battery AUDI A4 1996 B5 / 1.G Quattro Fuel Syst
Page 47 of 55
20-98
Note:
Ensure that fuel hoses fit tightly.
Radio operating instructions - Tighten union nut with 3217 wrench.
60 Nm
- Connect wiring and harness connector.
- Connect Battery Ground strap with ignition switched OFF.
- After connecting Battery, input radio anti-theft code
- Run door windows up to stop using electric window lifters.
- Operate all window lifters again for at least 1 second in "closed"
position to activate automatic up/down.
- Set the clock.
Pa
ge 47 of 55 Fuel su
pp
ly system, servicin
g (vehicles with all wheel drive and 1.8 ltr. turbo or 2.8 ltr. en
gine
)
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.3
Page 50 of 55
20-101
Sender for fuel gauge -G, removing and
installing
Vehicles with all wheel drive and 1.8 ltr. turbo
or 2.8 ltr. engine
Observe Safety measures Page 20
-1 .
Observe Rules of cleanliness Page 20
-4 .
Removing
CAUTION!
Obtain the radio Anti-theft code from the
customer before disconnecting the Battery
Ground strap.
Note:
Fuel tank must not be filled higher than
1/3 maximum. - Disconnect Battery Ground strap with ignition switched OFF.
- Open fuel tank cover briefly and close again.
- If necessary, drain fuel tank using fuel cart Page 20
-66
.
Fuel supply unit, removing Page 20
-91
.
Pa
ge 50 of 55 Fuel su
pp
ly system, servicin
g (vehicles with all wheel drive and 1.8 ltr. turbo or 2.8 ltr. en
gine
)
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.3
Page 52 of 55
20-103
Installing
Installation is performed in reverse order, when
performing, note the following:
- Install sender for fuel gauge in guide on surge
housing outer section and press down until it
engages Page 20
-97
.
- Connect battery Ground strap with ignition
switched OFF.
- After connecting battery, input radio anti-theft
code
Radio operating instructions
- Operate door windows up to the stop using
window switches.
- Operate all window lifters again for at least 1
second in the "closed" position to activate the
automatic up/down.
- Set the clock.
Pa
ge 52 of 55 Fuel su
pp
ly system, servicin
g (vehicles with all wheel drive and 1.8 ltr. turbo or 2.8 ltr. en
gine
)
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.3