brake Acura TL 2004 Service Manual

If you have a f lat tire while driving,
stop in a saf e place to change it.
Drive slowly along the shoulder until
you get to an exit or an area to stop
that is far away from the traffic lanes.Park the vehicle on f irm, level, and
non-slippery ground. Put the
transmission in Park (automatic)
or Reverse (manual). Apply the
parking brake.
Turn on the hazard warning lights,
and turn the ignition switch to
LOCK (0). Have all the
passengers get out of the vehicle
while you change the tire.Open the trunk. Raise the trunk
f loor by lif ting up on the back edge.
Take the tool case out of the spare
tire.
Unscrew the wing bolt and take
the spare tire out of its well.
5. 4.
3.
2. 1.
CONT INUED
Changing a Flat T ire
T aking Care of t he Unexpect ed231
TOOL CASE
JACK
TRUNK FLOOR
SPARE TIRE
The vehicle can easily roll off
the jack, seriously injuring
anyone underneath.
Follow the directions for
changing a tire exactly, and
never get under the vehicle
when it is supported only by the
jack.

Remove the wheel nuts, then
remove the f lat tire. Temporarily
place the f lat tire on the ground
with the outside surface of the
wheel f acing up. You could scratch
the wheel if you put it f ace down.Bef ore mounting the spare tire,
wipeanydirtoff themounting
surface of the wheel and hub with
a clean cloth. Wipe the hub
carefully;itmaybehotfrom
driving.Put on the spare tire. Put the
wheel nuts back on f inger-tight,
then tighten them in a crisscross
pattern with the wheel wrench
until the wheel is f irmly against
the hub. Do not try to tighten
them f ully.
9.
10. 11.
CONT INUED
Changing a Flat T ire
T aking Care of t he Unexpect ed233
BRAKE HUB

´´ µ
Although this seems like a simple
procedure, you should take several
precautions.
Turn of f all the electrical acces-
sories: heater, A/C, stereo system,
lights, etc. Put the transmission in
Neutral or Park, and set the
parking brake.
Connect one jumper cable to the
positive ( ) terminal on your
battery. Connect the other end to
the positive ( ) terminal on the
booster battery.Connect the second jumper cable
to the negative ( ) terminal on
the booster battery. Connect the
other end to the grounding strap
as shown. Do not connect this
jumper cable to any other part of
the engine.
You cannot start an Acura with an
automatic transmission by pushing
or pulling it. Open the hood, and check the
physical condition of the battery.
In very cold weather, check the
condition of the electrolyte. If it
seems slushy or like ice, do not try
jump starting until it thaws.
1.
2.
3. 4.
Jump Starting
T aking Care of t he Unexpect ed
To Jump Start Your Vehicle:
238
NOTICE:
A battery can explode if you do
not follow the correct procedure,
seriously injuring anyone
nearby.
Keep all sparks, open flames,
and smoking materials away
from the battery. If a battery sits in extreme
cold, the electrolyte inside can f reeze.
Attempting to jump start with a f rozen
battery can cause it to rupture.

If you do not see steam or spray,
leave the engine running, and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge comes down to the midpoint,
then continue driving.
Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park, and set the parking brake.
Turn of f all accessories, and turn
on the hazard warning indicators.
If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood.
The pointer of the vehicle’s
temperature gauge should stay in
the midrange. If it climbs to the red
mark, you should determine the
reason (hot day, driving up a steep
hill, etc.).
If the vehicle overheats, you should
take immediate action. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
If the temperature gauge stays at
the red mark, turn of f the engine.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ).
1.
2. 3.
4.
5.
249
If theEngineOverheats
T aking Care of t he Unexpect ed
Emergency
Towing
240
NOTICE: Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature
gauge pointer at the red mark can
cause serious damage to your engine.

Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the long
distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed and repaired as
soon as possible (seeon page ).
If the brake system indicator comes
on while driving, the brake f luid level
is probably low. Press lightly on the
brake pedal to see if it f eels normal.
If it does, check the brake f luid level
thenexttimeyoustopataservice
station (see page ). The brake system indicator
normally comes on when
you turns the ignition
switch to ON (II) and as a
reminder to check the
parking brake. It will stay
on if you do not f ully
release the parking brake.
However, if the brake pedal does not
f eel normal, you should take
immediate action. A problem in one
part of the system’s dual circuit
design will still give you braking at
two wheels. You will f eel the brake
pedal go down much f arther bef ore
the vehicle begins to slow down, and
you will have to press harder on the
pedal.
If you must drive the vehicle a short
distance in this condition, drive
slowly and caref ully. If the ABS indicator and the VSA
system indicator come on with the
brake system indicator, have your
vehicle inspected by an Acura dealer
immediately.
If the f luid level is low, take your
vehicle to a dealer and have the
brake system inspected f or leaks or
worn brake pads. 211
249
Brake System Indicator
Emergency
Towing
T aking Care of t he Unexpect ed244
Canada U.S.

