warning CHEVROLET CAVALIER 2005 3.G Service Manual

Page 286 of 354

Appearance Care
Cleaning products can be hazardous. Some are toxic.
Other cleaning products can burst into ames if a match
is struck near them or if they get on a hot part of the
vehicle. Some are dangerous if their fumes are inhaled
in a closed space. When anything from a container
is used to clean the vehicle, be sure to follow the
manufacturer’s warnings and instructions. Always open
the doors or windows of the vehicle when cleaning
the inside.
Never use these to clean the vehicle:
Gasoline
Benzene
Naphtha
Carbon Tetrachloride
Acetone
Paint Thinner
Turpentine
Lacquer Thinner
Nail Polish Remover
They can all be hazardous — some more than
others — and they can all damage the vehicle, too.Do not use any of these products unless this manual
says you can. In many uses, these will damage
the vehicle:
Alcohol
Laundry Soap
Bleach
Reducing Agents
Fabric/Carpet
Use a vacuum cleaner often to get rid of dust and loose
dirt. Wipe vinyl, leather, plastic, and painted surfaces
with a clean, damp cloth.
GM-approved cleaning products can be obtained from
your dealer.
Here are some cleaning tips:
Always read the instructions on the cleaner label.
Clean up stains as soon as you can before they set.
Carefully scrape off any excess stain.
Use a clean cloth or sponge, and change to a clean
area often. A soft brush may be used if stains are
stubborn.
To avoid forming a ring on fabric after spot cleaning,
clean the entire area immediately or it will set.
5-72

Page 341 of 354

A
Accessory Power Outlets.................................3-16
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-80
Air Cleaner/Filter, Engine.................................5-17
Air Conditioning..............................................3-18
Airbag
Readiness Light..........................................3-24
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
Airbag System................................................1-46
How Does an Airbag Restrain?......................1-52
Servicing Your Airbag-Equipped Vehicle..........1-55
What Makes an Airbag Inate?......................1-52
What Will You See After an Airbag Inates?........1-53
When Should an Airbag Inate?....................1-51
Where Are the Airbags?...............................1-49
AM-FM Radio.................................................3-37
Antenna, Fixed Mast.......................................3-71
Antenna, XM™ Satellite Radio
Antenna System..........................................3-71
Anti-Lock Brake System (ABS)........................... 4-6
Anti-Lock Brake, System Warning Light..............3-27
Appearance Care............................................5-72
Aluminum or Chrome-Plated Wheels..............5-76
Care of Safety Belts....................................5-74
Chemical Paint Spotting...............................5-78
Cleaning Exterior Lamps/Lenses....................5-75Appearance Care (cont.)
Fabric/Carpet..............................................5-72
Finish Care.................................................5-75
Finish Damage............................................5-77
Glass Surfaces............................................5-74
Instrument Panel.........................................5-74
Interior Plastic Components...........................5-74
Sheet Metal Damage...................................5-77
Tires..........................................................5-77
Underbody Maintenance...............................5-78
Vehicle Care/Appearance Materials................5-78
Vinyl..........................................................5-74
Washing Your Vehicle...................................5-75
Weatherstrips..............................................5-75
Windshield and Wiper Blades........................5-76
Ashtrays........................................................3-17
Audio System(s).............................................3-36
AM-FM Radio.............................................3-37
Care of Your CD Player...............................3-70
Care of Your CDs........................................3-70
Chime Level Adjustment...............................3-71
Fixed Mast Antenna.....................................3-71
Personal Choice Radio Controls....................3-69
Radio with CD............................3-39, 3-44, 3-54
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-36
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-36
1

