brake fluid Acura MDX 2004 Owner's Manual

This indicator comes on when you
turn the ignition switch to ON (II)
with the headlight switch off and the
parking brake set. It should go of f if
youturnontheheadlightsorrelease
the parking brake. If it comes on at
any other time, it means there is a
problem with the DRL. There may
also be a problem with the high
beam headlights.
This indicator comes on when you
set the cruise control. See pagef or inf ormation on operating the
cruise control. This indicator comes on with the
high beam headlights. See page
f or inf ormation on the headlight
controls.
On Canadian models, this indicator
comes on with reduced brightness
when the Daytime Running Lights
(DRL) are on (see page ).
This indicator comes on as a
reminder that you must ref uel soon. This indicator comes on when the
washer f luid level is low. Add washer
fluidwhenyouseethisindicator
comes on (see page ).
72
74 209
144
Canadian models only
Inst rument s and Cont rols
‘‘Daytime Running
Lights’’ Indicator
Cruise Control Indicator High Beam Indicator
Low Fuel Indicator
Washer Level Indicator
Instrument Panel Indicators
61

Towing generally requires a variety
of supplemental equipment. To
ensure the best quality, we
recommend that you purchase Acura
equipment whenever possible.
Discuss any additional needs with
your trailer sales or rental agency,
and make sure all equipment is
properly installed, maintained, and
also meets state regulations.
A weight distributing hitch is not
recommended f or use with your
MDX.Always use saf ety chains when you
tow a trailer. Make sure the chains
are secured to the trailer and hitch,
and that they cross under the tongue
and can catch the trailer if it
becomes unhitched. Leave enough
slack to allow the trailer to turn
corners easily, but do not let the
chains drag on the ground.
This device is recommended if your
trailer tends to sway. Your trailer
maker can tell you what kind of sway
control you need and how to install it.
To help prevent overheating, a
heavy-duty transmission f luid cooler
and a heavy-duty power steering
f luid cooler are required f or trailer
towing. These coolers are available
only f rom your Acura dealer.
Acura requires that any trailer with a
total trailer weight of 1,000 lbs (455
kg) or more have its own brakes.
There are two common types of
trailer brakes: surge and electric.
Surge brakes are common f or boat
trailers, since the brakes will get wet.
Electric brakes must be
electronically actuated. Do not
attempt to tap into your vehicle’s
hydraulic system. See your brake
manuf acturer f or more inf ormation
on installing electric brakes.
Many states and provinces require
special exterior mirrors when towing
a trailer. Even if they don’t, you
should install special mirrors if you
cannot clearly see behind you, or if
the trailer creates a blind spot.
We strongly recommend that you
have your Acura dealer install an
Acura hitch and use the required
f luid coolers. Using non-Acura
equipment may result in serious
damage to your vehicle. T owing Equipment and
A ccessories
Hitch
Weight Distributing Hitch Saf et y Chains
Sway Cont rolT ransmission Fluid Cooler andPower St eering Fluid Cooler Trailer Brakes
Trailer Mirrors
Towing a Trailer
Driving188

This section explains why it is
important to keep your vehicle well
maintained and how to f ollow basic
maintenance saf ety precautions.
This section also includes
Maintenance Schedules f or normal
driving and severe driving conditions,
a Maintenance Record, and instruc-
tions f or simple maintenance tasks
you may want to take care of
yourself .
If you have the skills and tools to per-
f orm more complex maintenance
tasks on your Acura, you may want
to purchase the Service Manual. See
page f or inf ormation on how to
obtain a copy, or see your Acura
dealer.......................
Maintenance Saf ety .196
.................
Maintenance Schedule . 197
....................
Maintenance Record .201
..............................
Fluid Locations .204
........................
Adding Engine Oil .205
.........
Changing the Oil and Filter . 206
..............................
Engine Coolant .208
....................
Windshield Washers .209
....
Automatic Transmission Fluid . 210
..........................
Dif f erential Fluid .211
.............
Transf er Assembly Fluid . 211
....................................
Brake Fluid .212
....................
Power Steering Fluid . 213
....................................
Timing Belt .213
....................................
Hood Latch .214
.............................................
Lights .214
.......................................
Seat Belts .218
.....................................
Floor Mats .218
.................................
Wiper Blades .219
...............................................
Tires .221
...................
Checking the Battery . 226
.............................
Vehicle Storage .227
269
Maintenance
Maint enance195

