air condition AUDI A6 1999 C5 / 2.G AEB ATW Engines Lubrication System Components Workshop Manual
Page 28 of 33
for more than 0.5 seconds at engine speeds
greater than 1500 RPM. If condition occurs
more than three times during a drive,
warning will remain active even at engine
speeds less than 1300 RPM.
Pa
ge 28 of 33 Lubrication s
ystem com
ponents, removin
g and installin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE02.17.1
Page 29 of 33
17-23
Special tools and equipment
VAG1342 oil pressure tester
VAG1527B voltage tester
VAG1594A measuring appliance adapter
Test conditions
Oil level OK
Oil pressure warning light -K3- must light up
when ignition is switched on.
For vehicles with Auto Check system, "i.O"
indicator must be lit (call up symbol)
Engine oil temperature approximately 80 C
(176 F)
Pa
ge 29 of 33 Lubrication s
ystem com
ponents, removin
g and installin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE02.17.1
Page 33 of 33
17-27
Oil level, checking
Test conditions
Minimum engine oil temperature: 60 C
(140 F)
Vehicle on level ground
After stopping engine, wait a few minutes to
allow oil to flow back into oil pan
- Withdraw dipstick, wipe off using clean cloth and
reinsert fully.
- Withdraw dipstick again and read oil level.
Range of markings on dipstick:
CAUTION!
Do not overfill with oil past the MAX mark on the oil dipstick.
Damage to the Three Way Catalytic Converter (TWC) could result. a - Oil MUST NOT be topped off.
b - Oil may be topped off. After topping off, oil may reach range -a-.
c - Oil MUST BE topped off. After topping off, it is sufficient if oil level is
somewhere in range -b- (shaded area).
Pa
ge 33 of 33 Lubrication s
ystem com
ponents, removin
g and installin
g
11/18/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE02.17.1