engine Acura TL 2004 Manual PDF

Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the ambient
temperature is between 20° and
95°F.Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions. If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more. Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
CONT INUED
St at e Emissions T est ing
T esting of Readiness Codes
T echnical Inf ormation263

µµ
µ
(


%
)
$
%

.
"

#
) This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
This manual describes the procedures involved in the
replacement of damaged body parts.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
270
NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA
Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

CONT INUED
BatteryCharging System ...........................
Indicator .52, 242
............................
Jump Starting .238
..............................
Maintenance .226
............................
Specif ications .257
..............................
Bef ore Driving .163
....................................
Belts,Seat .8,19
...........................
Beverage Holder .106
Brakes ...........
Anti-lock System (ABS) . 189
.............
Break-in, New Linings . 164
...........................................
Fluid .211
.......................................
Parking .103
.................
System Indicator . 52,244 ........................
Wear Indicators .188
.............................
Braking System .188
........................
Break-in, New Car .164
..
Brightness Control, Instruments . 75
........................
Brights, Headlights .74
Bulb Replacement ..........................
Back-up Lights .216
.................................
Fog Lights .213
............................
Specif ications .257
............
Turn Signal Lights . 214,215
..............................
Bulbs, Halogen .213
............................
Capacities Chart .256
.............
Carbon Monoxide Hazard . 46
............................
Carrying, Cargo .171
Cassette Player ............................................
Care .138
...................................
Operation .136
..............
CAUTION, Explanation of . ii
..................................
Ceiling Light .104
........................
Certif ication Label .254
...................................
Chains, .225
...
Accessories and Modif ications . 168
................................
Accessories .169
............................
Modif ications .170
ACCESSORY (Ignition Key .......................................
Position) .80
............
Accessory Power Sockets . 106
................
Adding Engine Coolant . 207
........................
Adding Engine Oil .204
....................
Additives, Engine Oil . 205
...............................
Airbag (SRS) .9, 22
...............
Additional Information . 22
......................................
Servicing .28
...................
System Components . 22
..............
Air Conditioning System . 110
.......................
Air Pressure, Tires .221
......................................
Antif reeze .207
Anti-lock Brakes (ABS) ...............................
Indicator .53, 189
...................................
Operation .189
..............
Anti-thef t, Audio System . 140
.
Anti-thef t Steering Column Lock . 80
................................
Audio System .117
...
Automatic Lighting Off Feature . 76
...
Automatic Seat Belt Tensioners . 20.............
Automatic Speed Control . 142
..............
Automatic Transmission . 181
..........................
Capacity, Fluid .256
...............
Checking Fluid Level . 209
.......................................
Shif ting .181
.
Shif t Lever Position Indicator . 181
.......................................
Shif ting .181
....................
Shif t Lock Release . 185
tires
Index
A
BC
I

ÎÎÎ
ÎÎ
Changing Oil ........................................
How to .205
......................................
When to .195
....................
Changing a Flat Tire .231
...
Charging System Indicator . 52,242
............
Checklist, Bef ore Driving . 176
..................
Childproof Door Locks . 84
.....................................
Child Saf ety .29
..............................
Booster Seats .43
...................................
Child Seats .36
..........................................
Inf ants .34
............................
Large Children .42
.........................................
LATCH .38
......................
Risks with Airbags .30
.............................
Small Children .35
.........................................
Tethers .41
.........
Where Should a Child Sit? . 30
Cleaning .................................
Floor Mats .218
...................................
Seat Belts .218
...............
Climate Control System . 115
..............................................
Clock .103
..........................
CO in the Exhaust .46
.......................
Compact Spare .230
.................
Console Compartment . 107
...............
Consumer Inf ormation . 265.............
Controls, Instruments and . 49
Coolant ........................................
Adding .207
....................................
Checking .167
.........................
Proper Solution .207
...................
Temperature Gauge . 57
Crankcase Emissions Control ........................................
System .260
................
Cruise Control Indicator . 54
............
Cruise Control Operation . 142
...................................
Cup Holders .106
..........
Customer Relations Of f ice . 266
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 50
............
Daytime Running Lights . 74
Daytime Running Light ...................................
Indicator .55
............
Def ects, Reporting Saf ety . 268
................
Def ogger, Rear Window . 77
..............
Def rosting the Windows . 114
....................................
Dimensions .256
...............
Dimming the Headlights . 74Dipstick
..........
Automatic Transmission . 209
..................................
Engine Oil .167
..........................
Directional Signals .74
........
Disc Brake Wear Indicators . 188
.................................
Disc Changer .129
...
Disc Changer Error Messages . 135
.....................
Disposal of Used Oil .206
Doors ..............................
Monitor Light .60
......................
Power Door Locks .82
..........
DOT Tire Quality Grading . 258
...........
Driver and Passenger Safety . 5
...........................................
Driving .175
....................................
Economy .168
Driving Position Memory ..........................................
System .93
..............................
Economy, Fuel .168
............
Emergencies on the Road . 229
.............
Battery, Jump Starting . 238
...........
Brake System Indicator . 244
................
Changing a Flat Tire . 231
.....
Charging System Indicator . 242
tire
Index
D
E
II