Page 342 of 354

Audio System(s) (cont.)
Theft-Deterrent Feature................................3-69
Understanding Radio Reception.....................3-70
XM™ Satellite Radio Antenna System............3-71
Automatic Transaxle
Fluid..........................................................5-19
Operation...................................................2-20
B
Battery..........................................................5-36
Run-Down Protection...................................3-16
Before Leaving on a Long Trip.........................4-21
Brake
Anti-Lock Brake System (ABS)........................ 4-6
Emergencies................................................ 4-8
Parking......................................................2-25
System Inspection.......................................6-23
System Warning Light..................................3-26
Brakes..........................................................5-32
Braking........................................................... 4-5
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-16
Bulb Replacement...........................................5-41
Back-Up Lamps...........................................5-45
Front Turn Signal and Parking Lamps.............5-44
Halogen Bulbs............................................5-41Bulb Replacement (cont.)
Headlamps.................................................5-42
Replacement Bulbs......................................5-45
Taillamps and Turn Signal Lamps..................5-44
Buying New Tires...........................................5-56
C
California Fuel.................................................. 5-5
Caliper/Knuckle Maintenance Inspection.............6-23
Canadian Owners................................................ ii
Capacities and Specications............................5-85
Carbon Monoxide...........2-10, 2-29, 4-24, 4-37, 4-43
Care of
Safety Belts................................................5-74
Your CD Player...........................................3-70
Your CDs ...................................................3-70
Center Console Storage Area...........................2-35
Chains, Tire...................................................5-60
Charging System Light....................................3-25
Check
Engine Light...............................................3-30
Gages Warning Light...................................3-34
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-78
Child Restraints
Child Restraint Systems...............................1-33
Infants and Young Children...........................1-30
2

Page 343 of 354

Child Restraints (cont.)
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-39
Older Children.............................................1-27
Securing a Child Restraint Designed for the
LATCH System........................................1-41
Securing a Child Restraint in a Rear Seat
Position..................................................1-41
Securing a Child Restraint in the Right Front
Seat Position...........................................1-43
Top Strap...................................................1-37
Top Strap Anchor Location............................1-38
Where to Put the Restraint...........................1-36
Chime Level Adjustment..................................3-71
Cigarette Lighter.............................................3-17
Cleaning
Aluminum or Chrome-Plated Wheels..............5-76
Exterior Lamps/Lenses.................................5-75
Fabric/Carpet..............................................5-72
Finish Care.................................................5-75
Glass Surfaces............................................5-74
Instrument Panel.........................................5-74
Interior Plastic Components...........................5-74
Tires..........................................................5-77
Underbody Maintenance...............................5-78
Vinyl..........................................................5-74
Washing Your Vehicle...................................5-75Cleaning (cont.)
Weatherstrips..............................................5-75
Windshield and Wiper Blades........................5-76
Climate Control System...................................3-18
Outlet Adjustment........................................3-20
Clutch, Hydraulic.............................................5-19
Comfort Guides, Rear Safety Belt.....................1-24
Compact Spare Tire........................................5-71
Content Theft-Deterrent....................................2-14
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-35
Coolant
Engine Temperature Gage............................3-29
Heater, Engine............................................2-19
Low Warning Light.......................................3-30
Surge Tank Pressure Cap.............................5-23
Cooling System..............................................5-25
Cruise Control Lever.......................................3-10
Cupholder(s)..................................................2-35
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
3

Page 345 of 354

Engine (cont.)
Overheating................................................5-23
Starting......................................................2-18
Enhanced Traction System (ETS)........................ 4-8
Active Light................................................3-29
Warning Light.............................................3-28
Entry Lighting.................................................3-16
Event Data Recorders (EDR)............................. 7-9
Extender, Safety Belt.......................................1-26
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-17
Finish Damage...............................................5-77
Fixed Mast Antenna........................................3-71
Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-61
Flat Tire, Changing.........................................5-62
Flat Tire, Storing.............................................5-70
Fluid
Automatic Transaxle.....................................5-19
Manual Transaxle........................................5-19
Power Steering...........................................5-30
Windshield Washer......................................5-31Fog Lamps....................................................3-15
Front Reading Lamps......................................3-16
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-35
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
System Inspection.......................................6-22
Fuses
Engine Compartment Fuse Block...................5-84
Fuses and Circuit Breakers...........................5-81
Instrument Panel Fuse Block.........................5-82
Windshield Wiper.........................................5-81
G
Gage
Check Gages Warning Light..........................3-34
Engine Coolant Temperature.........................3-29
Fuel..........................................................3-35
Speedometer..............................................3-23
Tachometer.................................................3-23
5

