engine light BMW 318ti 1998 E36 Electrical Troubleshooting Manual




 !
Pin Assignments


 

E = Input, A = Output, M = Ground
X17
Pin Type Description/Function Connection
1
ETrailer turn signal indicator controlHazard flasher relay
2AVehicle speed signalVarious control modules
3MGround supply, terminal 31 for indicator and
warning lampsGround point
4EVoltage supply, terminal 15 for instrument
cluster electronicsFront power distribution box, fuse 23
5EVoltage supply, terminal 15 for battery
charge indicatorIgnition switch, terminal 15
6EGround supply, terminal 61 for battery
charge indicatorGenerator
7Not used
8EFog light indicator controlFront power distribution box, fuse 15
9ASound tone signalChime module
10Not used
11Not used
12EASC signalASC control module
13ATI-measurement signal (fuel consumption)Engine control module (DME)
14ESeat belt warning lamp controlDriver’s seat belt switch
15ES/A reset/service interval indicator resetData link connector
16EVoltage supply, terminal RFront power distibution box, fuse 46
17ACoolant temperature sensor (–)Coolant temperature sensor
18ECoolant temperature sensor (+)Coolant temperature sensor
19EOil pressure warning lamp controlOil pressure switch
20Not used
21EABS warning lamp (ABS)ABS control module/hydraulic unit/Slip
control module (ABS/ASC)
22EIgnition key warning/Audible ignition key
warningIgnition switch
23EDriver’s door openDriver’s door jamb switch
24Not used



 !
K4
BLOWER RELAY
F2030A F397.5A
5B9y
PRESSURE
SWITCHS36y
DOUBLE
TEMPERATURE
SWITCHK21
NORMAL SPEED
RELAY
B8y
PRESSURE
SWITCHA6000
ENGINE CONTROL
MODULE (DME)
B9508
PRESSURE
SWITCH
X11250
A107
INTEGRATED
HEATING– AND
CLIMATE CONTROL
MODULE
.0
F235AF165A
S2
IGNITION SWITCH
M30
BLOWER MOTOR R11
BLOWER
RESISTORS K19
COMPRESSOR
CONTROL RELAY
Y2
AIR CONDITIONING
COMPRESSORA8500
TRANSMISSION
CONTROL MODULE
(EGS)
A6000
ENGINE CONTROL
MODULE (DME)
Y4z
WATER VALVE
S531
TEMPERATURE
WHEEL SWITCHM111
FRESH AIR
RECIRCULATION
MOTOR4X13274
S530
IHKS CONTROL
SWITCHF16
5AF4840A
K22
HIGH SPEED
RELAY
E103
CLIMATE CONTROL
SWITCH
ILLUMINATION 58g
LIGHT SWITCH
DETAILS
6300.0P97
AUXILIARY FUSE
BOX
6450.6-00
6450.6-00
6450.6-006450.6-00
6450.6-01
6450.6-016450.6-016450.6-026450.6-02
6450.6-026450.6-02
6450.6-01
6450.6-006450.6-03
6450.6-03
6450.6-03 6450.6-03
6450.6-03P90
FRONT POWER
DISTRIBUTION BOX
M9
AUXILIARY FAN
MOTOR 6450.6-03
F165A
P90
FRONT POWER
DISTRIBUTION BOXP90
FRONT POWER
DISTRIBUTION BOX
B14
EVAPORATOR
TEMPERATURE
SENSOR
6
6450.6-012S75
BLOWER SWITCH 6450.6-00
6
A6000
ENGINE CONTROL
MODULE (DME) 6450.6-01
41
107
K13
REAR DEFOGGER
RELAY 6450.6-01
3
X11250
9 X132741 8
A6000
ENGINE CONTROL
MODULE (DME) 6450.6-03
6450.6-01
6450.6-03
6450.6 INTEGRATED HEATING– AND CLIMATE CONTROL



 !
Pin Assignments

 

E = Input, A = Output, M = Ground X11250
6-Pins, black
X1327410-Pins, black
X11250
Pin Type Description/Function Connection
1
EAir recirculation signalBlower switch
2MGroundGround point
3EFunction signalIHKS switch, Engine control module (DME)
4EAir recirculation signalBlower switch
5EPressure signalPressure switch
6EEvaporative temperatureEvaporative temperature sensor
X13274
Pin Type Description/Function Connection
1
MGroundGround point
2Not used
3Not used
4EAir circulation signalBlower switch
5Not used
6ETerminal 58gLight switch
7ETerminal 15Front power distribution box, fuse 23
8AAir recirculation signalFresh air recirculation motor
9AFunction signalIHKS-control module, Engine control
module (DME)
10ARear defogger signalRear window defogger relay

31




!


