charging CHEVROLET KODIAK 2006 Owners Manual

•The charging system light should come on when
the ignition key is turned to RUN or START and
should go out when the engine is running above
idle. If the light does not go out or comes back on
during normal engine operation, have the charging
system checked right away. (This light tells you
if the generator is not charging; it does not reflect
the condition of the battery.) SeeCharging System
Light on page 3-31for more information.
•The voltmeter charge indicator gage tells you the
condition of your battery’s charge. The gage
should be in the center area during engine
operation. The red area on the left indicates an
undercharge condition; the red area on the
right indicates an overcharge. If the gage is in
either red area, have the battery and charging
system checked right away. SeeVoltmeter Gage
on page 3-32for more information.Notice:Do not allow the engine to operate at low
idle for more than ve minutes. This can cause
low engine operating temperatures which can affect
engine operation and reduce engine life. Engine
idle speed should be increased to 1200 rpm
whenever extended idle is required. Once started,
the engine should be placed under load to allow the
engine coolant temperature to reach 150°F (66°C)
before shutting off the engine.
2-25

Instrument Panel Overview...............................3-4
Hazard Warning Flashers................................3-6
Other Warning Devices...................................3-6
Horn .............................................................3-6
Tilt Wheel.....................................................3-7
Turn Signal/Multifunction Lever.........................3-7
Turn and Lane-Change Signals........................3-8
Headlamp High/Low-Beam Changer..................3-8
Windshield Wipers..........................................3-9
Windshield Washer.......................................3-10
Cruise Control..............................................3-10
Exterior Lamps.............................................3-14
Headlamps on Reminder................................3-15
Daytime Running Lamps (DRL).......................3-15
Marker Lamps..............................................3-16
Instrument Panel Brightness...........................3-16
Dome Lamps ...............................................3-16
Entry Lighting...............................................3-17
Reading Lamps............................................3-17
Instrument Panel Switchbank..........................3-18
Accessory Power Outlet(s).............................3-19
Ashtray(s) and Cigarette Lighter......................3-20Climate Controls............................................3-20
Climate Control System.................................3-20
Outlet Adjustment.........................................3-24
Rear Heating System....................................3-24
Warning Lights, Gages, and Indicators............3-25
Instrument Panel Cluster................................3-26
Speedometer and Odometer...........................3-27
Trip Odometer..............................................3-27
Tachometer.................................................3-27
Engine Speed Limiter....................................3-28
Safety Belt Reminder Light.............................3-28
Safety Belt Reminder Tone............................3-28
Airbag Readiness Light..................................3-29
Airbag Off Light............................................3-30
Charging System Light..................................3-31
Voltmeter Gage............................................3-32
Service Transmission Warning Light................3-32
Range Inhibit Warning Indicator......................3-33
Brake System Warning Light..........................3-33
Anti-Lock Brake System Warning Light.............3-35
Trailer Anti-Lock Brake System Warning Light . . .3-36
Engine Coolant Temperature Gage..................3-36
Section 3 Instrument Panel
3-1

{CAUTION:
If the airbag readiness light ever comes on
when you have turned off the airbag, it means
that something may be wrong with the airbag
system. The right front passenger’s airbag
could inate even though the switch is off. If
this ever happens, do not let anyone whom the
national government has identied as a
member of a passenger airbag risk group sit in
the right front passenger’s position (for
example, do not secure a rear-facing child
restraint in the right front passenger’s seat)
until you have your vehicle serviced. See
Airbag Off Switch on page 1-58andAirbag
Readiness Light on page 3-29for more on this,
including important safety information.
Charging System Light
The charging system light
may be located in the
instrument panel cluster, or
with the auxiliary warning
lights in the center of
the instrument panel.
It should come on briefly when you turn on the ignition,
before the engine is running, as a check to show
that it is working.
If it stays on, or comes on while you are driving, have
your vehicle checked right away. You could have a loose
generator drive belt or some other problem.
Driving while this light is on will drain your battery. If you
must drive a short distance with the light on, turn off
your radio and other accessories. Sustained driving with
a generator failure could result in a lack of back-up
braking if the engine quits or the power steering pump
should fail.
3-31

