clutch Alfa Romeo 4C 2021 Instructieboek (in Dutch)
[x] Cancel search | Manufacturer: ALFA ROMEO, Model Year: 2021, Model line: 4C, Model: Alfa Romeo 4C 2021Pages: 156, PDF Size: 3.06 MB
Page 45 of 156
43
Warning lights on panelMeaningWhat to do
TCT FAULT
The digital warning light switches on when the key is
turned to MAR-ON, but it should switch off after a few
seconds.
The digital warning light flashes (together with a message
in the display and an acoustic signal) to indicate that the
TCT is faulty.
The warning light or symbol switches on in the case of
transmission overheating, after a particularly demanding
use; engine performance is limited in this case.
DOOR OPEN
(where provided)
The digital warning light on the display switches on when
one or more doors are not properly shut. A buzzer will
sound when doors/tailgate are open and the car is moving.
BRAKE PAD WEAR
(where provided)
The digital warning light switches on when the front or
rear brake pads show signs of wear.
The associated message appears on the display.Replace the pad as soon as possible.
ALFA ROMEO CODE SYSTEM FAULT
(where provided)
The digital warning light (or symbol on the display) will
come on (on some versions, with a message on the
display) to indicate an Alfa Romeo CODE system or alarm
fault.Contact a dedicated
Alfa Romeo Dealership as soon as possible.
Contact a dedicated
Alfa Romeo Dealership as soon as possible.
If you need to start the engine in presence of a faulty
gearbox, follow the procedure shown in the
“TCT twin clutch transmission”, paragraph in the “Starting
the engine” section, “Starting and driving” chapter.
Page 48 of 156
KNOWING THE INSTRUMENT PANEL TOOLS
46
Warning lights on panelMeaningWhat to do
GENERIC FAILURE INDICATION
(where provided)
The symbol appears on the display together with the
events shown below.
Engine oil pressure sensor
The symbol appears when a failure is detected in the
engine oil pressure sensor. The display shows the
dedicated message.In this case, go to a dedicated
Alfa Romeo Dealership as soon as possible to have the
fault corrected.
Clutch overheating message
The
symbol, together with a message on the display,
lights up to indicate clutch overheating.
If you continue driving, the symbol
will disappear and
the warning light will come on (on some versions
together with a message on the display) to indicate a
gearbox fault.
If the symbol comes on together with a message on
the display, limit the gear shifting and/or change the
condition of use, until normal operating conditions are
restored.
If the warning light lights up (a message will appear on
the display, on some versions) stop immediately, operate
the handbrake, switch off the engine and wait 5 minutes:
after this, normal transmission operating conditions will
be restored.
Should the transmission failure condition persist, contact
the dedicated Alfa Romeo Dealership.
FUEL CUT-OFF SYSTEM
The symbol and the corresponding message are shown on
the display in the following cases:
❒ fuel cut-off system intervention:
the yellow symbol lights up;
❒ fuel cut-off system failure:
the red symbol lights up.For reactivating the fuel cut-off system, refer to the
description in the
“Fuel cut-off system” section in the “In an emergency”
chapter. If it is not possible to restore the fuel supply,
contact a dedicated Alfa Romeo Dealership.
s è
Page 69 of 156
STARTING AND DRIVING
STARTING THE ENGINE........................................................................................ 68
PARKING .......................................................................................................................69
TCT TWIN CLUTCH TRANSMISSION ............................................................ 70
CRUISE CONTROL.................................................................................................... 75
PARKING SENSORS ............................................................................................... 77
REFUELLING THE CAR ......................................................................................... 79
Let’s get to the heart of the matter: seeing how you can exploit
all the potentials of your car to the fullest.
This is how to drive your car safely in all conditions for
pleasantly comfortable and cost-efficient travelling.
Page 72 of 156
STARTING AND DRIVING
70
TCT TWIN CLUTCH
TRANSMISSION
Alfa 4C features the TCT 6-speed twin
dry clutch transmission with steering
wheel controls. This is an advanced
technical solution which combines the
control of a manual gearbox, the
immediacy of a sequential system and
the convenience of being able to select an
automatic selection programme without
the slowdown of a conventional
automatic transmission.
With the key removed from the ignition,
the system will not implement any action
when the buttons on the transmission
control panel on the central tunnel fig. 43
are pressed, irrespective of the pressure
applied to the brake pedal.
43A0L0067
Therefore, the transmission will remain in
the condition that it was in when the
engine was switched off.
With car stationary and key at MAR
(ignition-operated electrical services
activated), the screen displays the gear
engaged and the active operating mode
(automatic = AUTO or manual = no
display).
