phone BMW 318is 1998 E36 Electrical Troubleshooting Manual




DATA LINK
DATA LINK CONNECTOR, PINS 12 AND 14
 $%%




%%&



D+
12 X6002
D100
DATA LINK
CONNECTOR25 X20
.75 BL
A2w
INSTRUMENT
CLUSTER 6 X17
3 X13305
X213
14 X6002
D100
DATA LINK
CONNECTOR G6509
GENERATOR
2.5 RT
.5 BL 1.5 BL
.35 BL .5 BL.5 BL
G1
BATTERY
POWER
DISTRIBUTION
0670.2
POWER
DISTRIBUTION
0670.2
X8004
BR
X6410
14 X6002
D100
DATA LINK
CONNECTORX6430
G6430
B+ JUMP START
JUNCTION POINT
X6411
ENGINE CONTROL
SYSTEM MS41.1
(6–CYLINDER M52)
1210.17
M3, 328i, 323i 318is
TELEPHONE
CONNECTOR
CENTER CONSOLE6 RT
2.5 RT
X6412
4 RT
X7509

10 RT

 $%%



%%&



1230.0 CHARGING SYSTEM
1.5 BLG6509
GENERATOR
31
3131
B+
D+
A2w
INSTRUMENT
CLUSTER X175
X176
S2
IGNITION SWITCH
0) OFF
1) ACCESSORY
2) RUN
3) START
X2091
7 X33
POWER
DISTRIBUTION
0670.2X203
2.5 GN
2.5 GN
.5 GN
X8004.75 BL
X6002
12 D100
DATA LINK
CONNECTOR
.5 BL
X133053
16 RT
X6509
X7509
2
10
3
15
.5 BL
X213
30h
G1
BATTERY
X497
G6430
X6512
POWER
DISTRIBUTION
0670.2POWER
DISTRIBUTION
0670.2 25 RT
M6510
STARTER
BR
31
.35 BL.5 BL
TELEPHONE
CONNECTOR
X2025
CENTER CONSOLE
318is



CONVERTIBLECONVERTIBLE
12
X1260
12
23




6510.0 RADIO/STEREO
STEREO, 6–SPEAKER SYSTEM
 $%%



%%&



N9
RADIO
H59
LEFT FRONT HIGH
RANGE SPEAKER 1
16
H58
LEFT FRONT LOW
RANGE SPEAKER
815 FUSE DETAILS
0670.3
11X876
X753
X826
X1381
P90
FRONT POWER
DISTRIBUTION
BOX
H45
RIGHT REAR
SPEAKER 23
2
16
H50
RIGHT FRONT
HIGH RANGE
SPEAKERH51
RIGHT FRONT LOW
RANGE SPEAKER 11
2311 X827
X746
X877
X700
H46
LEFT REAR
SPEAKER 23
A2w
INSTRUMENT
CLUSTER
2) VEHICLE SPEED
OUTPUT 2 X17
X188
3
10 X181263
1213
LIGHT SWITCH
DETAILS
6300.0
INSTRUMENT
CLUSTER
6211.0
614
18 X10015
1 GR/RT
9.5 GR/RT58g
.75 GE/BR
.75 GE/RT
.75 GE/RT
.5 GE/RT .75 GE/RT
X701
.75 GE/BR
.75 GE/BR
.5 GE/BRX18196
X1002
.75 GE/VI .75 GE/GR.75 BL/SW
.75 BL/SW
.5 BL/SW.75 BL/BR
.75 BL/BR
.5 BL/BRX18198
.75 BL/SW .75 BL/BR
X1380
.75 BL/VI .75 BL/GR .5 SW/WS
X322
.5 SW/WS
.5 SW/WS
2
1 X424.5 WS16
4 X18126
.5 WS/BR
N8
ANTENNA
AMPLIFIER AM/FM
F920AF4415A
1 5X322
31
X13016
4
1.5 RT/WS
FUSE DETAILS
0670.3 28 X10018
52
1.5 VI/WS
6 X400
7 X14
.35 WS/BR.5 WS/BR .35 GE
MUTE 7
.35 GE
6
I-BUS
24 X14
TELEPHONE
CONNECTOR
LUGGAGE
COMPARTMENT
X557.35 WS/BR .35 WS/BR
.35 GECELLULAR TELEPHONE
(PROVISIONS)
6561.0
GROUND
DISTRIBUTION
0670.4
X18723
X1001
X1261
CONVERTIBLE
3X1892
N22
CD CHANGER