µ
µ µ
There are three popular types of
prof essional towing equipment.
Shif t the transmission to Neutral.
ShifttoD,thentoN.
Turn of f the engine.
The tow
truck uses metal cables with hooks
on the ends. These hooks go around
parts of the f rame or suspension and
the cables lif t that end of the vehicle
of f the ground. Your vehicle’s sus-
pension and body can be seriously
damaged.
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
behind another vehicle with just a
rope or chain. It is very dangerous.
The operator
loads your vehicle on the back of a
truck.
The tow
truck uses two pivoting arms that go
under the tires (f ront or rear) and lif t
them of f the ground. The other two
tires remain on the ground. If your Acura cannot be transported
by f lat-bed, it should be towed by
wheel-lif t equipment with the f ront
wheels of f the ground. If , due to
damage, your vehicle must be towed
with the f ront wheels on the ground,
do the f ollowing: Release the parking brake.
Start the engine. Release the parking brake.
Automatic Transmission:
6-speed Manual Transmission:
Sling-t ype Equipment
Flat -bed Equipment Wheel-lif t Equipment
T his method of towing
is unacceptable.
T his is the best way to
transport your A cura.
T his is
an acceptable way to tow your
Acura.
Emergency T owing
T aking Care of t he Unexpect ed249
NOTICE: Improper towing preparation
will damage the transmission. Follow
the above procedure exactly. If you
cannot shif t the transmission or start
the engine (automatic transmission),
your vehicle must be transported with
the f ront wheels of f the ground.

Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 6th (M/T). Do not use
thecruisecontrol.Whentraffic
allows, drive f or 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Acura dealer.
St at e Emissions T est ing
T echnical Inf ormation264

CONT INUED
BatteryCharging System ...........................
Indicator .52, 242
............................
Jump Starting .238
..............................
Maintenance .226
............................
Specif ications .257
..............................
Bef ore Driving .163
....................................
Belts,Seat .8,19
...........................
Beverage Holder .106
Brakes ...........
Anti-lock System (ABS) . 189
.............
Break-in, New Linings . 164
...........................................
Fluid .211
.......................................
Parking .103
.................
System Indicator . 52,244 ........................
Wear Indicators .188
.............................
Braking System .188
........................
Break-in, New Car .164
..
Brightness Control, Instruments . 75
........................
Brights, Headlights .74
Bulb Replacement ..........................
Back-up Lights .216
.................................
Fog Lights .213
............................
Specif ications .257
............
Turn Signal Lights . 214,215
..............................
Bulbs, Halogen .213
............................
Capacities Chart .256
.............
Carbon Monoxide Hazard . 46
............................
Carrying, Cargo .171
Cassette Player ............................................
Care .138
...................................
Operation .136
..............
CAUTION, Explanation of . ii
..................................
Ceiling Light .104
........................
Certif ication Label .254
...................................
Chains, .225
...
Accessories and Modif ications . 168
................................
Accessories .169
............................
Modif ications .170
ACCESSORY (Ignition Key .......................................
Position) .80
............
Accessory Power Sockets . 106
................
Adding Engine Coolant . 207
........................
Adding Engine Oil .204
....................
Additives, Engine Oil . 205
...............................
Airbag (SRS) .9, 22
...............
Additional Information . 22
......................................
Servicing .28
...................
System Components . 22
..............
Air Conditioning System . 110
.......................
Air Pressure, Tires .221
......................................
Antif reeze .207
Anti-lock Brakes (ABS) ...............................
Indicator .53, 189
...................................
Operation .189
..............
Anti-thef t, Audio System . 140
.
Anti-thef t Steering Column Lock . 80
................................
Audio System .117
...
Automatic Lighting Off Feature . 76
...
Automatic Seat Belt Tensioners . 20.............
Automatic Speed Control . 142
..............
Automatic Transmission . 181
..........................
Capacity, Fluid .256
...............
Checking Fluid Level . 209
.......................................
Shif ting .181
.
Shif t Lever Position Indicator . 181
.......................................
Shif ting .181
....................
Shif t Lock Release . 185
tires
Index
A
BC
I

