transmission Acura TSX 2008 Service Manual

Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.
If the battery in your vehicle has
been disconnected or gone dead,
thesecodesmaybeerased.Ittakes
several days of driving under various
conditions to set the codes again.
If your vehicle has an automatic
transmission, the malf unction
indicator lamp may also come on
with the ‘‘D’’ indicator.
You will also see a ‘‘CHECK
EMISSION SYSTEM’’ message on
the multi-information display (see
page ). To check if they are set, turn the
ignition switch to the ON (II)
position, without starting the engine.
The malf unction indicator lamp will
come on f or 20 seconds. If it then
goes of f , the readiness codes are set.
If it blinks f ive times, the readiness
codes are not set. If possible, do not
take your vehicle for a state
emissions test until the readiness
codes are set. Ref er to
f or more inf ormation (see
page ).
84 362
Readiness Codes
Emissions
Testing
Malf unction Indicator L amp
T aking Care of t he Unexpect ed
337
If you keep driving with the
malf unction indicator lamp on, you can
damage your vehicle’s emissions
controls and engine. Those repairs may
not be covered by your vehicle’s
warranties.
\f—\f—
y
\fy
(\fy\fy
2008 TSX

µµ
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
The operator
loads your vehicle on the back of a
truck.
Therearetwowaystotowyour
vehicle: If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do this:
Release the parking brake.
Shif t the transmission to neutral.
With the f ront wheels on the ground,
it is best to tow the vehicle no farther
than 50 miles (80 km), and keep the
speedbelow35mph(55km/h).
The tow
truck uses two pivoting arms that go
under the tires (f ront) and lif t them
of f the ground. The other two tires
remain on the ground. Turn of f the engine.
ShifttoD,thentoN.
Start the engine.
Release the parking brake.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
Manual transmission:
Automatic transmission:
CONT INUED
Flat -bed EquipmentWheel-lif t Equipment
T his is the best way to
transport your vehicle.
T his is an
acceptable way to tow your
vehicle.
Emergency Towing
T aking Care of t he Unexpect ed
345
Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (automatic transmission), your
vehicle must be transported with the
f ront wheels of f the ground.
\f—\f—
y

y
(\fy\f\fy
2008 TSX

The transmission number is on a
label on top of the transmission.
The engine number is stamped into
the f ront of the engine block.
Identif ication Numbers
Technical Inf ormation
349
AUTOMATIC TRANSMISSION NUMBER
MANUAL TRANSMISSION NUMBER
ENGINE NUMBER
\f—\f—
y
y
(\fy\fy
2008 TSX

µµÎ
Î
Î
Î
Specif ications
350
Dimensions
Weights
Capacities
Air Conditioning
Seating Capacities Capacities
1.40 US gal (5.3
)
1.37 US gal (5.2)
105.1 in (2,670 mm)
59.6 in (1,515 mm)
59.6 in (1,515 mm)
183.3 in (4,657 mm)
69.4 in (1,762 mm)
57.3 in (1,456 mm)
1.90 US gal (7.2
)
1.88 US gal (7.1)
4.4 US qt (4.2
)
4.2 US qt (4.0
)
5.6 US qt (5.3
)
2.1 US qt (2.0)
2.3 US qt (2.2)
3.1 US qt (2.9)
6.9 US qt (6.5)
4.8 US qt (4.5
)
2.6 US qt (2.5)
0.16 US gal (0.6
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity:
Excluding the oil remaining in the engine
Length
Width
Height
Wheelbase
Track
See the certification label attached
to the driver’s doorjamb.
Gross vehicle weight rating
Fuel tank
17.1 US gal (64.7)
Refrigerant type
Charge quantity
Lubricant type
SP-10
17.6 19.4 oz (500 550 g) HFC-134a (R-134a) 5
2
3
Total
Front
Rear Engine
coolant
Engine oil
Manual trans-
mission fluid
Automatic
transmission
fluid
Windshield
washer
reservoir
Approx.
Front
Rear
1:
2:Change
Manual
Automatic
Total Manual
Automatic
Change Including
filter
Without
filter
Total
Change
Total
Change
Total
U.S. Models
Canada Models
1
2
\f—\f—
y
y
(\fy\fy
2008 TSX