ÎCONT INUED
...............
Gas Mileage, Improving . 168
.........................................
Gasoline .164
...............
Fuel Reserve Indicator . 56
...........................................
Gauge .57
................
Octane Requirement . 164
........................
Tank, Filling the .165
................
Gas Station Procedures . 165
...................................
Fan, Interior .122
Features, Comfort and ..............................
Convenience .109
....................
Filling the Fuel Tank . 165
........................................
Filter, Oil .205
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 231
.....................................
Floor Mats .218
Fluids ..........
Automatic Transmission . 209
..........................................
Brake .211
.........................................
Clutch .211
..............
Manual Transmission . 210
..........................
Power Steering .212
................
Windshield Washers . 208
FM Stereo Radio ...................................
Reception .122
.....................................
Fog Lights .75 ..........................
Four-way Flashers .76
..............................
Front Airbags .9 ,22
......................................
Front Seats .90
......................................
Adjusting .90
.........................................
Heaters .96
.....................................
Airbags .9, 22
.................................................
Fuel .164
......................
Fill Door and Cap .165
...........................................
Gauge .57
................
Octane Requirement . 164
........................
Reserve Indicator .56
........................
Tank, Filling the .165
.....................
Fuses, Checking the .245
..................
Checking the Fuses . 245
.........
Hazard Warning Flashers . 76
......
If Your Vehicle Gets Stuck . 249
............................
Jump Starting .238
.....
Low Oil Pressure Indicator . 242
...
Malf unction Indicator Lamp . 243
..................
Overheated Engine . 240
.......................................
Towing .249
.........................
Emergency Brake .103
......................
Emergency Flashers .76
......................
Emergency Towing .249
............
Emergency Trunk Opener . 84
.......................
Emissions Controls .260
.............
Emissions Testing, State . 263
Engine ....
Coolant Temperature Gauge . 57
Malf unction Indicator ................................
Lamp .52, 243
.........................................
Oil Lif e .64
........
Oil Pressure Indicator . 52,242
..............
Oil, What Kind to Use . 204
...............................
Overheating .240
............................
Specif ications .257
....................
Speed Limiter . 179,185
.......................................
Starting .177
...................
Engine, .236 ......................
Ethanol in Gasoline .164
.
Evaporative Emissions Controls . 260
...............................
Exhaust Fumes .46
Expectant Mothers, Use of Seat ........................................
Belts by .17
if it won’t start
Index
F
G
III

ÎÎÎ
ÎÎ.................
Jacking up the Vehicle . 232
.......................................
Jack, Tire .231
................................
Jump Starting .238
Gauges
...
Engine Coolant Temperature . 57
...............................................
Fuel .57
...............................
Speedometer .57
.................................
Tachometer .57
Gearshif t Lever Positions ..........
Automatic Transmission . 181
6-speed Manual .........................
Transmission .178
......................................
Glove Box .107 ...
Identif ication Number, Vehicle . 254
Ignition ..............................................
Keys .79
...........................................
Switch .80
............
Timing Control System . 261
........................
Immobilizer System .81
.........
Important Safety Precautions . 6
.........................................
Indicators .52
......
ABS (Anti-Lock Brake) . 53,189
Brake (Parking and Brake ............................
System) .52, 244
................
Charging System . 52,242
.............................
Cruise Control .54
DRL (Daytime Running ..................................
Lights) .55
...................................
Fog Light .56
...................................
High Beam .55
........
Key (Immobilizer System) . 56
......................................
Low Fuel .56 ................
Low Oil Pressure . 54,242
...........................
Side Airbag Of f .53
.........................................
SRS .26, 53
Turn Signal and Hazard ...................................
Warning .55
............................
VSA Activation .54
.................................
VSA System .54
...............................
Inf ant Restraint .34
......................................
Inf ant Seats .34
..........
Tether Anchorage Points . 41
...................
Inf lation, Proper Tire . 221
...................................
Inside Mirror .91
.............................
Inspection, Tire .222
............................
Instrument Panel .51
..........
Instrument Panel Indicators . 52
........
Instrument Panel Brightness . 75
...............................
Interior Lights .104
........................................
Introduction .i
.......................
Halogen Fog Bulbs .213
..........
HandsFree Link (HFL) . 70,149
..............
Hazard Warning Flashers . 76
........................................
Headlights .74
........................................
Aiming .213
Automatic Lighting Off .....................................
Feature .76
.......
Daytime Running Lights . 74
..................
High Beam Indicator . 55
.........................
Reminder Chime .74
...................................
Turning on .74
..............................
Head Restraints .89
.................
High-Low Beam Switch . 74HomeLink Universal
................................
Transceiver .145
....................................
Hood Latch .212
.......................
Hood, Opening the .166
Index
H I
J
IV

