manual transmission AUDI A4 2000 B5 / 1.G AWM Engine Lubrication System Components Workshop Manual

17-16

Vehicles with automatic transmission:

Note:
Observe cleanliness rules when working on the
automatic transmission:

Repair Manual, 5 Spd. Automatic
Transmission 01V, Repair Group 37


Note:
Ignore positions -1- and -2-.
All models: - Remove bolt -3- and disconnect ATF lines from transmission.
- Remove bracket for ATF lines from engine.
- Move ATF lines aside.

- Remove stop for torque reaction support -arrows-.
Pa
ge 16 of 35 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE06.17.1

17-19


Note:
The subframe should be disconnected and lowered at the front only,
otherwise it will be necessary to check the wheel alignment.
Vehicles with manual transmission - Remove front subframe bolts -2- and -3- (left and right) and loosen
bolts -1-.

- Loosen nut -arrow- on left transmission mounting until it is flush with
end of bolt (approx. four turns on the thread).
Pa
ge 19 of 35 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE06.17.1

17-22

Note:

Unscrew both rear oil pan bolts -1- and -2- with attachment 3249. Turn the
flywheel on vehicles with a manual transmission -3- until the notch -arrow-
is aligned with the bolt.
- Take off oil pan. If necessary loosen it by striking lightly with a rubber
hammer.
- Carefully remove sealant residues from cylinder block (remove baffle
plate).

WARNING!
Wear protective glasses. - Remove remaining sealant from oil pan, e.g. with a rotating plastic
brush.
- Clean sealing surfaces: they must be free of oil and grease.
Pa
ge 22 of 35 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE06.17.1

17-26


Repair Manual, Suspension, Wheels, Steering, Repair Group 40

Vehicles with automatic transmission:
Repair Manual, 5 Spd. Automatic Transmission 01V, Repair Group 37

All models:
Vehicles with automatic transmission:
Repair Manual, 5 Spd. Automatic Transmission 01V, Repair Group 37 - Support subframe with workshop crane VAG 1202 A.
- Installing subframe:
- Secure ATF lines.- Install lock carrier Page 13
-1 .
- Fill engine with oil and check oil level.
- Check ATF level:
Pa
ge 26 of 35 Lubrication s
ystem com
ponents, removin
g and installin
g
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE06.17.1