The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The emissions control systems are
designed and certif ied to work
together in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Acura replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The exhaust emissions controls
include three systems: PGM-FI,
ignition timing control, and three
way catalytic converter. These three
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It
then controls how much f uel to inject
under all operating conditions.
2
2
Exhaust Emissions Controls Replacement Parts
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
PGM-FI System
Emissions Cont rols
360
\f—\f—
y
y
(\fy\fy
2008 TSX

CONT INUED
....................................
Accessories .240
ACCESSORY (Ignition Key
.....................................
Position) .128
............
Accessory Power Sockets .156
....................
Additives, Engine Oil .291
.....................
Adjusting the Sound .175
Adjust Outside Temperature ...................................
Display .73,96
........
Advice For Pregnant Women .17
.....................................
Airbag (SRS) .9
.....
Airbag, Additional Information .23
...
Additional Safety Precautions .35
.............................
Airbag Service .34
Check Airbag System ...................................
Message .83
How the Passenger Airbag Of f ......................
Indicator Works .33
How the Side Airbag Of f ......................
Indicator Works .32
..
How the SRS Indicator Works .32
How Your Front Airbags
.........................................
Work .26
...
How Your Side Airbags Work .30 How Your Side Curtain
..........................
Airbags Work .31
........................
SRS Components .23
............................
Air Conditioning .160
.........................................
Usage .162
.......................
Air Pressure, Tires .315
......................................
Alignment .317
.......................
Alcohol in Gasoline .232
Anti-lock Brakes (ABS) ...............................
Indicator .65,261
.......................................
Message .83
...................................
Operation .261
..............
Anti-thef t, Audio System .203
Anti-thef t Steering Column
............................................
Lock .128
................................
Audio System .170
................
Automatic Lighting Off .122
...
Automatic Seat Belt Tensioners .21
..............
Automatic Transmission .252
..........................
Capacity,Fluid .350
...............
Checking Fluid Level .297
..............
Engine Speed Limiter .251
....
Sequential SportShif t Mode .254
.......................................
Shif ting .252
.
Shif t Lever Position Indicator .252
................
Shif t Lever Positions .252 ....................
Shif t Lock Release .257
......................
Auxiliary Input Jack .184
Battery Charging System ...........................
Indicator .62,336
.......................................
Message .84
............................
Jump Starting .331
..............................
Maintenance .320
............................
Specif ications .351
..............................
Bef ore Driving .231
..........................................
Belts, Seat .8
.........................
Beverage Holders .156
.....
Bluetooth
Hands Free Link.213
..................................
Booster Seats .52
Index
A
B
INDEX
I
\f—\f—
y


y
(\fy\fy
2008 TSX

Brakes...........
Anti-lock System (ABS) .261
.............
Break-in, New Linings .232
....................
Bulb Replacement .306
....
Check ABS System Message .83
.
Check Brake System Message .84
...........................................
Fluid .300
....................
Fluid Low Message .79
.......................................
Parking .151
.................
System Indicator .63,338
.........................
System Message .84
........................
Wear Indicators .260
.........
Braking Fluid Low Message .79
.............................
Braking System .260
.................
Brake-in, New Vehicle .232
Brightness Control,
...............................
Instruments .123
......................
Brights, Headlights .122
Bulb Replacement ..............................
Brake Lights .306
.................................
Fog Lights .308
................
Front Parking Lights .305
.................................
Headlights .302
.........
High-mount Brake Light .308
....................
Rear License Plate .308
............................
Specif ications .351.............
Turn Signal Light .304,306
..............................
Bulbs, Halogen .302
............................
Capacities Chart .350
.............
Carbon Monoxide Hazard .55
.............................
Carrying Cargo .242
.............
CAUTION, Explanation of .iii
.........................................
CD Care .194
...................................
CD Changer .185
.....................
CD Error Messages .193
...............................
Center Pocket .155
........................
Certif ication Label .348
............................................
Chains .319
....................
Changing a Flat Tire .325
Changing Oil ........................................
How to .293
......................................
When to .280
...
Charging System Indicator .62,336
.......................................
Message .84
........
Check ABS System Message .83
....
Check Airbag System Message .83
.....
Check Brake System Message .84
Check Charging System
.......................................
Message .84 .......
Check DRL System Message .85
Check Emission System
.......................................
Message .84
Check Engine Oil Level .......................................
Message .82
Check Tire Pressure ...............................
Message .81,265
Check TPMS System ...............................
Message .80,267
......
Check Transmission Message .83
........
Check VSA System Message .82
............
Checklist, Bef ore Driving .248
.....................................
Child Saf ety .36
..............................
Booster Seats .52
...................................
Child Seats .44
.....
Important Saf ety Reminders .36
..........................................
Inf ants .41
......................
Lap/Shoulder Belt .48
..........................
Larger Children .51
.........................................
LATCH .46
.........................
Risk with Airbag .37
.............................
Small Children .42
.........................................
Tethers .49
.........
Where Should a Child Sit? .37
................
Childproof Door Locks .130
Index
C
II
——
y

