key CHEVROLET SILVERADO 1999 1.G Service Manual

yellowblue
7-21
Starter Switch Check
CAUTION:
When you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake (see ªParking
Brakeº in the Index if necessary) and the regular brake.
NOTE: Do not use the accelerator pedal, and be
ready to turn off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work only in
PARK (P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way to
the floor. If the starter works when the clutch isn't
pushed all the way down, your vehicle needs service.Brake
-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
CAUTION:
When you are doing this check, the vehicle could
move suddenly. If it does, you or others could be
injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a
level surface.
2. Firmly apply the parking brake
(see ªParking Brakeº in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the
RUN position, but don't start the engine. Without
applying the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the shift
lever moves out of PARK (P), your vehicle's BTSI
needs service.

yellowblue
7-22
Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.

With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).

With a manual transmission, the key should turn to
LOCK only when you press the key release button.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.

To check the parking brake's holding ability: With
the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure from
the regular brake pedal. Do this until the vehicle is
held by the parking brake only.

To check the PARK (P) mechanism's holding ability:
With the engine running, shift to PARK (P). Then
release all brakes.
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.

yellowblue
7-26
USAGEFLUID/LUBRICANT
Key Lock
CylindersMulti-Purpose Lubricant,
Superlube
(GM Part
No. 12346241 or equivalent).
Floor Shift
LinkageLubriplate
Lubricant Aerosol
(GM Part No. 12346293 or
equivalent) or lubricant meeting
requirements of NLGI # 2
Category LB or GC
-LB.
Chassis
LubricationChassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements of
NLGI # 2, Category LB or
GC
-LB.
Differential,
FrontSAE 80W-90 Axle Lubricant (GM
Part No. 1052271 or equivalent).
USAGEFLUID/LUBRICANT
Rear AxleSAE 75W-90 Synthetic Axle
Lubricant (GM Part
No. 12378261) or equivalent
meeting GM
Specification 9986115.
Manual Transfer
CaseDEXRON
-III Automatic
Transmission Fluid.
Automatic
Transfer CaseAutomatic Transfer Case Fluid
(GM Part No. 12378396).
Front Axle
Propshaft Spline
or One
-Piece
Propshaft Spline
(Two
-Wheel
Drive with
Auto. Trans.)
Spline Lubricant, Special
Lubricant (GM Part
No. 12345879) or lubricant
meeting requirements of
GM 9985830.

yellowblue
8-6
Chevrolet Roadside Assistance Program
To enhance Chevrolet's strong commitment to customer
satisfaction, Chevrolet is excited to announce the
establishment of the Chevrolet Roadside Assistance
Center. As the owner of a 1999 Chevrolet, membership
in Roadside Assistance is free.
Roadside Assistance is available 24 hours a day,
365 days a year, by calling 1
-800-CHEV-USA (243-8872).
This toll-free number will provide you over
-the-phone
roadside assistance with minor mechanical problems. If your problem cannot be resolved over the
phone, our advisors have access to a nationwide network
of dealer recommended service providers. Roadside
membership is free; however some services may incur costs.
Roadside offers two levels of service to the customer,
Basic Care and Courtesy Care:

Toll
-free number, 1-800-CHEV-USA (243-8872)

Free towing for warranty repairs

Basic over
-the-phone technical advice

Available dealer services at reasonable costs (i.e.,
wrecker services, locksmith/key service, glass
repair, etc.)
ROADSIDE Courtesy Care PROVIDES:

Roadside Basic Care services (as outlined previously)
Plus:

FREE Non
-Warranty Towing (to the closest dealer
from a legal roadway)

FREE Locksmith/Key Service (when keys are lost
on the road or locked inside)

FREE Flat Tire Service (spare installed on the road)

FREE Jump Start (at home or on the road)

FREE Fuel Delivery ($5 of fuel delivered on
the road)