OPERATING MODE
The transmission can operate in two
operating modes (except when the “Race”
mode is selected):
❒ the first manual type (MANUAL), in
which the driver decides directly when to
change gear;
❒ the second completely automatic
(AUTO), in which the system decides
when to change gear.
When the “Race” mode is selected, the
only allowed operating mode is MANUAL.
Manual operation (MANUAL)
In this operating mode, the driver is
responsible for choosing the best gear
ratio to engage, depending on the car
operating conditions.Use the “+” steering wheel stalk to
engage a higher gear, or the “–” stalk to
engage a lower gear (see the following
paragraph, “Steering wheel stalks”).
If the request is accepted by the system,
the display shows the new gear engaged.
If the request is not accepted by the
system, the display shows the gear
engaged before the request and emits an
acoustic signal.
If the gear change request may adversely
affect the correct operation of the engine
and the transmission, the system will not
allow it.
44A0L0146
Page 76 of 156
STARTING AND DRIVING
74
The car always starts in neutral. When
1st gear is requested, the system forces
the selection of AUTO mode.
IMPORTANT If 10 seconds elapse with
the ignition key in the MAR position and
the display does not show the gear
engaged, turn the key to the STOP
position, wait for the display to go out
and then repeat the manoeuvre.
If the fault persists, contact a dedicated
Alfa Romeo Dealership.
ACOUSTIC SIGNAL
For safety reasons, there is a buzzer
warning when parking the car with the
gearbox in neutral (N) (the warning is
heard when the ignition key is turned to
the STOP position).
With the vehicle stationary, the engine
started and (1st) or (R) engaged, the
system activates the buzzer and
automatically put the gearbox in neutral
(N) when:
❒ the accelerator and/or the brake
pedal are not operated for at least 3
minutes;
❒ the brake pedal is pressed for longer
than 10 minutes;❒ the driver’s door is opened and the
accelerator pedal or the brake pedal are
not operated for at least 1.5 seconds;
❒ a fault is detected in the gearbox.
PARKING THE CAR
When parking and leaving the car,
proceed as follows:
❒ engage the gear (on a slope, engage
first gear if the vehicle is facing uphill or
reverse if it is facing downhill) and leave
the wheels steered;
❒ stop the engine and engage the
handbrake.
Block the wheels with a wedge or a stone
if the car is parked on a steep slope.
Wait until the indication of the gear
engaged disappears on the display
before releasing the brake pedal.
IMPORTANT: NEVER leave the car with
the transmission in neutral.
IMPORTANT NOTES
❒ With car stationary and gear engaged,
always keep the brake pedal pressed
until you decide to set off, then release
the brake and accelerate gradually.
❒ During prolonged stops with the
engine running, it is advisable to keep the
gearbox in neutral (N).❒ In order to safeguard the efficiency of
the clutch, do not use the accelerator to
keep the car stationary (e.g. when
stopped on an incline). Clutch overheating
could damage it:
use the brake pedal instead or the
handbrake and only press the accelerator
pedal when you wish to set off.
❒ If, with reverse gear (R) engaged, you
have to engage 1st gear or vice versa,
only do this when the car is completely
stationary and with the brake pedal
pressed.
❒ Although it is strongly discouraged, if
you are going downhill and for unknown
reasons you let the car move forward
with the gearbox in neutral (N), when
there is a request to engage a gear the
system will automatically engage the
best gear in relation to the speed of the
actual to allow the correct transmission
of the drive torque to the wheels;.
Page 106 of 156
SERVICING AND CARE
104
2436486072
Thousands of km
Months
40
12
206080100120
Visually inspect condition of the accessory drive belt(s)
Inspect the conditions of toothed timing drive belt
Check handbrake lever travel and adjust, if necessary
(or every 12 months)
Use the diagnosis socket to check supply/engine and
gearbox/transmission management system operation and engine oil degradation
Check and, if necessary, top up oil level for the
twin clutch transmission
Replace spark plugs (1)
Replace accessory drive belt/s
Replace toothed timing drive belt (2)
Replace air cleaner cartridge
Replace engine oil and oil filter (3)
Change brake fluid (or every 24 months)
(1) The following are essential to ensure correct operation and prevent serious damage to the engine: only use spark plugs of the same make and type
which are specially certified for such engines (see the information in the “Engine” paragraph in the “Technical specifications” chapter); strictly
comply with the spark plug replacement interval given in the Scheduled Servicing Plan; for spark plug replacement, it is advisable to contact a
dedicated Alfa Romeo Dealership.
