AUDI A4 1996 B5 / 1.G APB Engine Lubrication System Components Manual PDF

17-65

Oil pressure and oil pressure switch,
checking


Note:
Servicing and checking function of oil pressure
warning lamp and buzzer:

Electrical Wiring Diagrams, Troubleshooting &
Component Locations

Test procedure

- Remove oil pressure switch (F1) and screw oil pressure switch into
tester.
- Screw tester into oil pan in place of oil pressure switch.
- Connect brown wire of tester to ground (GND) (-).
- Using test leads from VAG 1594, connect diode test lamp VAG 1527
between positive battery terminal (+) and oil pressure switch.
- Start engine and gradually increase engine speed.
LED should light up at 1.2...1.6 bar, otherwise replace oil pressure
switch.
- Increase engine speed further.

At 2000 RPM and an oil temperature of 80 C oil pressure should be at
least 2.0 bar.
Pa
ge 71 of 74 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE05.17.1

17-66

Engine oil, specifications

A high-quality multigrade oil is put in at the
factory: this can be used all year round, except in
extremely cold climates.

Viscosity grades and oil specifications
Viscosity grades and oil specifications
Repair Manual, Maintenance
Pa
ge 72 of 74 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE05.17.1

17-67

Oil level, checking


Test conditions

Oil temperature above 60 C.

Vehicle level.
The vehicle must be standing on level
ground when checking the oil level. Wait for
a few minutes after switching off the engine
to allow the oil to flow back into the oil pan.

Test sequence

- Pull out dipstick, wipe off with a clean cloth and
insert it again as far as it will go.

- Pull out dipstick again and read oil level.
Pa
ge 73 of 74 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE05.17.1

17-68


Markings on oil dipstick:
Note:
The oil level must not be above marking -a- on the dipstick.
Oil capacities Repair Manual, Maintenance
a - Do not top up oil.
b - Oil can be topped up. The oil level may rise as far as area -a- after
topping up.
c - Oil must be topped up. It is sufficient if the oil level is somewhere in
area -b- (grooved area on dipstick) after topping up.
Pa
ge 74 of 74 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE05.17.1