battery AUDI A4 1995 B5 / 1.G Heating And Ventilation System Servicing Workshop Manual
Page 1 of 24
87-151
Heating and ventilation system,
servicing Instrument panel air outlets and air guide
ducts
CAUTION!
Before working on the electrical system:
Note:
Air is extracted from the passenger compartment
through 2 outlets located on both sides of the rear
luggage compartment area near the bumper
page 87-157
.
Removing and installing Repair Manual, Body
Interior, Repair Group 70
Obtain security code for anti-theft radio.
Note customer's pre-set radio stations.
Disconnect battery Ground (GND) strap.1 -
Instrument panel top cover 2 -
Retaining spring for air guide duct
Pa
ge 1 of 24 Heatin
g and ventilation s
ystem, servicin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.87.22
Page 9 of 24
87-159
Heater/air conditioner assembly
complete with instrument panel,
removing and installing (1996)
- Using VAG1551 function 03, initiate output
Diagnostic Test Mode (DTM) page 01
-42
.
CAUTION!
Before proceeding with removal of instrument panel and heater/air
conditioner complete: - Proceed through output DTM and wait until air flow flap -A- closes via
air flow flap motor V71.
- Cancel output DTM (press VAG1551 button -C-) with closed air flow
flap -A-.
- Discharge refrigerant system page 87
-201
.
- Remove dust and pollen filter page 87
-158
.
Obtain security code for anti-theft radio.Note customer's pre-set radio stations.Move power seats to most rearward position.Disconnect and remove battery.
Pa
ge 9 of 24 Heatin
g and ventilation s
ystem, servicin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.87.22
Page 17 of 24
87-165
Heater/air conditioner assembly,
removing and installing (1997 )
CAUTION!
Obtain security code for anti-theft radio.
Note customer's pre-set radio stations.
Move power seats to most rearward
position.
Switch off ignition and disconnect battery
ground (GND) strap.
- Release pressure in coolant system by opening
cap at coolant expansion tank.
WARNING!
With hot engine, cooling system is under
pressure.
Coolant expansion tank cap must be
removed slowly.
Dispose of used coolant properly. Check
local regulations.
Pa
ge 17 of 24 Heatin
g and ventilation s
ystem, servicin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.87.22