ignition Acura RSX 2004 Service Manual

CONT INUED
If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pagesand or the diagram on the
fuse box lid, which fuses control that
device. Check those f uses f irst, but
check all the f uses bef ore deciding
that a blown f use is the cause.
Replace any blown f uses, and check
if the device works.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box. Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Removing these f uses
requires a Phillips-head screw-
driver.Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse box by
pulling out each f use with the f use
puller provided in the interior f use
box.
3.
1.
2. 4.
213 214
Fuses
T aking Care of t he Unexpect ed
Checking and Replacing Fuses
211
FUSE
BLOWN

Î
ÎÎ
ÎÎ
Î
CONT INUED
No. Circuits Protected No.
Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12 Ignition Coil
Laf Heater
Daytime Running Lights
ACG (IG)
Not Used
Power Window Relay
Moonroof
Radio
Rear Wiper
Gauge panel
ABS
Daytime Running Lights 13
14
15
16
17
18
19
20
21
22
23
24
25
SRS
Power Mirror
Bass Speaker
Heated Seats
Fuel Pump
Accessory Power Socket
Turn Signal
Front Wiper
Not Used
Front Passenger’s Power Window
Driver’s Power Window
Not Used
Not Used
Canadian models only
Type-S only
1:
2:
1
1 2
1
Fuse Locations
T aking Care of t he Unexpect ed213
INTERIOR FUSE BOX

µ
No.Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21 25 Condenser f an
Small Light
Interior Light
Cooling Fan
Hazard
FI ECU
Horn, Stop
ABS (F/S)
Back Up
ABS Motor
Rear Demister
Heater Motor
Power Window
Option
Lef t Headlight
Door Lock
Right Headlight
Not Used
Main Fuse Battery
Main Fuse Ignition
Spare Fuse
Fuse Locations
T aking Care of t he Unexpect ed214
UNDER HOOD FUSE BOX

If you decide to tow your vehicle
with all f our wheels on the ground,
make sure you use a properly-
designed and attached tow bar.
Prepare the vehicle for towing as
described above, and leave the
ignition switch in the Accessory (I)
position so the steering wheel does
not lock. Make sure the radio and
any electrical accessories are turned
of f so they do not run down the
battery.
Emergency T owing
T aking Care of t he Unexpect ed216
NOTICE:
NOTICE: Trying to lif t or tow your
vehicle by the bumpers will cause
serious damage. The bumpers are not
designed to support the vehicle’s weight.
T he steering system can be
damaged if the steering wheel is locked.
Leave the ignition switch in the
Accessory (I) position, and make sure
the steering wheel turns f reely bef ore
you begin towing.

This section gives you the
dimensions and capacities of your
Acura, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 218
................................
Specif ications .220
DOT Tire Quality Grading ......................
(U.S. Vehicles) .222
Unif orm Tire Quality ..................................
Grading .222
.................................
Treadwear .222
......................................
Traction .222
.............................
Temperature .223
.................................
Tire Labeling .224 .......................
Emissions Controls .225
.....................
The Clean Air Act .225
Crankcase Emissions Control ....................................
System .225
Evaporative Emissions Control ....................................
System .225
Onboard Ref ueling Vapor ................................
Recovery .226
...
Exhaust Emissions Controls . 226
....................
PGM-FI System .226
Ignition Timing Control ................................
System .226
Three Way Catalytic ...........................
Converter .226
....................
Replacement Parts . 226
..
Three Way Catalytic Converter . 227
..............
State Emissions Testing . 228
T echnical Inf ormat ion
T echnical Inf ormation217

The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The exhaust emissions controls
include three systems: PGM-FI,
Ignition Timing Control, and Three
Way Catalytic Converter. These
three systems work together to
control the engine’s combustion and
minimize the amount of HC, CO, and
NOx that comes out the tailpipe. The
exhaust emissions control systems
are separate from the crankcase and
evaporative emissions control
systems.The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
or the Powertrain Control Module
(PCM) uses various sensors to
determine how much air is going
into the engine. It then controls how
much f uel to inject under all operat-
ing conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Genuine Acura replacement parts or
their equivalent f or repairs. Using
lower quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more inf orma-
tion.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Emissions Cont rols
T echnical Inf ormation
Onboard Ref ueling Vapor
Recovery
Exhaust Emissions Controls Replacement PartsPGM-FI Syst em
Ignit ion T iming Cont rol Syst emThree Way Catalytic Converter
226