Page 346 of 354

Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-5
Headlamp Wiring............................................5-80
Headlamps....................................................5-42
Bulb Replacement.......................................5-41
Daytime Running Lamps...............................3-13
Flash-to-Pass............................................... 3-8
Front Turn Signal and Parking Lamps.............5-44
Halogen Bulbs............................................5-41
High/Low Beam Changer................................ 3-8
On Reminder..............................................3-13
Heater...........................................................3-18
Highbeam On Light.........................................3-34
Highway Hypnosis...........................................4-22
Hill and Mountain Roads..................................4-22
Hood
Checking Things Under................................5-10
Release.....................................................5-10Horn............................................................... 3-6
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-13
Hydraulic Clutch.............................................5-19
I
Ignition Positions.............................................2-16
Infants and Young Children, Restraints...............1-30
Ination -- Tire Pressure..................................5-53
Inspection
Brake System.............................................6-23
Caliper/Knuckle Maintenance.........................6-23
Engine Cooling System................................6-22
Exhaust System..........................................6-22
Fuel System...............................................6-22
Part C - Periodic Maintenance.......................6-22
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-22
Throttle System...........................................6-22
Instrument Panel
Brightness..................................................3-15
Cluster.......................................................3-22
Overview..................................................... 3-4
6

Page 347 of 354

J
Jump Starting.................................................5-37
K
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Labelling, Tire Sidewall....................................5-48
Lamps
Battery Run-Down Protection.........................3-16
Exterior......................................................3-13
Fog ...........................................................3-15
Front Reading.............................................3-16
Map ..........................................................3-16
LATCH System
Child Restraints...........................................1-39
Securing a Child Restraint Designed for the
LATCH System........................................1-41
Latches, Seatback............................................ 1-6
Light
Airbag Readiness........................................3-24
Anti-Lock Brake System Warning...................3-27
Brake System Warning.................................3-26Light (cont.)
Charging System.........................................3-25
Check Gages Warning.................................3-34
Enhanced Traction System (ETS)
Active Light.............................................3-29
Enhanced Traction System (ETS)
Warning Light..........................................3-28
Highbeam On.............................................3-34
Low Coolant Warning...................................3-30
Malfunction Indicator....................................3-30
Oil Pressure...............................................3-33
Passlock
®Warning.......................................3-34
Safety Belt Reminder...................................3-24
Service Vehicle Soon...................................3-35
Up-Shift.....................................................3-26
Lighting
Entry.........................................................3-16
Lockout Protection..........................................2-10
Locks
Door........................................................... 2-8
Lockout Protection.......................................2-10
Power Door.................................................. 2-9
Rear Door Security Locks............................... 2-9
Long Trip/Highway Scheduled Maintenance........6-13
Loss of Control...............................................4-14
Low Coolant Warning Light..............................3-30
7

Page 349 of 354

O
Odometer......................................................3-23
Odometer, Trip...............................................3-23
Off-Road Recovery..........................................4-12
Oil
Engine.......................................................5-13
Pressure Light.............................................3-33
Older Children, Restraints................................1-27
Online Owner Center........................................ 7-3
OnStar
®System.............................................2-33
Other Warning Devices...................................... 3-6
Outlet Adjustment............................................3-20
Outside
Breakaway Mirrors.......................................2-32
Convex Mirror.............................................2-32
Power Mirrors.............................................2-31
Remote Control Mirror..................................2-31
Owners, Canadian............................................... ii
P
Park (P)
Shifting Into................................................2-26
Shifting Out of............................................2-28Parking
Brake........................................................2-25
Over Things That Burn.................................2-29
Parking Your Vehicle.......................................2-28
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-18
Part C - Periodic Maintenance Inspections..........6-22
Part D - Recommended Fluids and Lubricants.......6-24
Part E - Maintenance Record...........................6-26
Passing.........................................................4-12
Passlock
®......................................................2-15
Personal Choice Radio Controls........................3-69
Power
Accessory Outlets........................................3-16
Door Locks.................................................. 2-9
Electrical System.........................................5-81
Retained Accessory (RAP)............................2-18
Steering Fluid.............................................5-30
Windows....................................................2-13
Q
Questions and Answers About Safety Belts.........1-12
9