CONT INUED
..................................................
Keys .79
...............
Keyless Memory Setting . 66
...................
Neutral Gear Position . 182
..................
New Vehicle Break-in . 164
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 254
.......................
Label, Certif ication .254
.................
Lane Change, Signaling . 74
........................
Lap/Shoulder Belts .19
Lights ....................
Bulb Replacement .213
.......................................
Indicator .52
.........................................
Parking .74
..................................
Turn Signal .74
.....................................
Load Limit .172
......
LOCK (Ignition Key Position) . 80
........................
Lockout Prevention .82
Locks .......
Anti-thef t Steering Column . 80
..................................
Glove Box .107
.................................
Power Door .82
...........................................
Trunk .83
........................
Low Coolant Level .167
...
Low Oil Pressure Indicator . 52,242
...
Lubricant Specif ications Chart . 256..............
Luggage, .171
...
Octane Requirement, Gasoline . 164
.........................................
Odometer .62
...............................
Odometer, Trip .62
Oil ........................
Change, How to .205
......................
Change, When to .195
......................
Checking Engine .167
..............
Pressure Indicator . 52,242
Selecting Proper Viscosity ......................................
Chart .204
...........
ON (Ignition Key Position) . 80
..................................
Maintenance .193
.....................................
Messages .64
........................................
Minder .195
...
Owner Maintenance Checks . 198
........................................
Record .200
..........................................
Saf ety .194
Malf unction Indicator ....................................
Lamp .52, 243
...................
Manual Transmission . 178
........
Manual Transmission Fluid . 210
.............
Memory, Driving Position . 93
...............................
Meters, Gauges .57
..........................
Mirrors, Adjusting .91
...............
Modif ying Your Vehicle . 170
.......................................
Moonroof .100
.............
Multi-Inf ormation Display . 59
............................
Engine Oil Lif e .64
..........................
HandsFree Link .70
.........
Keyless Memory Settings . 66
.............
Maintenance Messages . 64
.....................................
Odometer .62
.................
Outside Temperature . 63............................
Trip Computer .65
...................................
Trip Meter .62
Storing (Cargo)
Index
K
L N
O
M
V

Î..................................
Saf ety Belts .8, 19
.........
Safety Defects, Reporting . 268
.................................
Saf ety Features .7
...........................................
Airbags .9
..................................
Door Locks .11
..........................
Head Restraints .13
.......................................
Seat Belts .8
.....................
Seats & Seat-Backs .12
.............
Saf ety Labels, Location of . 47
...............................
Saf ety Messages . ii
................................
Satellite Radio .124
.....................................
Seat Belts .8, 19
...............
Additional Information . 19
Onboard Ref ueling Vapor
....................................
Recovery .260
..............................
Outside Mirrors .91
.....................
Outside Temperature .63
....................
Overheating, Engine .240
....
Owner’s Maintenance Checks . 198
..............
Panel Brightness Control . 75
........................
Park Gear Position .182
...........................................
Parking .187
...............................
Parking Brake .103
Parking Brake and Brake System ...............................
Indicator .52, 244
.................................
Parking Lights .74
..
Parking Over Things that Burn . 187
.............................
PGM-FI System .261
...............
Power Socket Locations . 106
.........
Pregnancy, Using Seat Belts . 17
.........
Protecting Adults and Teens . 11
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children .29
Installing a Child Seat Using ........................................
Latch .38 Installing a Child Seat with a
..................
Lap/Shoulder Belt . 40
Installing a Child Seat with a ......................................
Tether .41
.................
Selecting a Child Seat . 36
.......................
Protecting Inf ants .34
.......
Protecting Larger Children . 42
.........
Protecting Small Children . 35
..................
Protecting Your Discs . 134
...................
Radiator Overheating . 240
Radio/Cassette/Disc Sound ........................................
System .117
...................
Readiness Codes . 243,263
..
Rear Lights, Bulb Replacement . 215
..........................
Rear Seat Armrest .89
............................
Rear View Mirror .91
.................
Rear Window Def ogger . 77
...............
Reclining the Seat Backs . 88
.............................
Reminder Lights .52
................
Remote Audio Controls . 139
.......................
Remote Transmitter .85
Replacement Inf ormation ................
Engine Oil and Filter . 205..........................................
Fuses .245
................................
Light Bulbs .213
...........................................
Tires .224
.............................
Wiper Blades .219
Replacing Seat Belts Af ter a ............................................
Crash .21
...
Reserve Tank, Engine Coolant . 167
.........................
Restraint, Child .34 ,35
..................
Reverse Gear Position . 182
................................
Rotation, Tire .223
Index
P
RS
VI