CONT INUED
....................................
Accessories .127
ACCESSORY (Ignition Key .......................................
Position) .66
..............
Accessory Power Sockets . 85
....................
Additives, Engine Oil . 165
.............................
Airbag (SRS) .10, 22
...
Airbags, Additional Information . 22
...
Additional Safety Precautions . 28
.............................
Airbag Service .28
How the Side Airbag Cutof f ......................
Indicator Works .27
..
How the SRS Indicator Works . 26
How Your Front Airbags .........................................
Work .22
...
How Your Side Airbags Work . 25
........................
SRS Components .22
................
Air Conditioning System . 88
.......................
Air Pressure, Tires .184
......................................
Antif reeze .168
Anti-lock Brakes (ABS) ...............................
Indicator .51, 147
...................................
Operation .147
Anti-thef t Steering Column ..............................................
Lock .65 ..................................
Audio System .92
...
Automatic Seat Belt Tensioners . 20
.............
Automatic Speed Control . 115
..............
Automatic Transmission . 139
..........................
Capacity,Fluid .220
...............
Checking Fluid Level . 169
.......................................
Shif ting .139
.
Shif t Lever Position Indicator . 139
................
Shif t Lever Positions . 139
....................
Shif t Lock Release . 144
Battery Charging System ...........................
Indicator .51, 205
............................
Jump Starting .200
..............................
Maintenance .188
............................
Specif ications .221
..............................
Bef ore Driving .119
....................................
Belts,Seat .8,19
...........................
Beverage Holders .85
..................................
Booster Seats .42
Brakes ...........
Anti-lock System (ABS) . 147
.............
Break-in, New Linings . 121....................
Bulb Replacement .174
...........................................
Fluid .171
.................
System Indicator . 51,208
........................
Wear Indicators .146
.............................
Braking System .146
.................
Break-in, New Vehicle . 121
..
Brightness Control, Instruments . 61
........................
Brights, Headlights .60
Bulb Replacement ..........................
Back-up Lights .178
..............................
Brake Lights .178
................
Front Parking Lights . 177
.........
Front Turn Signal Lights . 176
.................................
Headlights .174
.........
High-mount Brake Light . 178
.........
Rear Side Marker Lights . 178
............................
Specif ications .221
..............................
Bulbs, Halogen .174
Index
A
B
I

............................
Front Airbags .10, 22
Front Seat ......................................
Adjusting .72
.........................................
Heaters .75
...................................
Airbags .10, 22
.................................................
Fuel .121
......................
Fill Door and Cap .122
...........................................
Gauge .57
................
Octane Requirement . 121
........................
Reserve Indicator .52
........................
Tank, Filling the .122
.....................
Fuses, Checking the .211
...............
Gas Mileage, Improving . 126
.........................................
Gasoline .121
...............
Fuel Reserve Indicator . 52
...........................................
Gauge .57
................
Octane Requirement . 121
........................
Tank, Filling the .122
................
Gas Station Procedures . 122
Gauges ...
Engine Coolant Temperature . 57
...............................................
Fuel .57 Gearshif t Lever Positions
..........
Automatic Transmission . 139
5-speed and 6-speed Manual
.......................
Transmissions .136
........................................
Glove Box .71
.............
Halogen Headlight Bulbs . 174
................................................
Hatch .68
.................................
Opening the .68
............................
Open Indicator .52
..............
Hazard Warning Flashers . 61
Headlights ........................................
Aiming .174
............
Daytime Running Lights . 60
..................
High Beam Indicator . 52
........................
Reminder Beeper .60
........
Replacing Halogen Bulbs . 174
...................................
Turning on .60
.....................................
Heater, Seat .75
.......................
Heating and Cooling .88
.............
High Altitude, Starting at . 135
.................
High-Low Beam Switch . 60
..............
High-mount Brake Light . 178
....................................
Hood Latch .173 .......................
Hood, Opening the .123
..................................................
Horn .58
...........................
Hydraulic Clutch .172
...
Identif ication Number, Vehicle . 218
Ignition ..............................................
Keys .63
...........................................
Switch .65
............
Timing Control System . 226
........................
Immobilizer System .64
.........
Important Safety Precautions . 6
Indicators ...............
ABS (Anti-lock Brake) . 51
Brake (Parking and Brake ....................................
System) .51
................
Charging System . 51,205
.............................
Cruise Control .52
....................................
Door-open .52
DRL (Daytime Running ......................................
Lights) .53
...................................
High Beam .52
........
Key (Immobilizer System) . 53
......................................
Low Fuel .52
................
Low Oil Pressure . 51,204
Index
G H
I
IV

