maintenance schedule Acura RSX 2003 Owner's Guide

Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If the level is below the lower
mark, add f luid into the f iller hole
to bring it to the upper mark.
Always use Honda ATF-Z1
(Automatic Transmission Fluid). If it
is not available, you may use a
DEXRON
III automatic
transmission f luid as a temporary
replacement. However, continued
use can affect shift quality. Have the
transmission f lushed and ref illed
with Honda ATF-Z1 as soon as it is
convenient.
To thoroughly f lush the transmission,
the technician should drain and ref ill
it with Honda ATF-Z1, then drive the
vehicle a short distance. Do this
three times. Then drain and ref ill the
transmission a f inal time.
Insert the dipstick all the way into
the transmission securely as
shown in the illustration.
Remove the dipstick and check
the f luid level. It should be
between the upper and lower
marks. 5.
6.
4. 3.
T ransmission Fluid
Maint enance218
UPPER
MARK
LOWER
MARK

Check the f luid level in the reser-
voirs monthly. There are up to two
reservoirs, depending on the model.
They are:Brake f luid reservoir (all models)
Clutch f luid reservoir
(manual transmission only)
The brake f luid should be replaced
according to the time recommenda-
tion in the maintenance schedule.
Check the f luid level with the
transmission at normal operating
temperature and the car sitting on
level ground. Remove the
transmission f iller bolt and caref ully
f eel inside the bolt hole with your
f inger. The f luid level should be up
to the edge of the bolt hole. If it is
not, add Honda Manual Transmis-
sion Fluid (MTF) until it starts to
run out of the hole. Reinstall the
f iller bolt and tighten it securely. If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives and continued use can
cause stiffer shifting. Replace as
soon as it is convenient.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
CONT INUED
Brake and Clutch Fluid
Manual Transmission
Transmission Fluid, Brake and Clutch Fluid
Maint enance219
Correct level
FILLER BOLT

To replace it:Loosen the f ive bolts.
Clean the air cleaner element by
blowing compressed air through it in
the opposite direction to normal air
f low. If you do not have access to
compressed air (such as a service
station), ask your Acura dealer to do
this service. The air cleaner element should be
cleaned or replaced according to the
time and distance recommendations
in the maintenance schedule.
Unsnap the clamp, then remove
the intake air duct f rom the f ront
of the air cleaner housing.
Use a pair of pliers to slide back
the clamp on the breather tube
attached to the side of the housing.
The air cleaner element is inside the
air cleaner housing on the driver’s
side of the engine compartment. Follow the replacement procedure
for removal and reinstallation.
1.
2.3.
A ir Cleaner Element
Maint enance
Cleaning (Severe Conditions)
Replacement
222
AIR CLEANER
HOUSING
BREATHER TUBE
INTAKE AIR DUCT BOLTS

Clean the hood latch assembly with a
mild cleaner, then lubricate it with a
multipurpose grease. Lubricate all
the moving parts (as shown),
including the pivot. Follow the time
and distance recommendations in
the Maintenance Schedule. If you
are not sure how to clean and grease
the latch, contact your Acura dealer.The spark plugs in your car should
be replaced according to the time
and distance recommendations in
the maintenance schedule.
Clean off any dirt and oil that have
collected around the ignition coils. Remove the four nuts, then
remove the coil cover.
1.
2.
ReplacementSpark Plugs
Hood L atch
Maint enance
Hood L at ch, Spark Plugs
224
LATCH
ASSEMBLY
PIVOTS COIL
COVER
NUTS

An auto-tensioner adjusts the tension
of the drive belt. The indicator on
the auto-tensioner should be in the
proper range. It should be checked
accordingtothetimeanddistance
recommendations in the
maintenance schedule.If the indicator is not within the
proper range, have the drive belt
replaced by your Acura dealer as
soon as possible.
Drive Belts
Maint enance
Drive Belt
234
INDICATOR
Proper range

Block the rear wheels.
Fill the f uel tank.
Change the engine oil and f ilter
(see page ).
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc. are
completely dry.
If you need to park your car f or an
extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your car back on the road. If
possible, store your car indoors.
If the car is to be stored for a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the car is being stored indoors).
Disconnect the battery.
Support the f ront and rear wiper
blade arms with a f olded towel or
ragsotheydonottouchthe
windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and hatch seals. Also, apply a body
wax to the painted surf aces that
mate with the door and hatch seals.If possible, run the engine f or a
while periodically (pref erably once
amonth).
If you store your car f or 12 months
or longer, have your Acura dealer
perf orm the inspections called f or in
the 24 months/30,000 miles (48,000
km) maintenance schedule (Normal
Conditions) as soon as you take it
out of storage (see page ). The
replacements called f or in the
maintenance schedule are not
needed unless the car has actually
reached that time or mileage. Coverthecarwitha‘‘breathable’’
cover, one made f rom a porous
material such as cotton.
Nonporous materials, such as
plastic sheeting, trap moisture,
which can damage the paint.
Leave the parking brake off. Put
the transmission in Reverse
(manual) or Park (automatic). 209
198
Maint enance
St oring Your Car
252

