check oil Alfa Romeo 159 2010 Owner handbook (in English)

35 70 105 140 175
●●●●●
●
●●●●●
●●●●●
●●●●●
●
●
●
●
●
●
●●
●●
●●
●
●●●●●
●●●●●
●●●●●
●●
●●●●●
Thousands of km
Check and adjust tappet clearance (1.9 JTDM8v version)
Check and adjust tappet clearance, if required (1.8 140 HP version)
Check exhaust emissions (petrol versions)
Check exhaust emissions/smoke (diesel versions)
Check engine control system operation (through diagnosis socket)
Replace accessory drive belt/s (except 1.8 140 HP version)
Replace accessory drive belt/s (1.8 140 HP version)
Replace timing belt (1.8 140 HP version) (*)
Replace timing belt (1750 TURBO BENZINA version) (*)
Replace timing belt (diesel versions) (*)
Change spark plugs (3.2 JTS and 2.2 JTS Selespeed versions)
Change spark plugs (1.8 140 HP and 1750 TURBO BENZINA versions)
Replace diesel fuel filter (diesel versions)
Change air cleaner cartridge
Change front transmission gear oil (3.2 JTS 4x4 versions)
Change engine oil and oil filter (1.8 140 HP versions) (or every 12 months)
Change engine oil and oil filter (1750 TURBO BENZINA versions) (**)
(or every 12 months)
Change engine oil and oil filter (3.2 JTS and 2.2 JTS Selespeed versions)
(or every 24 months) (***)
Change engine oil and oil filter (diesel versions with DPF) (**)
(or every 24 months)
Change engine oil and oil filter (diesel versions without DPF)
(or every 24 months)
Change brake fluid (or every 24 months)
Change pollen filter (or every 24 months)
(*) Regardless of the km covered, the timing belt shall be replaced every 4 years for particularly demanding use (cold climates, driving in the city,
idling for a long time) or in any case every 5 years.
(**) The engine oil and the filter must be changed when the instrument panel warning light comes on (see “Warning lights and Messages” chapter)
and in all cases every 24 months.
If the car is mainly used for town driving or in particularly harsh climate conditions and has a low annual mileage, the engine oil and filter should
be changed every 12 months.
CAR
MAINTENANCE
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
INDEX
TECHNICAL
SPECIFICATIONS
IN AN
EMERGENCY
WARNING
LIGHTS AND
MESSAGES
SAFETY
DEVICES
226
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 226

USE OF THE CAR
UNDER HEAVY
CONDITIONS
Should prevailing use of the car be un-
der one of the following specially heavy
conditions:
❒ trailer or caravan towing;
❒ dusty roads;
❒ short distances (less than 7-8 km)
and repeated with external temper-
atures below zero;
❒ frequently idling engines or long dis-
tance low speed driving (e.g.: door-
to-door deliveries) or in case of a long
term inactivity;
❒ urban routes;
carry out checks more frequently than
required on Service Schedule:
❒ check front disk brake pad conditions
and wear;
❒ check cleanness of bonnet and boot
locks and lever cleanness and lubri-
cation;
❒ sight inspect the conditions of: en-
gine, gearbox, transmission, pipes
and hoses (exhaust - fuel - brakes),
rubber parts (boots, sleeves, bushes,
etc.);
❒ check battery charge and fluid level
(electrolyte);
❒ visual check on various drive belt con-
ditions;
❒ change engine oil and oil filter, if re-
quired;
❒ check and replace pollen filter, if re-
quired;
❒ check and replace air cleaner, if re-
quired.
PERIODICAL CHECKS
Every 1,000 km or before long jour-
neys, check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒ tyre pressure and conditions.
❒ check light system operation (head-
lights, direction indicators, hazard
lights, etc.);
❒ check windscreen wiper/washer op-
eration and windscreen/rear window
blade position/wear;
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use
PETRONAS LUBRICANTSprod-
ucts, designed and produced specifical-
ly for Alfa Romeo cars (see table “Ca-
pacities” in section “Technical specifi-
cations”).
CAR
MAINTENANCE
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
INDEX
TECHNICAL
SPECIFICATIONS
IN AN
EMERGENCY
WARNING
LIGHTS AND
MESSAGES
SAFETY
DEVICES
227
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 227

