber
30 + feed (circuit s alw ays live)
Fuel pumps E-engines + CI system ....... (via fuel pump relay)
Fuel i njection ((B 23 ET)
2 Four-way
hazard
warning lamps ......... Headlight flasher (via fuses 17 and 18)
ABS
3 Extra lights (spot/fog lamps in
air dam/ front spoiler) . ................ ... .. ......
Rear fog lamp relay
4 Brake lights .....
.. .............•........
5 C lock ....... ............. ............. ..
Vanity mirror lamp Glove compartment lamp Engine and luggage compartment lamps
Interior lamp Power aerial Door warning lamps
Radio
15+I-feed via relay (ignition II)
(fuses 6&7 via relay)
6 Electric cooling fan ................ ...... Fasten seat belt light Heated seats
7
p()\J\; er windows ........... . •.... ........
8 Day
running
lights ..... .......... ....... Bulb failure sensor Relay, power windows + cooling fan
9 Heated
rear
window ................. ....
Power sun roof Air conditioning
15+R-feed (ignition II & III)
10 Instrumentation ........................ .
Reversing (back-up) lights Ignition setting Cruise control
Spade terminals + 15 in central electrical
unit: -Oil level sensor
-Seat belt reminder (USA) -Exhaust gas temp sensor
-Relay, temp contro lled ign. advance)
-Converter (ABS)
25A
25A
15A
15A
15A
25A
30A
15A
30A
15A (25A)
11 Direction indicators.. .. .... .. . .... .. ..... 15A Overdrive relay (25 A) Constant idle speed system Glow plug relay Hot spot relay Warm start-valve (carb. engines)
70019401960 Specifications
Section
3 Electrical System
1984
Fuse C ircuit s protected Fuse
num-rating
ber
X-feed (ignition I & II)
12 Cigar lighter ...... ..............•....... 15A
Radio
Power door mirrors Power driver's seat
13 Horn ...... ........... .. ................ 25A
Windsh ield wash/wipe (interm ittent relay)
Headlamp wash/wipe
14 Fan motor .................. ......... ... 30A
Air conditioning
15 Tank pump E and F-engines via fuse num-ber 1 ...... ...................... ....... 15A
(only in circuit when starting and when en-
gine is running)
Main and dipped beams
16 Rear fog lamps (UK + S) ................ 15A
Headlamp cut-out
17 Indicator lamp, main beam .............. 15A
Main beam , left
18 Main beam, right .......•... ............. 15A IN
Relay, spot lights "I
19 Dipped beam, left ...... ................. 15A IIII( II.
20 D ipped beam, right ...........•.......... 15A "I II. II
Feed from light switch (58)
21 Instrument and control lighting, front ..... 15A
Tail and parking lights, left Number (license) plate light
22 Seat belt lock and ashtray light, rear ...... 15A
Panel light, auto selector lever Lighting, switches on trans tunnel Tail and parking lights, right Relay, auxiliary lamps
129

70019401960 Specifications
Section
3 E lectrical System
760 1985-1987 760 1985-1987
740 1985-1988 740 1985-1988
Fuse C ircuit s protected Fuse Fuse Circuits protected
Fuse nurn- r
ating nurn-rating ber ber
Fuel pumps
E-engines & CI system ....... 25A 12 Reversing (back-up) lights ............... 15A
(via fuel pump relay) Indicator lamp, low oil level Fuel injection (B 200 ET, B 230 ET) Overdrive