Î
ÎÌ
Ì
Ì
Î
Î Î
Maint enance199
Service the items listed at the indicated distance (or time, if given).
miles x 1,000
km x 1,000 Check oil and coolant at each fuel stop
Check inflation and condition once a month
Every 7,500 miles (12,000 km)
Every 3 years (independent of mileage)
At 120,000 miles (192,000 km) or 10 years, then every 60,000 miles (96,000 km) or 5 years
( (
O
O r
re
ev
ve
er
ry
y 7
7y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
(
O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
( O
O r
re
ev
ve
er
ry
y 2
2y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Every 7,500 miles (12,000 km) or every 1 year, whichever comes first
At every 15,000 miles (24,000 km) up to 30,000 miles (48,000 km) or every 1 year, then every 30,000 miles (48,000 km) or 2 years. At 45,000 miles (72,000 km) or 3 years, then every 30,000 miles (48,000 km) or 2 years.
See information on maintenance and emissions warranty, middle column, page .
( ( O
O t
th
h e
er
rw
w i
is
se e a
ad
d j
ju
u s
stt o
o n
nl
ly
y i
if
f n
n o
oi
is
sy y )
)
120
192 135
216150
240
90
144
75
120
60
96
45
72
30
48
15
24 105
168
Check engine oil and coolant
Check tires
Replace engine oil
Rotate tires (follow pattern on page 223)
Replace engine oil filter
Check front and rear brake wear
Check parking brake adjustment
Inspect the following items: Tie-rod ends, steering gearbox, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system
Fuel lines and connections
Inspect drive belts
Replace dust and pollen filter
Replace air cleaner element
Inspect valve clearance
Replace automatic transmission fluid
Replace transfer fluid
Replace VTM-4 rear differential fluid
Inspect idle speed
Replace spark plugs
Replace timing belt and inspect water pump
Replace engine coolant
Replace brake fluid
1:
2:: 198
1
1 2
Maintenance Schedule for Normal Conditions

Î
Î
ÎÌ
Ì
Ì
ÎÎ
ÌÎ
Maint enance200
Service the items listed at the indicated distance (or time, if given).
miles x 1,000
km x 1,000 Check oil and coolant at each fuel stop
Check inflation and condition once a month
Every 7,500 miles (12,000 km)
Every 3,750 miles (6,000 km) or every 6 months, whichever comes first
7.5
12 15
2430
4845
7260
9675
120 90
144 105
168 135
216150
240
( (
O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
( O
O r
re
ev
ve
er
ry
y 2
2y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Every 15,000 miles (24,000 km) (Use normal schedule except in dusty conditions)
(
(O
O t
th
h e
er
rw
w i
is
se e a
ad
d j
ju
u s
stt o
o n
nl
ly
y i
if
f n
n o
oi
is
sy y )
)
(
( O
O r
re
ev
ve
er
ry
y 7
7y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
At 120,000 miles (192,000 km) or 10 years, then every 60,000 miles (96,000 km) or 5 years
Every 3 years (independent of mileage)
At every 7,500 miles (12,000 km) up to 15,000 miles (24,000 km) or every 6 months, then every 15,000 miles (24,000 km) or 1 year.
See timing belt on page for replacement information under special driving conditions. Follow this schedule for rear differential fluid replacement if you use your vehicle for off-highway driving, trailer towing, mainly in stop-and-go driving. Otherwise, use
the fluid replacement schedule in the Maintenance Schedule for Normal Conditions.
See information on maintenance and emissions warranty, middle column, page . Every 7,500 miles (12,000 km) or every 6 months, whichever comes first
120
192
Check engine oil and coolant
Check tires
Replace engine oil and oil filter
Rotate tires (follow pattern on page 223)
Check front and rear brake wear
Inspect the following items: Tie-rod ends, steering gearbox, and boots
Suspension components, Driveshaft boots
Check parking brake adjustment
Lubricate all hinges, locks and latches
Inspect the following items: Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system
Fuel lines and connections
Lights and controls/vehicle underbody
Inspect drive belts
Replace dust and pollen filter
Replace automatic transmission fluid
Replace transfer fluid
Replace air cleaner element
Inspect valve clearance
Replace VTM-4 rear differential fluid
Inspect idle speed
Replace spark plugs
Replace timing belt , and inspect water pump
Replace engine coolant
Replace brake fluid 1:
2:
3: : 198
213
1, 2
,3
Maintenance Schedule for Severe Conditions