9-yellowblue
9-1
Section 9 Index
A
ccessory Power Outlet 2-65 . . . . . . . . . . . . . . . . . . . . . . . . .
Adding Equipment to the Outside of Your Vehicle 6-3 . . . . . .
Air Bag 1-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding Equipment 1-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How Does it Restrain 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
How it Works 1-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location 1-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off Light 1-33, 2-71 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off Switch 1-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Readiness Light 1-27, 2-71 . . . . . . . . . . . . . . . . . . . . . . . . .
Servicing 1-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
What Makes it Inflate 1-29 . . . . . . . . . . . . . . . . . . . . . . . . . .
What Will You See After it Inflates 1-29 . . . . . . . . . . . . . . .
When Should it Inflate 1-28 . . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner Filter, Engine 6-16 . . . . . . . . . . . . . . . . . . . . . . . .
Air Cleaner Filter Restriction Indicator Check 7-19 . . . . . . . .
Air Conditioning 3-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Refrigerants 6-76 . . . . . . . . . . . . . . . . . . . . .
Air Dam Removal 4-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Dam Replacement 4-16 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Filter, Passenger Compartment 3-5, 6-18, 6-77 . . . . . . . .
Alignment and Balance, Tire 6-51 . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheels, Cleaning 6-59 . . . . . . . . . . . . . . . . . . . . . .
Antenna 3-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Antifreeze 6-29, 6-75, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock
Brake System Warning Light 2-74, 4-7 . . . . . . . . . . . . . . . .
Brakes 4-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Appearance Care 6
-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Appearance Care and Materials 6-62 . . . . . . . . . . . . . . . . . . . .
Arbitration Program 8-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Armrest Storage Compartment 2-64 . . . . . . . . . . . . . . . . . . . .
Ashtrays 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Equipment, Adding 3-26 . . . . . . . . . . . . . . . . . . . . . . . .
Audio Systems 3-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission
Check 7
-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-19, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Park Mechanism Check 7-22 . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-16 . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation 2-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary Battery 4-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary Roof Mounted Lamp Switch 2-54 . . . . . . . . . . . . . .
Axle, Front 6-27, 7-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle, Locking Rear 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Axle, Rear 6-25, 7-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery 6-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary 4-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Message 2-82 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacement, Keyless Entry 2-7 . . . . . . . . . . . . . . . . . . . . .
Run-Down Protection 2-56 . . . . . . . . . . . . . . . . . . . . . . . . .
Warnings 5-3, 5-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BBB Auto Line 8-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-6
Inspections (Continued)
Steering 7-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension 7-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle System 7-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transfer Case (Four-Wheel Drive) 7-24 . . . . . . . . . . . . . . .
Instrument Panel 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cluster 2-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse Block 6-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Intensity Control 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jumper Wiring Harness 4-69 . . . . . . . . . . . . . . . . . . . . . . . .
Interior Lamps 2-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jack, Tire 5-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump Starting 5-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Key Lock Cylinders Service 7-20 . . . . . . . . . . . . . . . . . . . . .
Key Release Button 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Keyless Entry System 2-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Keys 2-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Labels
Certification 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Certification/Tire 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Parts Identification 6-63 . . . . . . . . . . . . . . . . . . . . .
Vehicle Identification Number 6-63 . . . . . . . . . . . . . . . . . . .
Lamps 2-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cargo 2-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dome 2-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior 2-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Interior 2
-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
On Reminder 2-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Latches, Seatback 1-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Leaving Your Vehicle with the Engine Running 2-36 . . . . . . .
Lighter 2-64 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lights
4WD 2