y
(yy
2008 TSX

CONT INUED
.......................................
Child Seats .36
......
LATCH Anchorage System .46
...........
Lower Anchorage Points .46
..........
Tether Anchorage Points .49
....................
Client Service Of f ice .366
..............
Climate Control Sensors .169
.........................
Clock, Setting the .204
...................................
Clutch Fluid .301
............
Cold Weather, Starting in .249
......................
Compact Spare Tire .324
.................
Console Compartment .157
.................
Consumer Inf ormation .366
.............
Controls, Instruments and .59
Coolant
........................................
Adding .295
....................................
Checking .236
.........................
Proper Solution .295
...................
Temperature Gauge .68
Crankcase Emissions Control ........................................
System .359
........
Cruise Control Message .85,206
............
Cruise Control Operation .206
....................
Cruise Main Indicator .66
...................................
Cup Holders .156
.......................
Customized Settings .86
....................................
Def ault All .90...............
Door · Window Setup .110
...........................
Lighting Setup .106
.................................
Meter Setup .93
...........................
Position Setup .104
........................
Setting to Def ault .90
...............................
Wiper Setup .117
...............
DANGER, Explanation of .iii
...................................
Dashboard .3,60
..............
Daytime Running Lights .122
........................................
Def ault All .90
............
Defects, Reporting Safety .368
..............
Def ogger, Rear Window .124
....................................
Dimensions .350
.............
Dimming the Headlights .121
Dipstick
.
Automatic Transmission .297,298
..................................
Engine Oil .236
........................
Directional Signals .121
........
Disc Brake Wear Indicators .260
.............
Display, Multi-inf ormation .69
.....................
Disposal of Used Oil .294
Doors ............
Locking and Unlocking .129 ..................
Lockout Prevention .130
...................
And Trunk Open .11,78
......................
Power Door Lock .129
.......................
Door Lock Mode .111
..........
DOT Tire Quality Grading .353
Downshif ting, 6-speed Manual
.............................
Transmission .250
...........
Driver and Passenger Safety .5
.......................................
Driver’s ID .86
...........................................
Driving .247
....................................
Economy .237
Driving Position ........................
Memory System .143
......
DRL, Check System Message .85
..........
Dual Temperature Control .167
..................
DustandPollenFilter .311
..............................
Economy, Fuel .237
....
Elapsed Time Reset Condition .100
Index
INDEX
DD
E
III
——
y
y
(yy
2008 TSX

