air filter AUDI A4 2000 B5 / 1.G Engine Oil Level Checking Workshop Manual
Page 3 of 111
12
Engine oil, oil filter; replacing
Notes:
Replace oil drain plug seal.
Use VAG 1307 or 1358 to extract engine oil. For
rapid extration of oil on V6 engines use probe
VAG 1358A/4.
Please observe waste disposal requirements!
Do not clean and re-use oil fiter!
Tightening torque of oil drain plug: 40 Nm (30 ft
lb).
Engine oil capacity (with filter change)
1.8 liter 5V turbo: 3.5 liter (3.7 qt)
2.7 liter V6 5V turbo: 6.0 liter (6.3 qt.)
2.8 liter V6 5V: 5.7 liter (6.0 qt.)
Procedure
- Loosen oil filter with tensioning strap (e.g. Hazet
2171-1 or equivalent) and remove.
Pa
ge 3 of 111 Descri
ption of wor
k
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.ME01.01.6
Page 4 of 111
- Clean sealing surface on engine.
- Lightly oil rubber seal.
- Thread on new filter and tighten by hand.
Pa
ge 4 of 111 Descri
ption of wor
k
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.ME01.01.6
Page 11 of 111
17
Dust and pollen filter element, replacing
- Remove right scuttle panel.
Notes:
Be sure dust and pollen filter housing gasket -C- is positioned correctly
and undamaged.
Rain channel -A- must be properly installed to prevent water from running
onto dust and pollen filter and into heating system. - Remove rain channel -A-.
- Remove filter element -B- from housing.
- Install new filter element.
- Install gasket-C-, rain channel -A-, and right scuttle panel.
Pa
ge 11 of 111 Descri
ption of wor
k
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.ME01.01.6
Page 31 of 111
36
Manual transmission/final drive oil level,
checking
5-speed manual transmission 012/01W
Special tools and equipment
Key 3357, or
Hex key socket attachment, 17 mm AF
Note:
The vehicle must be absolutely horizontal when
checking transmission oil level. This work is
best performed over an inspection pit or using a
four column lifting platform.
The prescribed oil level is to be adhered to
exactly; the transmission reacts very sensitively
to over-filling.
The oil filter plug is on the left of the
transmission below the speedometer sender; it
may be concealed by the heat shield for the
drive shaft.
Depending on the version installed, use either special tool 3357 or a
17 mm hex socket key to loosen the oil filter plug.
Pa
ge 31 of 111 Descri
ption of wor
k
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.ME01.01.6