ETC Ignition advance
2 Hazard
warning
lights ................... 25A Cruise control
Headlight flash
(via number .17 & 18) ABS
Central lock
13 Fuel valve, diesel ........................ 15A ABS CIS
3 Relay, auxiliary lights .................... 15A Glow plugs, diesel
(spot/fog in front spoiler) Automatic choke
Relay , rear fog lights 14 Power door mirrors ..................... 15A
4 Brake lights .
............................ 15A Cigar lighter
Gear shift indicator (USA & CDN) Radio
5
Clock ................................... 15A Tailgate wiper
Vanity mirror light 15 Horn ..... ............................. . 25A
Glove compartment light Windscreen wiper
Engine compartrTJent and boot (trunk) light Headlight wash/wipe
Courtesy lighting 16 Heater fan .............................. 30A Radio AC Power aerial 17 Main beams, left ........................ 15A Door -open warning lamps 18 Main beams, right ....................... 15A 6 Heated
front seats .......... ........ 30 A (15A) Spot
lamps 7 Electric cooling fan ................. 25 A (30A) 19 Dipped beam, left ....................... 15A 8 Power windows ......................... 30A 20 Dipped
beam, right ...................... 15A 9 Direction
indicators ...................... 15A 21 Instrument and panel lighting ............ 15A Fasten seat belt light Tail lights & parking lights, left Heated front seats Numberplate lighting Power windows 22 Seat belt light & ashtray light, rear ....... 15A AC Selector panel light, automatic trans. Electric cooling fan
Lighting, trans. tunnel switches 10 Heated rear window ..................... 30A Tail lights & parking lights, right
Power sun roof Relay , auxiliary lights Power door mirrors 23 Power seats ............................. 15A 11 Tank pump ............................. 15A Day running lights 198B-Heated Lambda-sond 24 Supplementary restraint system (air bag). 30A
25 Day running lights ................... ... 15A Rear fog lights (USA & CDN) Dim/Dip (UK)
26 Power driver's seat ...................... 30A
130

70019401960 Specifications -------------------------------------------------------------
Oil pressure, overdrive
Direct drive .............................................. .. . .
Overdr ive engaged
D 24 TmC, with asbestos-free friction linings ................... .
Gasoline turbo with asbestos-free friction linings ................ .
Gasoline turbo with old type friction linings ..................... .
Remaining, with
old type friction linings ........................ .
All ......................................................... .
Early type friction linings (1987) ............................... .
Asbestos -
free linings (1988-) ................................. .
( Tightening torque data
8ellhousing ................................................. .
Gear
lever mounting bracket bolts ............................. .
Gearbox cover
bolts ......................................... .
Countershaft, M 47
.......................................... .
Drive
flange nuts, M 47, M 16 ................................. .
M20 ...................................... .
M46 ...................................... .
Rear cover, M 46
............................................ .
Rear cover,
5th gear synchronization, M 47 II ................... .
Oil drain plugs .............................................. .
Lubricant
/ Type ....................................................... .
Capacity, M46,
early type, -1990 Litres (US qts) ............... .
late type, 1991-Litres (US qts) ................. .
M
47, early type, Litres (US qts) ...................... .
late type, Litres (US qts) ....................... .
• On complaints about gearbox noise, Volvo Thermo oil (PIN 1161 243-9) can be used. Volvo Thermo oil is only recommended for vehicles driven in areas where
ambient temperature seldom drops below -10°C (+14°F), or high mileage vehicles such as taxis. NOTE: Do not mix oil types.
Section 4 Power Transmission
approx 0.15 MPa (21.3 psi)
Type J
2.8--3.1 MPa (400-440 psi)
2.8--3.1 MPa (400-440 psi)
3.9-4.2
MPa (555-600 psi)
3.7-4.0
MPa (525-570 psi)
Type P
2.8--3.1 MPa (400-440 psi)
Type J/P-hybrid
3.7-4.0 MPa (526-569 psi)
2.7-29
MPa (384-412 psi)
Nm ft Ib
35-50 (25-35)
40 (30)
15-25 (10-20)
35-45 (25-30)
70-90 (50-65)
90-110
(65-80)
165-180
(120-130)
12-18 (9-13)
120 (87)
27-40 (20-29)
Litres U S qts
ATF* type F or G
2 .3 (2.4)
2.6 (2.7)
1.3 (1.4)
1.6 (1.7)
139
I
.til I! II I! II I! ·1 , I!