Î
CONT INUED
.....................................
Tachometer .57
.
Taking Care of the Unexpected . 229
....................................
Tape Player .136
Technical Descriptions ......
DOT Tire Quality Grading . 258
.....
Emissions Control Systems . 260
Three Way Catalytic ...............................
Converter .262
.......................
Temperature Gauge .57
....................
Temperature, Outside . 63
........
Temperature, Inside Sensor . 116
..............
Tether Anchorage Points . 41
..
Three Way Catalytic Converter . 262
..................
Tilt the Steering Wheel . 78
..........................
Time, Setting the .103
.....................................
Cleaning .218
................
Lap/Shoulder Belt . 14,19
................................
Maintenance .21
Reminder Light and ................................
Beeper .19, 52
...................
System Components . 19
...............
Use During Pregnancy . 17
....................................
Seat Heaters .96
........................
Seats, Adjusting the .90
............................
Security System .141
........
Sequential SportShif t Mode . 183
...............................
Serial Number .254
...........................
Service Intervals .195
...........................
Service Manual .269
.........
Service Station Procedures . 165
..........................
Setting the Clock .103
.....
Shif t Lever Position Indicator . 181
........................
Shif t Lock Release .185
...........................................
Shif ting .181
................................
Side Airbags .9 ,25
........
Side Airbag Of f Indicator . 27,53
......................
Side Curtain Airbags .26
...............................
Signaling Turns .74
.....................................
Snow Tires .225
................................
Sound System .117 Spare Tire
......................................
Inf lating .230
............................
Specif ications .257
....................
Specif ications Charts . 256
................................
Speed Control .142
..........
SRS, Additional Inf ormation . 33
...
Additional Safety Precautions . 28
....................
Airbag Components . 22
.............................
Airbag Service .28
How the SRS Indicator .......................................
Works .26
How Your Front Airbags .........................................
Work .23
...
How Your Side Airbags Work . 25
How Your Side Curtain Airbags .........................................
Work .26
.............................
SRS Indicator .26 ,53
....
START (Ignition Key Position) . 80
.......................
Starting the Engine .177
................
With a Dead Battery . 238
..............
State Emissions Testing . 263
........
Steam Coming f rom Engine . 236
Steering Wheel ..................................
Adjustment .78
.............
Anti-theft Column Lock . 80
...................
Stereo Sound System . 117....................
Storing Your Vehicle .227
........................
Sunglasses Holder .108
....
Supplemental Restraint System . 22
......................................
Servicing .28
...............................
SRS Indicator .26
...................
System Components . 22
Index
T
VII

Service Inf ormat ion Summary
Manual Transmission
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:
Automatic Transmission Fluid: Tire Pressure (measured cold):
SpareTirePressure:
Power Steering Fluid:
Brake Fluid:
4.5 US qt (4.3
)
Premium unleaded gasoline,
pump octane number of 91 or
higher.
API Service SJ ‘‘Energy
Conserving’’ oil, SAE 5W-20
viscosity (see page ).
Oil change capacity (including
filter):
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page ). Manual Transmission Models
Front:
35 psi (240 kPa , 2.4 kgf/cm
)
Rear:
Automatic Transmission Models Front:
Rear:
60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm
)
Honda Manual Transmission
Fluid preferred, or an SAE 10W-30
or 10W-40 motor oil as a
temporary replacement (see page
).
Capacity:
2.6 US qt (2.5
)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ). 32 psi (220 kPa , 2.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm
)
209 204
210
212211
17.09 US gal (64.7)