-80 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag Off 1-33, 2-71 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bag Readiness 1-27, 2-71 . . . . . . . . . . . . . . . . . . . . . . .
Anti-Lock Brake System Warning 2-74, 4-7 . . . . . . . . . . . .
Brake System Warning 2-74 . . . . . . . . . . . . . . . . . . . . . . . . .
Cruise 2-80 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Reminder 1-12, 2-70 . . . . . . . . . . . . . . . . . . . . .
Service Engine Soon 2-77 . . . . . . . . . . . . . . . . . . . . . . . . . .
Shift 2-27, 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tow/Haul 2-81 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Information, Truck-Camper 4-50 . . . . . . . . . . . . . . .
Loading Your Vehicle 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Your Vehicle for Off-Road Driving 4-17 . . . . . . . . . .
Lockout Prevention 2-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Locks
Cylinders 7
-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door 2-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Transmission Check 7-22 . . . . . . . . . . . . . . . . . . . .
Key Lock Cylinders Service 7-20 . . . . . . . . . . . . . . . . . . . .
Power Door 2-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Coolant Message 2-84, 6-31 . . . . . . . . . . . . . . . . . . . . . .
Low Fuel Message 2-87 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Low Washer Fluid Message 2-87 . . . . . . . . . . . . . . . . . . . . . . .
Lubricants and Fluids 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Service, Body 7-20 . . . . . . . . . . . . . . . . . . . . . . . .
Lumbar Controls, Manual 1-3 . . . . . . . . . . . . . . . . . . . . . . . . .
Lumbar Controls, Power 1-5 . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-11
Treadwear 6-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Uniform Quality Grading 6-50 . . . . . . . . . . . . . . . . . . . . . . .
Wear Indicators 6-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Replacement 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . .
When It's Time for New 6-48 . . . . . . . . . . . . . . . . . . . . . . .
Top Strap 1-52 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque Lock 2-37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torque, Wheel Nut 5-30, 6-74 . . . . . . . . . . . . . . . . . . . . . . . . .
Total Vehicle Reserve Capacity 4-49 . . . . . . . . . . . . . . . . . . . .
Tow/Haul Light 2-81 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tow/Haul Mode 2-23, 4-55 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing
Trailer 4
-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recreational Vehicle 4-44 . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Vehicle 5-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer
Brakes 4
-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driving on Grades 4-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driving with 4-61 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hitches 4-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance When Towing 4-64 . . . . . . . . . . . . . . . . . . . . .
Parking on Hills 4-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Chains 4-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tongue Weight 4-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Total Weight on Tires 4-57 . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing 4-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signals 4-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Weight 4-56 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring Harness 4-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trans Fluid Hot Message 2-82 . . . . . . . . . . . . . . . . . . . . . . . . . Trans Hot....Idle Engine Message 2
-83 . . . . . . . . . . . . . . . . . .
Transfer Case, Automatic 2-30 . . . . . . . . . . . . . . . . . . . . . . . . .
Transfer Case Lubricant 6-26, 7-26 . . . . . . . . . . . . . . . . . . . . .
Transfer Case, Manual 2-28 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Fluid
Automatic 6
-19, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual 6-22, 7-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Temperature Gage 2-75 . . . . . . . . . . . . . . . . . . .
Transmitters, Keyless Entry 2-6 . . . . . . . . . . . . . . . . . . . . . . . .
Transportation, Courtesy 8-8 . . . . . . . . . . . . . . . . . . . . . . . . . .
Trip Odometer 2-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TTY Users 8-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signal and Lane Change Signals 2-45 . . . . . . . . . . . . . . .
Turn Signal/Multifunction Lever 2-44 . . . . . . . . . . . . . . . . . . .
Turn Signals When Towing a Trailer 4-62 . . . . . . . . . . . . . . . .
Underbody Flushing Service 7-22 . . . . . . . . . . . . . . . . . . . . .
Underbody Maintenance 6-61 . . . . . . . . . . . . . . . . . . . . . . . . .
Underhood Electrical Center 6-69 . . . . . . . . . . . . . . . . . . . . . .
Vehicle
Control 4-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Damage Warnings iv. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification Number 6
-63 . . . . . . . . . . . . . . . . . . . . . . . . .
Loading 4-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage 6-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ventilation System 3-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Visors, Sun 2-65 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Voltmeter 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .