sensor AUDI A8 1997 D2 / 1.G 01V Transmission Front Final Drive Service Workshop Manual
Page 4 of 37
39-8
23 -
Seal
For left drive flangeAlways replace page 39
-13
24 -
Drive gear
For Speedometer Vehicle Speed Sensor
(VSS) -G22- Installed position page 39
-20
25 -
Left drive flange
Removing and installing page 39
-13
26 -
Mounting bracket for drive flange
27 -
Grooved ball bearing for drive flange
Always replace page 39
-13
28 -
Snap ring
29 -
O-ring
Square cross sectionRemove and install left drive flange to
replace page 39
-13
Pa
ge 4 of 37 Front final drive, servicin
g
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.AT01.39.2
Page 11 of 37
39-15
Remove left drive flange
- Loosen bolt drive axle/wheel hub while the
vehicle is still standing on its wheels.
- Remove wheel.
- Removing left drive axle:
Repair Manual, Suspension, Wheels,
Steering, Repair Group 40; Drive axle, removing and installing
- Place VAG1306 drip tray underneath.
Note:
Oil must be syphoned from final drive, otherwise there is a risk that the
gear oil could mix with the ATF. - Remove oil filler plug (arrow) and syphon off at least 0.5 L gear oil from
final drive using VAG1358A.
- Remove heat shield for left drive axle.
- Remove Speedometer Vehicle Speed Sensor (VSS) page 38
-35
.
-
Remove harness connector bracket from mounting bracket for drive
Pa
ge 11 of 37 Front final drive, servicin
g
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.AT01.39.2
Page 17 of 37
39-20
Installing seal
- Coat outer edge and sealing lip of oil seal with
gear oil.
- Drive in new seal to stop, without canting.
Installation position: The open side of the seal faces the
transmission.
Note:
If necessary, coat contact surface with grease to affix drive wheel in
installation position. - Set Speedometer Vehicle Speed Sensor (VSS) -G22- on drive flange
(arrow).
Installation position: The carriers at drive wheel must engage in
grooves of drive flange
Pa
ge 17 of 37 Front final drive, servicin
g
11/20/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.AT01.39.2