F235A
6 58g
6 1 X85
1
X10234
X853
X35
3
2
4
X771
2
FUSE DETAILS
0670.3
.5 GE/BR
.5 GE/BR
A107
INTEGRATED
HEATING– AND
CLIMATE CONTROL
MODULE P90
FRONT POWER
DISTRIBUTION BOX
M111
FRESH AIR
RECIRCULATION
MOTORK13
REAR DEFOGGER
RELAY
S531
TEMPERATURE
WHEEL SWITCH
0) NORMAL
TEMPERATURE
1) MAXIMUM
TEMPERATURE
.5 GE
4 X35
LIGHT SWITCH
DETAILS
6300.0
GROUND
DISTRIBUTION
0670.4FUSE DETAILS
0670.3
S530
IHKS CONTROL
SWITCH
0) OFF
1) REAR DEFOGGER
2) A/C
3) RECIRCULATIONGROUND
DISTRIBUTION
0670.4GROUND
DISTRIBUTION
0670.4B14
EVAPORATOR
TEMPERATURE
SENSOR
GROUND DISTRIBUTION
0670.4GROUND
DISTRIBUTION
0670.4 A6000
ENGINE CONTROL
MODULE (DME)X11250
X11250
1 GN/GR .5 GN/RT .5 GN/RT .35 GR/RT .5 GN/RT
X10233
X13274
1
X771
Y4z
WATER VALVE
14 3X13279
X132749
1
.35 VI/GR
.35 VI/GR 8 7
10 4 .35 GR/GE8
2
X1517
X151731.5 BL/SW4 X292
X10234
X100176
.5 RT/GE
.35 VI/GR
.5 VI/GR6 X35
6X20
.5 VI/GR
69 X6000
X35
X292
85 86 FUSE DETAILS
0670.3
7
X10012
.35 GR
X10012
030301010202
01
.5 GN/BL

X78WITH EGS




!



6571.0 CRUISE CONTROL (TEMPOMAT)
FUSE DETAILS
0670.3 X10017
16
5 X511
P90
FRONT POWER
DISTRIBUTION BOX F28
5A
ELECTRONIC
TRANSMISSION
CONTROL
(EGS A4S 270R)
2460.2
.5 BR/SW
F4615A
X10018
32
.5 VI/GE X511
7
 " 1 

'
 
 +
 1 
" 
 
5S3
AUTOMATIC
TRANSMISSION
RANGE SWITCH
0) OFF (LOW)
1) ON (HIGH)
3126
31
X191
.35 BR/SW1 X72
S28
CRUISE CONTROL
SWITCH
0) NORMAL
1) OFF
2) RESUME
3) DECELERATE/SET
4) ACCELERATE/SET
24
31
3
18
312
9
314 X72
20
X22
31
A8
CRUISE CONTROL
MODULE
(TEMPOMAT) .35 BL/WS .35 BL/GN .35 BL/GR.5 VI/GE
.35 BL/SW FUSE DETAILS
0670.3
468
5 EGS A4S 270R
 

1
1 2
2
15S29
BRAKE LIGHT SWITCH
1) NORMAL STATE
2) BRAKE PEDAL
DEPRESSED
BRAKE LIGHTS
6325.0
X116
X116
.35 BL/RT 1.5 BL/RT1.5 VI/GE
X181
L1L2L3L4
01010101
4 3
01 2
01 2
0
31
20
8X16
.35 SW.5 SW
X1047
31A2w
INSTRUMENT
CLUSTER
TD
ENGINE CONTROL
SYSTEM (DME M5.2,
4–CYLINDER M44)
1210.20
X78
S30
BRAKE LIGHT
SWITCH
1) BRAKE PEDAL
RELEASED
2) BRAKE PEDAL
DEPRESSED
WITHOUT EGS

6581.3 BOARD COMPUTER (BC – LOW)

!



B21
ON–BOARD
COMPUTER
TEMPERATURE
SENSOR
31 30
31 31 31
.35 BR/GR
P90
FRONT POWER
DISTRIBUTION BOX
232 X10018
FUSE DETAILS
0670.3
510
911
LIGHT SWITCH
DETAILS
6300.0
X10245
86 X10245
X10010
1 X770
2 X770
GROUND
DISTRIBUTION
0670.4
X10010GROUND
DISTRIBUTION
0670.4
58g
FUSE DETAILS
0670.3
 