Î
ÎThe United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page .
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
In Canada, Acura vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them from
the crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
196
The Clean Air Act
Evaporative Emissions Control
System Crankcase Emissions Control
System
T echnical Inf ormation
Emissions Cont rols
296

CONT INUED
........................................
Introduction .i
........................
Jacking up the Car .265
.......................................
Jack, Tire .264
................................
Jump Starting .270
..................................................
Keys .75
.......................
Label, Certif ication .288
.................
Lane Change, Signaling . 70
..................
Lap/Shoulder Belts . 16,44
.........................
Leather, Cleaning .257
Lights ....................
Bulb Replacement .244
.......................................
Indicator .59
.........................................
Parking .69
..................................
Turn Signal .70
.....................................
Load Limit .165
......
LOCK (Ignition Key Position) . 78Locks
.......
Anti-thef t Steering Column . 78
............................
Fuel Fill Door .156
....................................
Glove Box .84
............................................
Hatch .80
..............
Power Door and Hatch . 80
........................
Low Coolant Level .160
...
Lower Gear, Downshif ting to a . 170
.........................
Low Fuel Indicator .60
...
Low Oil Pressure Indicator . 61,274
Lubricant Specif ications ..................................
Chart .290, 291
.........................................
Luggage .164
..................................
Maintenance .193
...
Owner Maintenance Checks . 205
........................................
Record .203
......................
Required Indicator .64
.............................
Schedule .198-202
.
Malf unction Indicator Lamp . 61,276
...................
Manual Transmission . 170
........
Manual Transmission Fluid . 219
...............................
Meters, Gauges .66
...................
Methanol in Gasoline . 294..........................
Mirrors, Adjusting .94
.........................................
Moonroof .93
......................
Closing Manually .279
.....................................
Operation .93
...................
Neutral Gear Position . 174
..................
New Vehicle Break-in . 155
.....................
Normal Shif t Speeds .171
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 288
...
Octane Requirement, Gasoline . 155
.........................................
Odometer .66
...............................
Odometer, Trip .66
Index
J
K
L
MN
O
V

Oil........................
Change, How to .209
......................
Change, When to .198
......................
Checking Engine .159
..............
Pressure Indicator . 61,274
Selecting Proper Viscosity ......................................
Chart .208
...........
ON (Ignition Key Position) . 78
Onboard Ref ueling Vapor ....................................
Recovery .297
..
Operation in Foreign Countries . 287
..............................
Outside Mirrors .94
....................
Overheating, Engine .272
.........................
Oxygenated Fuels .294
.......
Owner Maintenance Checks . 205
..............................
Paint Touch-up .255
..............
Panel Brightness Control . 70
........................
Park Gear Position .174
...........................................
Parking .180
.................................
Parking Brake .95
........................
Parking Lights .69, 247
..
Parking Over Things that Burn . 180
.............................
PGM-FI System .297 ..................
Polishing and Waxing . 255
............
Pre-Drive Saf ety Checklist . 12
.........
Pregnancy, Using Seat Belts . 19
............................
Protecting Adults .13
...
Additional Safety Precautions . 19
.....
Advice f or Pregnant Women . 19
........................
Protecting Children .21
.......................
Protecting Inf ants .30
.......
Protecting Larger Children . 37
.........
Protecting Small Children . 34
Using Child Seats with .....................................
Tethers .41
.............................
Using LATCH .42
...................
Radiator Overheating . 272
.............
Radio/CD Sound System . 125
...........................
Readiness Codes .299
..
Rear Lights, Bulb Replacement . 249
............................
Rear Seat Access .86
..........................
Rear Seat, Folding .87
............................
Rear View Mirror .94
.................
Rear Window Def ogger . 73
....................
Rear Window Washer .72
.......................
Rear Window Wiper .72 ...............
Reclining the Seat Backs . 85
.......
Recommended Shif t Speeds . 171
.............................
Reminder Lights .59
Replacement Inf ormation .................
Air Cleaner Element . 222
.......................................
Coolant .214
................
Engine Oil and Filter . 209
..........................................
Fuses .280
................................
Light Bulbs .244
....................................
Schedule .198
................................
Spark Plugs .224
...........................................
Tires .235
.............................
Wiper Blades .229
Replacing Seat Belts Af ter a ............................................
Crash .46
...
Reserve Tank, Engine Coolant . 212
...............................
Restraint, Child .21
..................
Reverse Gear Position . 174
................................
Rotation, Tire .238
..................................
Saf ety Belts .8, 48
.................................
Saf ety Features .7
.........................................
Airbags .10
..................................
Door Locks .11
Index
P R
S
VI