Fluid Locations
Maint enance204
ENGINE OIL DIPSTICK
(Orange loop)
WASHER FLUID
(Blue cap)COOLANT
RESERVOIR
POWER STEERING
FLUID (Red cap) RADIATOR CAP ENGINE OIL FILL CAPAUTOMATIC
TRANSMISSION
FLUID DIPSTICK
(Yellow loop)
BRAKE FLUID
(Gray cap)

µµ
If it is not, slowly add proper f luid
until it starts to run out of the hole.
Reinstall the f iller plug and tighten it
securely.
Tightening torque:
UseaSAE90orSAE80W-90
viscosity hypoid gear oil, API service
classif ied GL4 or GL5 only, in the
transf er assembly.
Viscosity
The transf er assembly f luid should
be drained and ref illed with new f luid
accordingtothetimeanddistance
recommendations in the
maintenance schedule. Check the f luid level in the brake
f luid reservoir monthly. Replace it
according to the maintenance
schedule recommendations.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. Using any non-Honda
brake fluid can cause corrosion and
decrease the lif e of the system. Have
the brake system f lushed and ref illed
with Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Tightening torque:
T ransf er A ssembly Fluid, Brake Fluid
Maint enance
Brake Fluid
212
MAX
MIN
33 lbf·ft (45 N·m , 4.6 kgf·m)SAE 90: above 0°F ( 18°C)
SAE 80W-90: below 0°F ( 18°C)

CONT INUED
...
Accessories and Modif ications . 163
ACCESSORY (Ignition Key .......................................
Position) .79
............
Accessory Power Sockets . 101
....................
Additives, Engine Oil . 206
...............................
Airbag (SRS) .9, 22
..............
Air Conditioning System . 104
.....................
Rear A/C Control .109
.........................................
Usage .105
.......................
Air Outlets (Vents) .106
.......................
Air Pressure, Tires .221
......................................
Antif reeze .208
Anti-lock Brakes (ABS) ....................
Indicator Light .59, 181
...................................
Operation .181
..............
Anti-thef t, Audio System . 129
.
Anti-thef t Steering Column Lock . 79
................
Audio System . 110,115,125
...
Automatic Seat Belt Tensioners . 20
.........................
Automatic Lighting .73
.............
Automatic Speed Control . 144
..............
Automatic Transmission . 172
..........................
Capacity, Fluid .254
...............
Checking Fluid Level . 210.......................................
Shif ting .172
.
Shif t Lever Position Indicator . 172
................
Shif t Lever Positions . 172
....................
Shif t Lock Release . 175
...........................
Automatic Wipers .70
Battery Charging System ...........................
Indicator .58, 242
............................
Jump Starting .238
..............................
Maintenance .226
............................
Specif ications .255
..............................
Bef ore Driving .157
....................................
Belts,Seat .8,19
...........................
Beverage Holders .99
..................................
Booster Seats .48
Brakes ...........
Anti-lock System (ABS) . 181
.............
Break-in, New Linings . 158
...........................................
Fluid .212
....................
Bulb Replacement .216
.........................................
Parking .92
.................
System Indicator . 59,244
........................
Wear Indicators .180 .............................
Braking System .180
.................
Break-in, New Vehicle . 158
..
Brightness Control, Instruments . 74
........................
Brights, Headlights .72
Bulb Replacement ..........................
Back-up Lights .216
..............................
Brake Lights .216
................
Front Parking Lights . 215
........
Front Side Marker Lights . 215
.................................
Headlights .214
.........
High-mount Brake Light . 217
.................................
Rear Bulbs .216
............................
Specif ications .255
....................
Turn Signal Lights . 215
..............................
Bulbs, Halogen .214
Index
A
B
I