.35 WS/VI2.35 WS/GE3
B25y
FUEL TANK
SENSOR II .5 BR/GE7
2 X679
1 X679
15
.5 SW/WS2
X188
INSTRUMENT
CLUSTER
6211.0
X11291
1 X13
B6
FUEL LEVEL
SENSOR 2 X1241
1 X1241
.5 GE15
31
3 X271
.5 BR/SW
.5 BR/GE
1 X271
15
.35 BR/RT1
10 X32
1 X32
X173
GROUND
DISTRIBUTION
0670.4
A2w
INSTRUMENT
CLUSTER
2) VEHICLE
SPEED
OUTPUT 2
X17
.35 SW/WS
.35 GR/RT
A35y
BOARD
COMPUTER
(BC – LOW)
S7
COMBINATION
SWITCH
10) PROGRAM
MODUS 10TXD RXD
DATA LINK
0670.5.5 BR/GE
.5 BR/GE
A2w
INSTRUMENT
CLUSTER
.5 BR/SW.5 BR/SW
X805
INSTRUMENT
CLUSTER
6211.0
31415
.5 WS/SWA6000
ENGINE CONTROL
MODULE (DME)
X6000
24X20
.35 WS/SW
31
F315AF4615A
83
.35 BR/RT
.35 BR




COMPONENT LOCATION CHART
:





 !
 

COMP.8500.0 7100.0LOCATION DESCRIPTION

A836 .
ELECTRONIC IMMOBILIZER
CONTROL MODULE (EWS II) . . . . . .
under glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

01-2


A6000 ENGINE CONTROL MODULE (DME) . . rear RH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 00-1



A8500



TRANSMISSION CONTROL MODULE
(EGS) . . . . . . . . . . . . . . . . . . . . . . . . . . .


rear RH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .


00-1





B1 . . . .

RIGHT FRONT SPEED SENSOR –
ABS . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
on RH front wheel, above brake caliper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

06-3


B2 . . . . LEFT FRONT SPEED SENSOR – ABS on LH front wheel, above brake caliper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 06-3
B3 . . . . RIGHT REAR SPEED SENSOR – ABS on RH rear wheel, above brake caliper
B4 . . . . LEFT REAR SPEED SENSOR – ABS . on LH rear wheel, above brake caliper

B6 . . . .

FUEL LEVEL SENSOR . . . . . . . . . . . . . .

below LH side of rear seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

13-1


B8y . . . PRESSURE SWITCH . . . . . . . . . . . . . . . . near RH headlight assembly
B9 . . . . INTERMEDIATE PRESSURE SWITCH near RH headlight assembly

B10 . .
VEHICLE SPEED SENSOR . . . . . . . . . .
on differential . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
26-1



B14 . .

EVAPORATOR TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . .
RH side of LH footwell . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

17-1


B16 . . LEFT FRONT BRAKE PAD SENSOR . . on LH front wheel, above brake caliper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 06-3
B17 . . RIGHT REAR BRAKE PAD SENSOR . . behind RH rear wheel

B18 . .
BRAKE FLUID LEVEL SWITCH . . . . . . .
rear LH side of engine compartment top of brake fluid reservoir . . . . . . . . .
09-2



B21 . .

ON–BOARD COMPUTER
TEMPERATURE SENSOR . . . . . . . . .
in the engine compartment lower LH side of engine compartment . . . . . . .
14-1

B25y . FUEL TANK SENSOR II . . . . . . . . . . . . . below RH side of rear seat




COMPONENT LOCATION CHART
:





 !
 

COMP.8500.0 7100.0LOCATION DESCRIPTION
B72 . . FUEL TANK PRESSURE SENSOR . . . RH rear wheel well, behind trim panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29-1

B78 . .

DRIVER’S SIDE IMPACT SENSOR . . .

LH B–pillar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

29-3




B79 . .

PASSENGER’S SIDE IMPACT
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . .
RH B–pillar






B6203

CRANKSHAFT POSITION/RPM
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . .
under RH front of car rear of radiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

08-1


B6205 INTAKE AIR TEMPERATURE SENSOR LH side of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 09-3
B6209 HALL EFFECT CAMSHAFT SENSOR . front of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-2

B6217

HOT FILM AIR MASS METER . . . . . . . .

top front of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

09-3


B6231 OIL PRESSURE SWITCH . . . . . . . . . . . . LH front of engine below intake manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-1


B6232

ENGINE COOLANT TEMPERATURE
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . .
behind RH fresh air cowl below intake manifold . . . . . . . . . . . . . . . . . . . . . . .

28-1


B6240 KNOCK SENSOR . . . . . . . . . . . . . . . . . . . top front of engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26-2

B9508
PRESSURE SWITCH . . . . . . . . . . . . . . . .
near RH headlight assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
08-3



B62001

OXYGEN SENSOR (IN FRONT OF
CATALYTIC CONVERTER) . . . . . . . . .
under center of car . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

25-1




B62002

OXYGEN SENSOR (BEHIND
CATALYTIC CONVERTER) . . . . . . . . .
under center of car . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

26-3


C101 . CONTACT RING . . . . . . . . . . . . . . . . . . . . top of steering column . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-1
D100 . DATA LINK CONNECTOR . . . . . . . . . . . rear LH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 09-2

D110 .
OBD II CONNECTOR . . . . . . . . . . . . . . . .
center console right . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
24-3

E7 . . . . LEFT HEADLIGHT . . . . . . . . . . . . . . . . . . front LH side of engine compartment




COMPONENT LOCATION CHART
:





 !
 