............
Emergencies on the Road .323
.............
Battery, Jump Starting .331
.....
Brake System Indicator .63,338
................
Changing a Flat Tire .325
Charging System
...........................
Indicator .62,336
..................
Checking the Fuses .340
..........................
Fuse Locations .343
.......
Hazard Warning Flashers .124
Low Oil Pressure
...........................
Indicator .62,335
Malf unction Indicator ..........................
Lamp .62,84,336
...
Manually Closing Moonroof .339
..................
Overheated Engine .333
.......................................
Towing .345
.........................
Emergency Brake .151
....................
Emergency Flashers .124
......................
Emergency Towing .345
..........
Emergency Trunk Opener .136
Emission, Check System
.......................................
Message .84
.......................
Emissions Controls .359
........................
Emissions Testing .362
Engine .......
Check Engine Oil Message .82 ....
Coolant Temperature Gauge .68
.........................
If It Won’t Start .329
...
Malf unction Indicator Lamp .336
...................
Oil Lif e Display .73,280
........
Oil Pressure Indicator .62,335
..............
Oil, What Kind to Use .291
...............................
Overheating .333
............................
Specif ications .351
....................
Speed Limiter .251,257
.......................................
Starting .249
Engine Speed Limiter .............................................
A/T .257
............................................
M/T .251
......................
Ethanol in Gasoline .232
.
Evaporative Emissions Controls .359
...............................
Exhaust Fumes .55
Expectant Mothers, Use of Seat ........................................
Belts by .17
...................................
Fan, Interior .164
.............
Fasten Seat Belt Message .78
.........................................
Features .159
....................
Filling the Fuel Tank .233 Filter
.........................
Dust and Pollen .311
...............................................
Oil .293
...........
Flashers, Hazard Warning .124
...................
Flat Tire, Changing a .325
.....................................
Floor Mats .310
Fluids ..........
Automatic Transmission .297
..........................................
Brake .300
.........................................
Clutch .301
..............
Manual Transmission .299
..........................
Power Steering .301
......
Washer Fluid Low Message .81
..................
Windshield Washer .296
.....................................
Fog Lights .122
.......................................
Indicator .66
.........................
Folding Rear Seat .141
........................
Four-way Flashers .124
..................................
Front Airbags .26
.......................
Front Wiper Action .117
Index
F
IV
——
y
y
(yy
2008 TSX

CONT INUED
.................................................
Fuel .232
...............................
Cap Message .79
....................................
Economy .237
......................
Fill Door and Cap .233
...........................................
Gauge .68
.....................
Low Fuel Indicator .66
..............................
Low Message .81
................
Octane Requirement .232
....................................
Ref ueling .233
........................
Tighten Fuel Cap .79
..............................
Fuse Locations .343
.....................
Fuses, Checking the .340
...............
Gas Mileage, Improving .238
.........................................
Gasoline .232
...........................................
Gauge .68
.....................
Low Fuel Indicator .66
.....................
Low Fuel Message .81
................
Octane Requirement .232
........................
Tank, Filling the .233
................
Gas Station Procedures .233
Gauges
...
Engine Coolant Temperature .68
...............................................
Fuel .68...............................
Speedometer .68
.................................
Tachometer .68
GAWR (Gross Axle Weight .......................................
Rating) .271
Gearshif t Lever Positions ..........
Automatic Transmission .252
..............
Manual Transmission .250
......................................
Glove Box .158
.............
Halogen Headlight Bulbs .302
......
HandsFreeLink
, Bluetooth.213
.......................................
Message .85
............
Hazard Warning Flashers .124
.....................................
Headlights .121
........................................
Aiming .302
............
Automatic Lighting Off .122
.........................
Auto Of f Timer .108
.........
Daytime Running Lights .122
.................................
Fog Lights .122
..................
High Beam Indicator .66
....................
Lights On Indicator .63
..........
Low Beams, Turning on .121
.......................
Reminder Chime .121
........
Replacing Halogen Bulbs .302 .................................
Turning on .121
............................
Head Restraints .139
......................
Saf ety Inf ormation .14
...............................
Heated Mirror .146
...................................
Heated Seat .137
.............
High Altitude, Starting at .249
......................
High Beam Indicator .66
HomeLink
Universal ................................
Transceiver .209
..
Hood, Opening and Closing the .234
...........................................
Horn .4,119
...........................
Hydraulic Clutch .301
...
Identif ication Number, Vehicle .348
Ignition
............................................
Keys .126
.........................................
Switch .128
............
Timing Control System .359
......................
Immobilizer System .127
.........
Important Safety Precautions .6
Index
INDEX
I
G H
V
\f—\f—
y
y
(\fy\f\fy
2008 TSX