CONT INUED
...........................
Side Airbag Of f .50
...............................................
SRS .50
Turn Signal and Hazard ...................................
Warning .52
..............................
Washer Level .53
.........
Indicators, Instrument Panel . 49
...............................
Inf ant Restraint .33
Inf ant Seats .........................................
LATCH .37
...........................
Lower Anchors .37
..........
Tether Anchorage Points . 40
...................
Inf lation, Proper Tire . 183
...................................
Inside Mirror .80
.............................
Inspection, Tire .185
........................
Instrument Panel .2 ,49
........
Instrument Panel Brightness . 61
..........
Instrument Panel Indicators . 50
.................................
Interior Lights .83
........................................
Introduction . i
.................
Jacking up the Vehicle . 195
.......................................
Jack, Tire .194
................................
Jump Starting .200 ..................................................
Keys .63
.......................
Label, Certif ication .218
.................
Lane Change, Signaling . 60
..................
Lap/Shoulder Belts . 14,19
...........
LATCH Anchorage System . 37
Lights ....................
Bulb Replacement .174
.....................................
Load Limit .130
......
LOCK (Ignition Key Position) . 65
Locks .......
Anti-thef t Steering Column . 65
............................
Fuel Fill Door .122
....................................
Glove Box .71
............................................
Hatch .68
..............
Power Door and Hatch . 67
........................
Low Coolant Level .125
.........................
Low Fuel Indicator .52
...
Low Oil Pressure Indicator . 51,204
.................................
Lower Anchor .37
...
Lower Gear, Downshif ting to a . 136Lubricant Specif ications
..................................
Chart .220, 221
..............
Luggage, .129
.....
Luggage Cover (Cargo Cover) . 76
..................................
Maintenance .155
...
Owner Maintenance Checks . 158
........................................
Record .161
......................
Required Indicator .54
..........................................
Saf ety .156
.............................
Schedule .159-160
.
Malf unction Indicator Lamp . 51,206
...................
Manual Transmission . 136
...............
Checking Fluid Level . 170
................................
Shif ting the .136
........
Manual Transmission Fluid . 170
...............................
Meters, Gauges .56
..........................
Mirrors, Adjusting .81
...............
Modif ying Your Vehicle . 128
.........................................
Moonroof .80
......................
Closing Manually .209
.....................................
Operation .80
Storing (Cargo)
Index
J K
L
M
V

...................
Neutral Gear Position . 140
..................
New Vehicle Break-in . 121
.....................
Normal Shif t Speeds .137
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 218 ...................
Radiator Overheating . 202
...............
Radio/CD Sound System . 92
...........................
Readiness Codes .228
..
Rear Lights, Bulb Replacement . 178
............................
Rear Seat Access .73
..........................
Rear Seat, Folding .74
............................
Rear View Mirror .80
.................
Rear Window Def ogger . 61
....................
Rear Window Washer .59
.......................
Rear Window Wiper .59
...............
Reclining the Seat Backs . 72
.......
Recommended Shif t Speeds . 137
.......................
Reminder Indicators .49
.......................
Remote Transmitter .69
Replacement Inf ormation ..............
Dust and Pollen Filter . 180
................
Engine Oil and Filter . 165
.................................
Floor Mats .180
..........................................
Fuses .211
................................
Light Bulbs .174
....................................
Schedule .159
...................................
Seat Belts .180
...........................................
Tires .183
.............................
Wiper Blades .181
..............
Panel Brightness Control . 61
........................
Park Gear Position .140
...........................................
Parking .145
.................................
Parking Brake .82
Parking Brake and Brake .................
System Indicator . 51,208
........................
Parking Lights .60, 177
..
Parking Over Things that Burn . 145
............................
Playing the Radio .92
..................................
Playing a CD .101
..................
Playing a CD Changer . 101
.................................
Playing a Tape .98
.............................
PGM-FI System .226
..........................
Power Door Locks .67
.................
Power Socket Locations . 85
..............................
Power Windows .78
.........
Pregnancy, Using Seat Belts . 17
.........
Protecting Adults and Teens . 11
...
Additional Safety Precautions . 17
.....
Advice f or Pregnant Women . 17
........................
Protecting Children .29
.....................
General Guidelines .29
...........................
Protecting Inf ants .33
.............
Protecting Small Children . 34
...
Octane Requirement, Gasoline . 121
.........................................
Odometer .56
...............................
Odometer, Trip .56
Oil ........................
Change, How to .165
......................
Change, When to .159
......................
Checking Engine .125
..............
Pressure Indicator . 51,204
Selecting Proper Viscosity ..............................
Chart .164, 165
...........
ON (Ignition Key Position) . 66
Onboard Ref ueling Vapor ....................................
Recovery .226
..............................
Outside Mirrors .81
....................
Overheating, Engine .202
.......
Owner Maintenance Checks . 158
Index
N
O PR
VI