COMP.8500.0 7100.0LOCATION DESCRIPTION
E8 . . . . RIGHT HEADLIGHT . . . . . . . . . . . . . . . . . front RH side of engine compartment

E9 . . . .

REAR DEFOGGER I . . . . . . . . . . . . . . . .

on lift gate




E11 . . . LEFT HIGH BEAM LIGHT . . . . . . . . . . . . near LH headlight assembly
E12 . . RIGHT HIGH BEAM LIGHT . . . . . . . . . . near RH headlight assembly

E13 . .
LEFT LOW BEAM LIGHT . . . . . . . . . . . .
near LH headlight assembly



E14 . .

RIGHT LOW BEAM LIGHT . . . . . . . . . . .

near RH headlight assembly




E15 . . LEFT PARK LIGHT . . . . . . . . . . . . . . . . . . front of vehicle
E19 . . RIGHT PARK LIGHT . . . . . . . . . . . . . . . . front of vehicle

E26 . .
LEFT FOG LIGHT . . . . . . . . . . . . . . . . . . .
under LH front bumper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
06-2

E27 . . RIGHT FOG LIGHT . . . . . . . . . . . . . . . . . under RH front bumper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 06-2
E28 . . FRONT CIGAR LIGHTER . . . . . . . . . . . . center console
E29 . . FRONT CIGAR LIGHTER LIGHT . . . . . center console

E32z .

REAR CENTER INTERIOR LIGHT . . . .

in roof panel






E34 . .

FRONT DOME LIGHT/MAP READING
ASSEMBLY . . . . . . . . . . . . . . . . . . . . . .
in roof panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

00-3


E35 . . DRIVER’S MAKE–UP MIRROR LIGHT in sun visor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-1

E36 . .
PASSENGER’S MAKE–UP MIRROR
LIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . .
in sun visor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

15-1


E42 . . GLOVE BOX LIGHT . . . . . . . . . . . . . . . . . RH side of glove box

E43 . .

LEFT LICENSE PLATE LIGHT . . . . . . . .

underside of luggage compartment lid, near license plate . . . . . . . . . . . . . .

07-1


E44 . . RIGHT LICENSE PLATE LIGHT . . . . . . underside of luggage compartment lid, near license plate . . . . . . . . . . . . . . 07-1




COMPONENT LOCATION CHART
:





 !
 

COMP.8500.0 7100.0LOCATION DESCRIPTION

E46 . .
LEFT LUGGAGE COMPARTMENT
LIGHT ASSEMBLY . . . . . . . . . . . . . . . .
in LH rear side of luggage compartment





E47 . .
RIGHT LUGGAGE COMPARTMENT
LIGHT ASSEMBLY . . . . . . . . . . . . . . . .
in RH rear side of luggage compartment





E51 . .
LEFT WASHER JET HEATER . . . . . . . .
on underside of engine hood



E52 . . RIGHT WASHER JET HEATER . . . . . . . on underside of engine hood
E56 . . DRIVER’S SEATBACK HEATER . . . . . . in upper LH front seatback
E57 . . DRIVER’S SEAT HEATER . . . . . . . . . . . under LH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30-3

E58 . .

PASSENGER’S SEAT HEATER . . . . . . .

underside of RH front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

30-3


E59 . . PASSENGER’S SEATBACK HEATER . in upper RH front seatback
E61 . . LEFT FRONT FOOTWELL LIGHT . . . . . LH footwell . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-3

E62 . .
RIGHT FRONT FOOTWELL LIGHT . . .
right footwell





E82 . .

TRANSMISSION POSITION
INDICATOR LIGHT . . . . . . . . . . . . . . . .
center console



E97 . . LIGHT SWITCH ILLUMINATION . . . . . . LH side of dash
E98 . . FOG LIGHT SWITCH ILLUMINATION . center of dash

E103 .
CLIMATE CONTROL SWITCH
ILLUMINATION . . . . . . . . . . . . . . . . . . .
center console





F97 . . .
FUSIBLE LINK . . . . . . . . . . . . . . . . . . . . . .
rear of engine compartment



G1 . . . BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . rear RH side of engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-3
G5 . . . DRIVER’S AIR BAG GAS GENERATOR behind steering wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-1