(2) Irrespective of the mileage, the timing drive belt must be replaced every 4 years for heavy-duty use
(cold climates, town use, long periods of idling) or, in any case, every 5 years.
(3) The actual interval for changing the oil and replacing the engine oil filter depends on the car usage conditions and is signalled by the warning light
or message (where provided) or the instrument panel or, in any case, every 12 months.
Page 133 of 156
131
(*) IMPORTANT Do not top up or mix with other fluids which have different specifications from those described.
(**) When the vehicle is used in particularly harsh weather conditions, we recommend using a 60% mixture of PARAFLUUPand 40% of demineralised
water.Synthetic fluid for brake and clutch
systems. That passes
FMVSS n. 116 DOT 4 specifications,
ISO 4925, SAE J1704 TUTELA TOP 4
Contractual Technical
Reference N° F001.A93
or
TUTELA TOP 4/S
Contractual Technical
Reference N° F005.F15Hydraulic brakes and
hydraulic clutch controls
Mixture of alcohol, water and
surfactants
CUNA NC 956-11 ^
SC 35
Contractual Technical
Reference N. F201.D02To be used diluted or
undiluted in
windscreen washer/wiper
systems Windscreen
washers liquidRed protective with antifreeze action,
based on inhibited monoethyl glycol
with organic formula. Exceeds CUNA NC
956-16, ASTM D 3306 specifications. PARAFLU
UP(*)
Contractual Technical
Reference N. F101.M01Proportions of use:
50% demineralised water
50% PARAFLU
UP(**) Protective agent
for radiators Brake liquid
Adhesive for glassBasic adhesive MS Polymer
FIAT qualification 9.55738/CSIMSON ISR 70-08 AP Gluing windows to body
Replacement interval /
applicationsUseFeatures Genuine fluids and
lubricants
28)The use of products with specifications other than those indicated above could cause damage to the engine not covered by the warranty.
WARNING
Specifications
9.55597
or
MS.90039
9.55523
or
MS.90032
9.55522
or
MS.90043
–
Page 153 of 156
151
Paint (identification plate) ....................121
Parking lights ..................................................17
Parking sensors .............................................77
Parking ................................................................69
handbrake ...................................................69
Passenger side front airbag
and child restraint systems ......................64
Passenger side front airbag .....................64
Performance ................................................132
Power windows ..............................................23
Pre-Fill (RAB - Ready Alert Brake)
system .................................................................52
Pretensioners ..................................................59
load limiters ..............................................60
Raising the car ............................................114
Read this carefully............................................2
Rear direction indicators ...........................85
Rear fog light/reversing light ..................86
Rear fog lights ................................................18
Rear light clusters
(changing a bulb) .............................................85
Rear-view mirror ............................................15
Refuelling .......................................................129
Refuelling the car .........................................79
Regular checks ............................................105
Remote control ..................................................9
Safety .................................................................49
SBR system (Seat Belt Reminder) ........59
Scheduled Servicing Plan .......................103
Seat belts ...........................................................57
use ..................................................................57
Seats ....................................................................13
Setup menu ...............................................32, 33
Side lights/brake lights ..............................86
Side lights/dipped beam
headlights ..........................................................17
Snow chains ...................................................126
Snow tyres .....................................................124
Spark plugs (type) ......................................122
Specifications ..............................................119
Speedometer .................................................30
Spider version ..............................................135
boot volume ............................................143
cleaning/washing the top.................138
CO
2emissions .......................................145
engine .........................................................144
front light clusters ..............................140
fuel consumption..................................145
performance ..........................................144
removable soft top..............................136
scheduled servicing ............................139
size...............................................................143
specifications.........................................142
weights ......................................................142Starting the engine ..............................68/72
Starting up and driving ...............................67
Steering wheel ................................................14
Steering wheel lock ......................................11
Tachometer .............................................30/31
TCT twin clutch transmission .................70
Third brake light
(bulb replacement) ........................................86
Towing the car .................................................99
attaching the tow ring ...........................99
TPMS (Tyre Pressure Monitoring
System) ...............................................................53
Trip Computer .................................................33
Tyres .................................................................123
Fix&Go Automatic (kit) ...............................94
inflation pressures ..............................124
snow tyres ...............................................124
tyres fitted ..............................................123
Using the Owner Handbook ........................3
Using the transmission ..............................70
Warning lights and messages .................34
Weights ............................................................128
Wheel rims and tyres ................................123
size...............................................................123
snow chains .............................................126
snow tyres ...............................................124