ÎÎÎ
ÎÎ
Changing Oil ........................................
How to .205
......................................
When to .195
....................
Changing a Flat Tire .231
...
Charging System Indicator . 52,242
............
Checklist, Bef ore Driving . 176
..................
Childproof Door Locks . 84
.....................................
Child Saf ety .29
..............................
Booster Seats .43
...................................
Child Seats .36
..........................................
Inf ants .34
............................
Large Children .42
.........................................
LATCH .38
......................
Risks with Airbags .30
.............................
Small Children .35
.........................................
Tethers .41
.........
Where Should a Child Sit? . 30
Cleaning .................................
Floor Mats .218
...................................
Seat Belts .218
...............
Climate Control System . 115
..............................................
Clock .103
..........................
CO in the Exhaust .46
.......................
Compact Spare .230
.................
Console Compartment . 107
...............
Consumer Inf ormation . 265.............
Controls, Instruments and . 49
Coolant ........................................
Adding .207
....................................
Checking .167
.........................
Proper Solution .207
...................
Temperature Gauge . 57
Crankcase Emissions Control ........................................
System .260
................
Cruise Control Indicator . 54
............
Cruise Control Operation . 142
...................................
Cup Holders .106
..........
Customer Relations Of f ice . 266
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 50
............
Daytime Running Lights . 74
Daytime Running Light ...................................
Indicator .55
............
Def ects, Reporting Saf ety . 268
................
Def ogger, Rear Window . 77
..............
Def rosting the Windows . 114
....................................
Dimensions .256
...............
Dimming the Headlights . 74Dipstick
..........
Automatic Transmission . 209
..................................
Engine Oil .167
..........................
Directional Signals .74
........
Disc Brake Wear Indicators . 188
.................................
Disc Changer .129
...
Disc Changer Error Messages . 135
.....................
Disposal of Used Oil .206
Doors ..............................
Monitor Light .60
......................
Power Door Locks .82
..........
DOT Tire Quality Grading . 258
...........
Driver and Passenger Safety . 5
...........................................
Driving .175
....................................
Economy .168
Driving Position Memory ..........................................
System .93
..............................
Economy, Fuel .168
............
Emergencies on the Road . 229
.............
Battery, Jump Starting . 238
...........
Brake System Indicator . 244
................
Changing a Flat Tire . 231
.....
Charging System Indicator . 242
tire
Index
D
E
II

ÎCONT INUED
...............
Gas Mileage, Improving . 168
.........................................
Gasoline .164
...............
Fuel Reserve Indicator . 56
...........................................
Gauge .57
................
Octane Requirement . 164
........................
Tank, Filling the .165
................
Gas Station Procedures . 165
...................................
Fan, Interior .122
Features, Comfort and ..............................
Convenience .109
....................
Filling the Fuel Tank . 165
........................................
Filter, Oil .205
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 231
.....................................
Floor Mats .218
Fluids ..........
Automatic Transmission . 209
..........................................
Brake .211
.........................................
Clutch .211
..............
Manual Transmission . 210
..........................
Power Steering .212
................
Windshield Washers . 208
FM Stereo Radio ...................................
Reception .122
.....................................
Fog Lights .75 ..........................
Four-way Flashers .76
..............................
Front Airbags .9 ,22
......................................
Front Seats .90
......................................
Adjusting .90
.........................................
Heaters .96
.....................................
Airbags .9, 22
.................................................
Fuel .164
......................
Fill Door and Cap .165
...........................................
Gauge .57
................
Octane Requirement . 164
........................
Reserve Indicator .56
........................
Tank, Filling the .165
.....................
Fuses, Checking the .245
..................
Checking the Fuses . 245
.........
Hazard Warning Flashers . 76
......
If Your Vehicle Gets Stuck . 249
............................
Jump Starting .238
.....
Low Oil Pressure Indicator . 242
...
Malf unction Indicator Lamp . 243
..................
Overheated Engine . 240
.......................................
Towing .249
.........................
Emergency Brake .103
......................
Emergency Flashers .76
......................
Emergency Towing .249
............
Emergency Trunk Opener . 84
.......................
Emissions Controls .260
.............
Emissions Testing, State . 263
Engine ....
Coolant Temperature Gauge . 57
Malf unction Indicator ................................
Lamp .52, 243
.........................................
Oil Lif e .64
........
Oil Pressure Indicator . 52,242
..............
Oil, What Kind to Use . 204
...............................
Overheating .240
............................
Specif ications .257
....................
Speed Limiter . 179,185
.......................................
Starting .177
...................
Engine, .236 ......................
Ethanol in Gasoline .164
.
Evaporative Emissions Controls . 260
...............................
Exhaust Fumes .46
Expectant Mothers, Use of Seat ........................................
Belts by .17
if it won’t start
Index
F
G
III