6510.1 RADIO/HIFI/TOP HIFI $%%


%%&



F3310AP90
FRONT POWER
DISTRIBUTION BOX F4415A

A2w
INSTRUMENT
CLUSTER
2) VEHICLE
SPEED
OUTPUT 2X17
X188
3
10CELLULAR TELE-
PHONE (PROVI-
SIONS)
6561.0
INSTRUMENT
CLUSTER
6211.0
628 X10018
.5 SW/WS
X322
.5 SW/WS
.5 SW/WS
N9
RADIO 59
16
X830
15
GROUND
DISTRIBUTION
0670.42
2 X1892
1 X1892
161
.75 GE/RT1523
32
6 X18126
8 17
1211 14
14 X18126
2X606
FUSE DETAILS
0670.3
.5 WS
N9
RADIOA18
HIFI AMPLIFIER
.75 BL/RT .75 GE/SW .75 BL/SW
.75 BR/OR .75 BR/OR .75 BR/OR .75 BR/OR
LV–LH–RV–RH– N22
CD CHANGER
LV+ RV+ LH+ RH+
.5 WSANT
ANT
.5 WSX18126
31
F9 20A

18X10015
1
.5 WS/BR
4
1 X605
FUSE DETAILS
0670.3FUSE DETAILS
0670.3
41 X606
6X400
X14 .5 WS/BR
1.5 VI/WS
2
MUTE
1 X424N8
ANTENNA
AMPLIFIER AM/FM
GROUND
DISTRIBUTION
0670.4
3 X605
1.5 RT/WS
2.5 RT/WS
GROUND
DISTRIBUTION
0670.4
.35 GE
.35 GE
3X14
24
CONVERTIBLE30 I-BUS R
31 TACHO7
.35 GE .35 GE
4 X322
13
5
LIGHT SWITCH
DETAILS
6300.058g
58gTELEPHONE CONNECTOR

LUGGAGE COMPARTMENT

X557
.35 WS/BR
X322X19513
1.5 RT/WS
6 1 GR/RT
.5 GR/RT
.35 WS/BR .35 WS/BR 7
X18723CONVERTIBLE
WITH TOP HIFIX18723CONVERTIBLE
WITH TOP HIFI
X13006X13016X13016





PROVISIONS
 $%%
 

%%&



6561.0 CELLULAR TELEPHONE (PROVISIONS)
1
X133055
6
FUSE DETAILS
0670.3
X133052
X10012
GROUND
DISTRIBUTION
0670.4
P90
FRONT POWER
DISTRIBUTION BOX
X1001826
FUSE DETAILS
0670.3
F3310AF435A
X3221
X181264
N9
RADIO
TELEPHONE CONNECTOR
MUTE
1 X4005
6
FUSE DETAILS
0670.3
P90
FRONT POWER
DISTRIBUTION BOX
X1001826
FUSE DETAILS
0670.3
F3310AF435A
6
TELEPHONE CONNECTOR
.5 BL25
2
X13006
GROUND
DISTRIBUTION
0670.4
7
63X213X400
6X17X7509
X600212
X557
.5 WS/BRA2w
INSTRUMENT
CLUSTER G6509
GENERATOR
.5 BL .5 BL 1.5 BL
X8004
.75 BL D+
.35 WS/BR
.35 WS/BR .5 WS/BR
.35 WS/BRD100
DATA LINK
CONNECTOR X20
.35 BL
X14
CENTER CONSOLE LUGGAGE COMPARTMENT
CDN




