sensor AUDI A4 1999 B5 / 1.G Suspension Rear Axle All Wheel Drive Workshop Manual
Page 12 of 32
42-48
Headlight range control, removing and
installing
As a running change in m.y. 1998 vehicles with
xenon headlights may have a connection for the
headlight range control installed in the left-rear of
the headlight.
1 -
Subframe
2 -
Suspension strut
3 -
Lower control arm
4 -
Linkage for headlight range control
5 -
Self-locking nuts
10 Nm (7 ft lb)
6 -
Nut 3 Nm +1/-0 Nm (27 in. lb +9/-0 in. lb)Observe Note page 42
-49
7 -
Sensor for headlight range control
8 -
Mounting bracket
Pa
ge 12 of 32 Rear axle, servicin
g (all-wheel-drive vehicles
)
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.SU01.42.3
Page 13 of 32
42-49
When removing the rear axle or lower control
arm It is essential to loosen the linkage for the
headlight range control at lower control arm.
Note:
For mounting linkage to sensor for headlight
range control use a 10 mm open end wrench
with a thickness of distance -A-) to avoid damage
to the seal
Notes:
Distance -A-: 4 mm (0.157 in.)Position -1- tightening torque: 3 Nm +1/-0 Nm (27 in. lb +9/-0 in. lb)Make sure sensor arm is properly aligned to linkage when installing
headlight range control The linkage must be aligned vertically.The sensor arm must point outward and downward.
Pa
ge 13 of 32 Rear axle, servicin
g (all-wheel-drive vehicles
)
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.SU01.42.3
Page 25 of 32
42-59
- Disconnect brake lines at fittings -1- and -2- at left-rear below vehicle.
- Unclip brake lines from holder (arrow) below vehicle.
- Remove holders -1- and -2- for wiring to ABS wheel speed sensors -
G44- and -G46- at lower control arm.
- Pull ABS wheel speed sensors -G44- and -G46- (arrow) out of wheel
bearing housing.
- Unhook wiring for wheel speed sensors at front of subframe.
Pa
ge 25 of 32 Rear axle, servicin
g (all-wheel-drive vehicles
)
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.SU01.42.3