228
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
CAR
MAINTENANCE
CHECKING
FLUID LEVELS
For refilling amounts refer to Technical
Specifications section.
1.Engine oil - 2. Battery
3.Brake fluid - 4.Windscreen washer
fluid - 5.Engine coolant -
6.Power steering fluid
fig. 2 - 1750 TURBO BENZINA version
2
4
1 6
53
A0E0854m
Never smoke while
working in the engine
compartment; gas and inflam-
mable vapours may be pre-
sent, with the risk of fire.
WARNING
When topping up take
care not to confuse the
various types of fluids:
they are all incompatible with
one another and could serious-
ly damage the car.
A0E0374mfig. 1 - 1.8 140 HP version
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 228

ENGINE OIL
Fig. 7: 1.8 140 HP version
Fig. 8: 1750 TURBO BENZINA version
Fig. 8/a: 2.2 JTS Selespeed version
Fig. 9: 3.2 JTS version
Fig. 10: 1.9 JTD
M8V-
1.9 JTD
M16Vversions
Fig. 11: 2.0 JTD
Mversion
Fig. 12: 2.4 JTD
MversionChecking engine oil
Check the oil level a few minutes (about
5) after the engine has stopped, with
the car parked on level ground.
Remove the dipstick Aand clean it, put it
back in completely, remove it and check
that the level is within the MIN and
MAXmarks on the dipstick. The gap be-
tween the MINand MAX marks cor-
responds to about one litre of oil.
CAR
MAINTENANCE
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
INDEX
TECHNICAL
SPECIFICATIONS
IN AN
EMERGENCY
WARNING
LIGHTS AND
MESSAGES
SAFETY
DEVICES
232
A0E0856mfig. 8A0E0069mfig. 9
A0E0233mfig. 10
A0E0855mfig. 11A0E0400mfig. 7
A0E0202mfig. 12
A0E0018mfig. 8/a
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 232

CAR
MAINTENANCE
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
INDEX
TECHNICAL
SPECIFICATIONS
IN AN
EMERGENCY
WARNING
LIGHTS AND
MESSAGES
SAFETY
DEVICES
233
Engine oil consumption
Max engine oil consumption is usually
400 grams every 1000 km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption can only be considered sta-
bilised after the first 5000 - 6000 km.
IMPORTANTThe oil consumption de-
pends on driving style and the conditions
under which the car is used.
IMPORTANTDo not add oil with
specifications other than that already
in the engine. Topping up engine oil
If the oil level is near or even below the
MINmark, add oil through the filler
neck B, until reaching the MAXmark.
Oil level shall never exceed the MAX
mark.
IMPORTANT If a routine check re-
veals that the oil level is above the
MAXmark, contact Alfa Romeo Au-
thorized Services to have the correct lev-
el restored.
IMPORTANT After adding or changing
the oil, let the engine turn over for a few
seconds and wait a few minutes after
turning it off before you check the level.
When the engine is hot,
take care when work-
ing inside the engine compart-
ment to avoid burns. Remem-
ber that when the engine is
hot, the fan may cut in: danger
of injury. Scarves, ties and
other loose clothing might be
pulled by moving parts.
WARNING
Used engine oil and fil-
ter contain harmful sub-
stances for the environ-
ment. Contact Alfa Romeo Au-
thorized Services to have the oil
and filter changed.
223-248 Alfa 159 GB 3-12-2009 14:11 Pagina 233