 $%%


%%&



P90
FRONT POWER
DISTRIBUTION BOX
N12w
ANTI–THEFT
CONTROL MODULE
(ALPINE) FUSE DETAILS
0670.3
F435A
2X13025
311
S61y
LUGGAGE COMPARTMENT
LIGHT SWITCH
1) TRUNK CLOSED
2) TRUNK OPEN1 X711
X465
LOW–NOISE MI-
CROPHONE
.75 BR/WS
9
A104
BODY
ELECTRONICS
CONTROL MODULE
(ZKE IV) 17.5 BL/RT/GE10 X13025
4 X13253
.5 WS/RT/GE
VI VI
SW SW
LED
X13009
GROUND
DISTRIBUTION
0670.4
6575.2 ANTI–THEFT SYSTEM (ALPINE)
ANTENNA
.5 BR/WS
8
2 X65
.5 BL/GN/GE
14 X14
N17
CRASH CONTROL
MODULE .5 BL/GN/GE
12
.5 BR/RT/GE
.5 BR/RT/GE
A104
BODY
ELECTRONICS
CONTROL MODULE
(ZKE IV)
1 X13254
S48
DRIVER’S DOOR
HANDLE SWITCH
1) HANDLE DOWN
2) HANDLE
LIFTED 2 X752
1X752
.5 BR/RT/GE
1 2
1 2LICENSE PLATE/
LUGGAGE
COMPARTMENT
LIGHTS
6320.03131
X495
GROUND
DISTRIBUTION
0670.4
19 X475X257
.5 BR/RT/GE
USA
X13168X450
.5 BL/RT/GE .5 WS/RT/GE
DRIVE–AW AY
PROTECTION
(EWS II)
6135.0.5 BL/RT/GE
26 X10018




COMPONENT LOCATION CHART
;






 $%%%%&
COMP.8500.0 7100.0LOCATION DESCRIPTION
X18723 GROUND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . below LH side of dash

X18741
(4 PINS, –––) . . . . . . . . . . . . . . . . . . . . . . . . . . .
center of dash MICROPHONE



X18797 (1 PIN, NATURAL) . . . . . . . . . . . . . . . . . . . . . . in RH rear side of luggage compartment
X18798 (1 PIN, NATURAL) . . . . . . . . . . . . . . . . . . . . . . in RH rear side of luggage compartment
X18994 (3 PINS, YELLOW) . . . . . . . . . . . . . . . . . . . . . . rear LH side of engine compartment below . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 01-1
X19527 (16 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . below LH side of dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 08-3
X19561
(6 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . .
on RH side of transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .


05-3
X62001 (4 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . . under center of car (318is) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37-1 07-2
X62002 (4 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . . under center of car (318is) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37-2 07-2
X62101 (4 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . . top center of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-3 07-2
X62102 (4 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . . under center of car on catalytic converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 07-2
X62201

(4 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . .

top center of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

15-3

07-2
X62202 (4 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . . under center of car on catalytic converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 07-2
X90260 (3 PINS, NATURAL) . . . . . . . . . . . . . . . . . . . . . RH side of steering column . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 04-3 01-1
X91009 (2 PINS, BLACK) . . . . . . . . . . . . . . . . . . . . . . . . under passenger’s seat

Y1 . . . .
ABS HYDRAULIC UNIT . . . . . . . . . . . . . . . . . .
rear LH side of engine compartment back of LH side shock tower . . . . . . . . . . . . . . .
16-2

Y1w . . ABS HYDRAULIC UNIT . . . . . . . . . . . . . . . . . . LH side of engine compartment
Y2 . . . . AIR CONDITIONING COMPRESSOR . . . . . front of engine
Y4 . . . . WATER VALVE ASSEMBLY . . . . . . . . . . . . . . rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-2
Y5 . . . . DRIVER’S SIDE MIRROR . . . . . . . . . . . . . . . . in upper LH front door

Y6 . . . .

PASSENGER’S SIDE MIRROR . . . . . . . . . . .

in upper RH front door




Y19 . . SHIFT–LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . center console RH side of gearshift selector