Page 351 of 354

Safety Belts (cont.)
Rear Safety Belt Comfort Guides for Children
and Small Adults......................................1-24
Rear Seat Passengers.................................1-20
Right Front Passenger Position......................1-20
Safety Belt Extender....................................1-26
Safety Belt Use During Pregnancy.................1-20
Safety Belts Are for Everyone......................... 1-8
Shoulder Belt Height Adjuster........................1-19
Safety Warnings and Symbols.............................. iii
Seatback Latches............................................. 1-6
Seats
Easy Entry Seat............................................ 1-6
Head Restraints............................................ 1-5
Manual........................................................ 1-2
Rear Seat Operation...................................... 1-7
Reclining Seatbacks...................................... 1-4
Seatback Latches.......................................... 1-6
Securing a Child Restraint
Designed for the LATCH System...................1-41
Rear Seat Position......................................1-41
Right Front Seat Position..............................1-43
Selecting the Right Schedule, Maintenance.......... 6-5
Service........................................................... 5-3
Adding Equipment to the Outside of
Your Vehicle.............................................. 5-5
Doing Your Own Work................................... 5-4Service (cont.)
Engine Soon Light.......................................3-30
Publications Ordering Information...................7-11
Vehicle Soon Light.......................................3-35
Servicing Your Airbag-Equipped Vehicle..............1-55
Setting the Time
Radios with Radio Data Systems (RDS).........3-36
Radios without Radio Data Systems (RDS).....3-36
Sheet Metal Damage.......................................5-77
Shifting Into Park (P).......................................2-26
Shifting Out of Park (P)...................................2-28
Short Trip/City Scheduled Maintenance................ 6-6
Shoulder Belt Height Adjuster...........................1-19
Signals, Turn and Lane-Change.......................... 3-8
Spare Tire
Installing....................................................5-65
Removing...................................................5-63
Storing.......................................................5-70
Specications, Capacities.................................5-85
Speedometer..................................................3-23
Starting Your Engine.......................................2-18
Steering........................................................4-10
Steering, Suspension and Front Drive Axle Boot
and Seal Inspection.....................................6-22
Steering Wheel, Tilt Wheel................................. 3-6
11

Page 353 of 354

Traction (cont.)
Enhanced Traction System (ETS)
Warning Light..........................................3-28
Transaxle
Fluid, Automatic...........................................5-19
Fluid, Manual..............................................5-19
Transaxle Operation, Automatic.........................2-20
Transaxle Operation, Manual............................2-23
Transmission
Up-Shift Light..............................................3-26
Trip Odometer................................................3-23
Trunk............................................................2-10
Turn and Lane-Change Signals.......................... 3-8
Turn Signal/Multifunction Lever........................... 3-7
U
Understanding Radio Reception........................3-70
Uniform Tire Quality Grading............................5-57
Up-Shift Light.................................................3-26
V
Vehicle
Control........................................................ 4-5
Damage Warnings........................................... iv
Parking Your...............................................2-28Vehicle (cont.)
Service Soon Light......................................3-35
Symbols......................................................... iv
Vehicle Data Collection and Event Data
Recorders.................................................... 7-9
Vehicle Identication
Number (VIN).............................................5-79
Service Parts Identication Label...................5-80
Ventilation Adjustment......................................3-20
Visors...........................................................2-13
W
Warning Lights, Gages and Indicators................3-21
Warnings
Hazard Warning Flashers............................... 3-6
Other Warning Devices.................................. 3-6
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Wheels
Alignment and Tire Balance..........................5-58
Replacement...............................................5-58
Where to Put the Restraint...............................1-36
Windows.......................................................2-12
Power........................................................2-13
Windshield
Wiper Blades, Cleaning................................5-76
13

Page:   < prev 1-10 ... 11-20 21-30 31-40 41-50