70019401960 Specifications
Section 4 Power Transmission
Automat ic transmission BW 55
Make and type .. ............................................ .
Reduction ratios, 1 st gear ..
................. ................. .
2nd gear
................................... .
3rd gear
................... ................. .
Reverse
.................................... .
Torque converter, type ratio
................................ .. .
Lubricant.
........................... ....................... .
Fluid capacity .................... ........................... .
* ATF = automatic transmission fluid.
1.45:1 x Converter ratios
Borg
Wirner type
55
2.45 :1
1 : 1
2.21 : 1
1-approx 2:1
ATF, type G (or F)*
6.9
litres = 7.2 US qts (inc!. approx 2.5 litres = 2 .6
US qts in torque converter)
.~ Engine type Normal
stall speed*
rls (r/min)
Type
designation
Type plate
colour
....... WAOIIHUH
55 e:> ~~D ~~~I~ f'"OUTUTAUS
B28A 38.3 (2300) 029 SERIAl~ Light brown 131755 * At sea level.
Stall speed drops 2 rls (120 rpm) for each 1000 m increase in altitude .
Throttle cable setting
Distance between adjusting sleeve and stop
at idling .................................................. .
kick -down
........................ ........................ .
C leara nces
Oil pump: pump body -outer cog wheel ....................... .
arc segment -
large cog wheel ...................... .
axial clearance .................................... .
Clutch C2, brakes B1 and B2:
clearance between
clutch assembly pressure plate and
locking ..................................................... .
Input shaft, clutch C1 axial clearance .......................... .
Output shaft,
axial clearance ................................. .
Line pressure
Idling D .................................................... .
R ..................... .... ........................... .
Stall speed, D .................. .............. ...... ........ .
R .............................................. .
140 0.25-1
.0
mm 51 +1.6mm -0.6
0.07-0.30 mm
0.11-0 .50 mm
0.02-0.10 mm
0.3-1 .2 mm
0.20-0 .55 mm
0.20-0.55 mm
(0.001-0.040 in) (2 +0.63 in) (-0.024Ih)
(0.0027-0.118 in)
(0.004-0 .019 in)
(0.0008-0.004 in)
(0.0118-0 .0472 in)
(0.0078-0.0216 in)
(0.0078-0.0216 in)
0.53-0.63 MPa (75-90 psi)
0.74-0.91 MPa (105-129 psi)
1 .12 -1.37
MPa (159-195 psi)
1.54-1.96
MPa (219-279 psi)

Regulator press ure
Final drive ratio 3.31:1
At 30 km/h (19 mph) ........................................ .
At 60 km/h (38 mph) ....... ................................. .
At 110 km/h (69 mph) ....................................... .
Gea r ch anging speeds
Limits for kick -down shift points , km/h (mph)
1-2 ........................................................ .
2 - 3
......... ............................................... .
3-2 ............................. ........................... .
3-1 ...................................................... .. .
Tran smiss io n brake an d clut ch pla tes
Min permissible thickness .................................. .. .
( Tig ht enin g to rq ue da ta
Drive plate - torque converter ....................... ......... .
Torque converter casing -engine, M
10 ....................... .
M12 ..................... ..
Center support -transmission housing
tighten
alternately in steps of 7 Nm (5 ft Ib) ................... .
Pump cover -pump housing
.................. ............... .
Pump -transmission housing ...
............................. .
Plate above parking detent ............................ .... ... .
Torque converter casing -transmission housing
4 x M
10 .................................................. .
2xM12 ....... . r. ............... ......................... .
Rear housing -transmission housing .......................... .
Valve bodies -transmission casing ........................... .
Valve bodies, for cam, M 6 ................................... .
Valve bodies, other bolis, M 5 ................................. .
Cover
plate - gearbox housing ............................... .
Strainer -
lower valve housing M 6 ......................... ... .
Oil pan - transmission housing (yellow gasket) ................. .
Oil pan -transmission housing (blue gasket) ................... .