320
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
INDEX
– fuel gauge ......................... 22
Fuel cut-off and power supply
switches ............................... 81
Fuel feed ................................ 255
Fuel filler cap .......................... 126
Fuses (replacement) .......... 209-292
Gearbox (use) ........................ 156
Glass/can holder ..................... 87
Glove compartment .................. 85
Glove compartment light
– bulb replacement ................ 207
Handbrake ............................. 155
Hazard lights ........................... 72
Head restraints ................. 48-49
Headlight washer
– control .............................. 73
– fluid level .......................... 232
Headlights .............................. 65
– adjusting headlight beam ..... 106
– headlight adjustment abroad 107
– headlight aiming device ....... 106
– front fog light adjustment ..... 107
Hill Holder system .................... 111
Homelink ............................... 89
Identification data .................... 250
If an exterior light burns out .. 196-288
If an interior light burns out .. 205-290
Ignition device ......................... 19In an emergency................ 181
Inactivity of the car .................. 164
Inertial fuel cut-off switch .......... 80
Installation of electric/
electronic devices ................... 117
Instrument panel ..................... 7-8
Instruments ............................ 21
Interior fittings ......................... 83
Interiors ................................. 247
Isofix universal
(child's seat) ..................140-286
Jacking the car ........................ 220
Labels
– identification data ............... 250
– bodywork paint .................. 251
Level checks ........................... 230
Main beam headlights
– bulb replacement ................ 199
– control .............................. 70
Manual climate control system ... 55
MSR system ........................... 114
Multifunction display ................ 25
Number plate light .................. 204
Oddments compartments .......... 88
Paint ..................................... 246
Parking .................................. 155 Direction indicators
– bulb replacement 200-201-204
– control .............................. 70
Doors ..................................... 96
Electronic key .......................... 12
Engine
– identification code ............... 252
– marking ............................ 251
– technical data .................... 253
Engine oil
– consumption ...................... 232
– level check ........................ 231
– specifications ..................... 266
Engine starting ........................ 150
Environment protection ............. 127
EOBD system .......................... 115
External lights ......................... 70
Eyeglasses holder .................... 87
Fix&Go automatic (device) ....... 190
Flashing the headlights ............. 70
Fluid level checks ..................... 230
Fluids and lubricants ................. 267
Follow me home (device) ......... 71
Front ceiling lights
– bulb replacement ................ 205
– control .............................. 78
Front fog lights
– bulb replacement ................ 202
– control .............................. 72
Fuel
– consumption ...................... 269
– fuel cut-off switch ............... 81
319-328 Alfa 159 GB 3-12-2009 15:53 Pagina 320

ENGINE OIL REPLEACEMENT (litres)
REFUELLING (litres)
CUSTOMER SERVICESTECHNICAL SERVICES - SERVICE ENGINEERING
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Fiat Group Automobiles S.p.A.
Publication no. 60438100 - 3 Edition - 11/2009
All rights reserved. Reproduction, even in part is prohibited without written permission
from Fiat Group Automobiles S.p.A.
SERVICE
COLD TYRE INFLATION PRESSURE
Space-saver
spare wheel
T125/80 R17
4.2
1.8 140 HP - 1750 TURBO BENZINA - 1.9 JTDM8v - 1.9 JTDM16v - 2.0 JTDM- 2.4 JTDM- 3.2 JTS
Fuel tank capacity 70
Reserve 10
For cars with petrol engine, only use unleaded petrol with over 95 R.O.N. (Specification EN228).
For cars with diesel engine only use Diesel fuel for motor vehicles (Specification EN590).
Tyres
205/55 R16 91V
front rear
2.3 2.3
2.6 2.6Tyres
215/55 R16 93V
front rear
2.3 2.3
2.5 2.5Tyres
225/50 R17 98W
front rear
2.5 2.5
2.9 2.7Tyres
235/45 R18 98W (▼)
front rear
2.7 2.5
2.9 2.7Tyres
235/40 ZR19 96Y (▼)
front rear
2.7 2.5
3.0 2.8
average load bar
full load bar
1.8 140 HP 1750 3.2 JTS 1.9 JTDM8v 2.0 JTDM2.4 JTDMTURBO BENZINA 1.9 JTDM16v
Lubrication system engine 4.5 5.0 5.4 4.6 4.9 6.4
Do not discard used oil in the environment.
(▼) Unchainable tyres. When using winter tyres, use 225/50 R17 98 tyres or 235/45 R18 98. Vehicles with TI fittings should not use 16” wheel rims.
Add +0.3 bar to the prescribed inflation pressure when the tyres are warm. Recheck pressure value with cold tyres.
With snow tyres, add +0.2 bar to the inflation pressure value prescribed for standard tyres.
Inflate tyres to full load pressures if driving at continuous speed exceeding 160 km/h.
319-328 Alfa 159 GB 3-12-2009 15:53 Pagina 328