Î
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 56
................
Daytime Running Lights . 74
.................................
Dead Battery .238
............
Def ects, Reporting Saf ety . 268
................
Def ogger, Rear Window . 75
..............
Def rosting the Windows . 107
..........................
Dif f erential Fluid .211
....................................
Dimensions .254
...............
Dimming the Headlights . 72
Dipstick ..........
Automatic Transmission . 210
..................................
Engine Oil .161
..........................
Directional Signals .72
........
Disc Brake Wear Indicators . 180
.....................
Disposal of Used Oil .207
Doors ..............
Locking and Unlocking . 80
....................
Lockout Prevention . 80
......................
Power Door Locks .80
................................
Cancel Button .144
............................
Capacities Chart .254
.............
Carbon Monoxide Hazard . 51
.............................
Carrying Cargo .165
Cassette Player ............................................
Care .127
...................................
Operation .125
..............
CAUTION, Explanation of . ii
.........................................
CD Care .119
..........................
CD Changer .116, 117
.....
CD Changer Error Messages . 122
.......................................
CD Player .116
.........
CD Player Error Messages . 120
........................
Certif ication Label .252
...................................
Chains, .225
Change Oil ........................................
How to .206
......................................
When to .197
....................
Changing a Flat Tire .231
...
Charging System Indicator . 58,242
............
Checklist, Bef ore Driving . 170
..................
Childproof Door Locks . 80
.....................................
Child Saf ety .33
..............................
Booster Seats .48 .............................
Child Seats .40, 41
.....
Important Saf ety Reminders . 36
..........................................
Inf ants .38
..........................
Larger Children .47
.........................................
LATCH .42
......................
Risks with Airbags .34
.............................
Small Children .39
..........................................
Tether .45
.........
Where Should a Child Sit? . 34
.......................................
Child Seats .40
..........
Tether Anchorage Points . 45
...............
Climate Control System . 104
..............................................
Clock .130
.....................
Code, Audio System .129
........................
CO in the Exhaust .259
......................
Compact Spare Tire .230
...............
Consumer Inf ormation . 266
.............
Controls, Instruments and . 55
Coolant ........................................
Adding .208
....................................
Checking .162
.........................
Proper Solution .208
...................
Temperature Gauge . 67
Crankcase Emissions Control ........................................
System .259
................
Cruise Control Indicator . 61............
Cruise Control Operation . 144
.....................................
Cup Holders .99
..........
Customer Relations Of f ice . 266
tires
Index
C
D
II

CONT INUED
...................................
Fan, Interior .105
Features, Comfort and ..............................
Convenience .103
....................
Filling the Fuel Tank . 159Filters
...............................................
Oil .206
.............
Flashers, Hazard Warning . 74
...................
Flat Tire, Changing a . 231
Fluids ..........
Automatic Transmission . 210
..........................................
Brake .212
......................
Dif f erential Fluid .211
..........................
Power Steering .213
...................
Transf er Assembly . 211
..................
Windshield Washer . 209
FM Stereo Radio ...................................
Reception .113
........................................
Fog Lights .75
................
Folding the Second Seat . 87
...................
Folding the Third Seat . 88
..........................
Four-way Flashers .74
........................................
Front Seat .84
......................................
Adjusting .84
.........................................
Airbags .23
.........................................
Heaters .89
..........
DOT Tire Quality Grading . 256
...........
Driver and Passenger Safety . 5
...........................................
Driving .169
....................................
Economy .162
Driving Position Memory ..........................................
System .94
..................
DVD Error Messages . 140
...................................
DVD Player .133
..............................
Economy, Fuel .162
..................................
Emergencies .229
.............
Battery, Jump Starting . 238
...........
Brake System Indicator . 244
................
Changing a Flat Tire . 231
.....
Charging System Indicator . 242
..................
Checking the Fuses . 246
.........
Hazard Warning Flashers . 74
.....
Low Oil Pressure Indicator . 242
...
Malf unction Indicator Lamp . 243
..................
Overheated Engine . 240
.......................................
Towing .244
...........................
Emergency Brake .92
......................
Emergency Flashers .74
......................
Emergency Towing .244 .......................
Emissions Controls .259
Engine ....
Coolant Temperature Gauge . 67
Malf unction Indicator ................................
Lamp .58, 243
........
Oil Pressure Indicator . 58,242
..............
Oil, What Kind to Use . 205
...............................
Overheating .240
............................
Specif ications .255
............................
Speed Limiter .174
.......................................
Starting .171
...................
Engine, .237
.
Evaporative Emissions Controls . 259
...............................
Exhaust Fumes .51
Exhaust Gas Recirculation ........................................
System .260
Expectant Mothers, Use of Seat ........................................
Belts by .17
if it won’t start
Index
E
F
III