Drive
plate - output shaft .... ............................. ... .
Blind plug, for pressure test ....................... .. ......... .
* Seal with Locking fluid 1 161 053-2 (1 161 054-2) .
0.10-0.13 MPa
0.14-0.18 MPa
0.30-0.36 MPa
71 (44)
128
(80)
117 (73)
approx.
60 (38)
2.1 mm
Nm
41-50
35-50 55-90
24-28
6-9
22-28
6-9
Nm
26-40
47 -60
26-40
8-12
6-9
5-6
5-6
6-9
6-10
8-12
40-50·
9-12
70019401960 Specifications
Section 4 Power Transmission
(14-18 psi)
(20-26 psi)
(43-51 psi)
(0.083 in)
ftlb
(30-37)
(26-37)
(41-66)
(18-21 )
(4-6)
(16-21)
(4-6)
ftlb
(19-29)
(35-44)
(19-29)
(7-9)
(4-6)
(3-4)
(4-6)
(3-4)
(4-8)
(7-9)
(29-37)
(6-9)
141
'", "" '", "" ·11"
"" ·11.· 1111 ,11'

(
Throttl e cable se tting
Distance between adjusting sleeve and cable stop
at idling .............................. mm 0.25-i.O
(in) (0. 001-0.040)
kick-down ............. .... mm 50.4-52.6 (1.99-2.1)
Sol e n o id va lv e
Resistan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 0
C lea ra n ces
Oil pump : pump body -outer gear wheel. ............... mm (in)
arc segment -large gear wheel ...................... mm (in)
axial clearance ................................ ..... mm (in)
Brake BO: clearance between clutch pressure plate
and lock ring ....................................... mm (in)
Clutch C2, brakes B1 and B2
clearance between clutch assembly pressure plate
and lock ring ....................................... mm (in)
Input shaft, clutch CO, axial clearance ........... ... ..... mm (in)
Output shaft, axial clearance ................. .......... mm (in)
B ra ke a nd clutch ring s
0.07-0.15
0 .
11-0.14
0 .
02-0.05
0.35-1.60
0.3--1.2
0 .
3--0.9
0.3--0 .9
Minimum permissible thickness ..................... .... mm (in) 2.1 mm
Line pr ess ure
Engine Tra nsmi ssion Press ure, 0
MPa (psi)
B
19/200 ElF AW70 0.35-0.44
(50--63)
B23E AW71 "
B230K -1986 AW71 "
B200K, B230F AW70 0.46-0.54 (65-77)
B23/230FT AW71 "
B 230 A
, B 230 FB AW71 "
B230K 1987-AW71 "
B28A, E, F AW71 "
B234 FIG AW72 0.44-0
.52 (63--74)
B280
AW71 0.51 (73)
S tall spee d press ure
Engine T
ra n smi ssion Press ure, 0
MPa (psi)
B
19/200 E AW70 1.00--1.20 (142-205)
B23E AW71 "
B230K -1986 AW71 "
B 200 K, B 230 F AW70 1.00--1.20 (142-205)
B23/230 FT AW71 "
B 230 A, B 230 FB AW71 "
B230K 1987-AW71 "
B28A, E, F AW71 "
B234 FIG AW72 1.12
-1.32 (159-188)
B280 AW71 1
.15 (164)
7001940 1960 Specifications
Section
4 Power Transmission
025-10mm
(0.003 -0 .006)
(0.0043--0 .0055)
(0.0008-0.0019)
(0.0138-0.0629)
(0.0118-0.0472)
(0.0118-0.0354)
(0.0118-0 .0354)
(0.083)
Pres sur e, R
MPa (psi)
0.50--0 .64 (71-91)
"
"
0.70--0.82 (106-117)
"
"
"
"
0.64-0.76 (91-109)
0 .
77 (110)
Press ure, R
MPa (psi)
1.37-1.70 (195-242) "
"
1.50--1.90 (213-270)
- -
"
"
"
1 .55-1.95 (220--277)
1 .