Voltmeter Gage
When your engine is
running, the voltmeter
gage shows the charging
system voltage.
Readings in either warning zone indicate a possible
problem in the electrical system.
Readings in the low warning zone may occur when a
large number of electrical accessories are operating in
the vehicle and the engine is left at an idle for an
extended period. This condition is normal since the
charging system may not be able to provide full power
at engine idle. As engine speeds are increased, this
condition should correct itself because higher engine
speeds allow the charging system to create maximum
power.
You can only drive a short time on the battery. Be sure
to shut off the radio, the fan or any unnecessary
accessories and have the system serviced.
Service Transmission Warning Light
If your vehicle has an Allison®automatic transmission,
certain transmission malfunctions will turn this light on.
This light is located with
the auxiliary warning lights
in the center of the
instrument panel.
If this light comes on while you are driving, do not use
the transmission shift control or you may lose forward
gears. The computer for the transmission senses
a problem and chooses a gear to stay in so that you
can drive the vehicle in that gear. You may not be able
to drive as fast or back up when this light is on.
Notice:If you continue driving your vehicle after
the transmission warning light comes on, you could
damage the transmission. While this light is on,
the transmission cannot operate in all gears. If you
attempt to shift gears, the vehicle may not
continue to move. Do not attempt to shift gears
while the transmission warning light is on. Instead,
drive directly to a GM dealer for service. If you
cannot drive to a dealer immediately, have the
vehicle towed.
3-32

Audio System(s).............................................3-48
AM-FM Radio.............................................3-50
Care of Your Cassette Tape Player................3-65
Care of Your CD Player...............................3-67
Care of Your CDs ........................................3-66
Chime Level Adjustment...............................3-67
Fixed Mast Antenna.....................................3-67
Radio with Cassette.....................................3-53
Radio with CD............................................3-59
Setting the Time..........................................3-49
Theft-Deterrent Feature................................3-64
Understanding Radio Reception.....................3-64
Automatic Ether Injection System......................5-72
Automatic Transmission
Fluid..........................................................5-36
Operation...................................................2-30
Axle, Two-Speed Rear Axle Electric
Shift Control...............................................2-28
B
Battery..........................................................5-58
Bench Seat, Split............................................. 1-6
Brake
Anti-Lock Brake System (ABS)........................ 4-8
Diesel Engine Exhaust.................................2-27
Emergencies................................................ 4-9
Exhaust Indicator Light.................................3-41Brake (cont.)
Hydraulic Systems......................................... 4-7
System Warning Light..................................3-33
Trailer Hand Control Valve............................4-10
Brakes..........................................................5-49
Air .............................................................2-42
Hydraulic....................................................2-40
Propshaft Brake Burnish Procedure................2-41
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-9
Break-In, New Vehicle.....................................2-11
Bucket Seats................................................... 1-2
Bulb Replacement...........................................5-68
C
California Proposition 65 Warning....................... 5-3
Canadian Owners................................................ ii
Capacities and Specifications............................5-99
Carbon Monoxide...................................2-45, 4-27
Care of
Safety Belts................................................5-86
Your Cassette Tape Player............................3-65
Your CD Player...........................................3-67
Your CDs ...................................................3-66
Center Console Storage Area...........................2-49
Center Passenger Position, Safety Belts.............1-24
Charging System Light....................................3-31
2

L
Lamps
Dome ........................................................3-16
Exterior......................................................3-14
Marker.......................................................3-16
Reading.....................................................3-17
LATCH System
Child Restraints...........................................1-41
Light
Airbag Off..................................................3-30
Airbag Readiness........................................3-29
Anti-Lock Brake System Warning...................3-35
Brake System Warning.................................3-33
Change Engine Oil......................................3-40
Charging System.........................................3-31
Check Gages Warning.................................3-44
Daytime Running Lamps Indicator..................3-43
Differential Lock Indicator..............................3-42
Engine Overspeed Warning...........................3-40
Engine Shutdown Warning............................3-40
Exhaust Brake Indicator................................3-41
Highbeam On.............................................3-43
Low Coolant Warning...................................3-37
Low Oil Level.............................................3-39
Low Washer Fluid Warning...........................3-44
Malfunction Indicator....................................3-38Light (cont.)
Range Inhibit Warning Indicator.....................3-33
Reduced Engine Power................................3-42
Safety Belt Reminder...................................3-28
Safety Belt Reminder Tone...........................3-28
Service Transmission Warning.......................3-32
Trailer Anti-Lock Brake System Warning..........3-36
Wait to Start Indicator..................................3-37
Water in Fuel Warning.................................3-46
Lighting
Entry.........................................................3-17
Loading Your Vehicle.......................................4-34
Locks
Door ........................................................... 2-6
Power Door.................................................. 2-7
Loss of Control...............................................4-17
Low Coolant Warning Light..............................3-37
Low Washer Fluid Warning Light.......................3-44
M
Maintenance, Normal Replacement Parts..........5-104
Maintenance Schedule
At Each Fuel Fill.........................................6-28
At Least Once a Year..................................6-32
At Least Twice a Year..................................6-29
8