74 (247)
-
143
I
I
I
I

(
(
Tightening torques
AW70, AW71, AW72
Converter casing -engine, M 10 ...................... .. ...... .
M12 .................. ......... .. . .
Drive plate
to torque converter ................... ............. .
Centre support to gear case:
tighten alternately
in steps to 7 Nm (5 ft Ib) ............... ... .
Pump cover to pump body .......................... ......... .
Pump assembly to gear case .............. ................... .
Plate above parking pawl ............................. ....... .
Converter casing gear case
4
x M 10 ................................ ................. .
2 x M 12 ..
.............. ................................. .
Rear extension housing to gear case
.......................... .
Valve bodies, for cam M 6 .................................... .
other bolts, M 5 ...
.............................. .
Oil strainer to lower valve body ........... .. ............ ...... .
Cover plate
to gear case, M 6 ................................ .
Valve body to gear case ..................... .......... ..... . .
Oil pan to gear case .......... ........ ..................... .. .
Coupling flange
to output shaW .................... ........... .
Blind plug for pressure test. . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..
... .
Nut, oil cooler to gear case .
.................................. .
Speedometer drive
................... .................. ..... .
Nut, oil dipstick tube
........ ................................. .
Solenoid valve
.................... .. ........................ .
Drain plug
to oil pan ........................................ . .
• Use locking fluid PIN 1161 053-2 (1161 054-0) .
Nm
35-50
55-90
41-50
24-28
6-9
22-28
6-9
27-42
48-68
27-47
6-9
5-6
5-6
6-9
8-12
4-5
40-50
5-9
20-30
4-6
65-70
10-16
18-23
70019401960 Specif ications
Section
4 Power Transmission
ftlb
(25-36)
(40-65)
(30-36)
(17-20)
(4-6)
(16-20)
(4-6)
(20-30)
(35-49)
(20-34)
(4-6)
(3.5-4)
(3.5-4)
(4-6)
(6-9)
(3-3.5)
(30-36)
(3.5-6)
(14-22)
(3-4)
(47-51)
(7-12)
(13-17)
145
II
" II ., II ' . .. • • ..

700/940/960 Specifications
Section
4 Powe r Transmission
Components
Contro l unit
-Volvo part number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515646
ShiH position sensor
-Volvo part number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515639
- Aisin Warner number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9903740153
Mode se lector
-Volvo part number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515640
Solenoids :
ShiH solenoid
1 (51) and 2 (52)
-Volvo part number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515643
- Aisin Warner number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9903740040
Resistance at +25°C (7rF). . . . . . . . .. ... . . . . . . . . .. . . . . .. . . . . .. 13±20
Lock-up so lenoid (SL)
-Volvo part number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515644
- Aisin Warner number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9903740041
Resistance at +25°C (7rF) ............. " . . . . . . . . . . . . .. . . .. . . 13±20
Line pressur e sole noid (5TH)
-Volvo part number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515645
- Aisin Warner number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9903457389
Resistance at +25°C (7rF). . . . . . . . . . . . . ... . .. ..... . . . . ... .. . . 13±20
Speed sensor
-Volvo part number ... ..-: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515641
- Aisin Warner number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9903740151
Oil te mp eratur senso r
-Volvo part number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3515642
- Aisin Warner number. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9903740154
Resistance at
+160°C (320°F)......... .. .... . ......... ....... .............. 20.7±2.90
-O°C (32°F) .. . . . . . . .. . . . . . . . . . . . . . . .. . . . . . . .. . . .. . . . .. . . . . . . 2067±396 0
20670
Tightening torques
Nm (ft Ib)
Converter casing -engine, starter motor (2 pcs) ................ . 40.0 30 others .............. ............... . 48.0 35
Drive plate -torque converter ................................ . 30.0 22
Coupling flange to output shaft ............................... . 50.0 36
Plug, oil pan ................................................ . 20.0 14
148