display CHEVROLET SILVERADO 2004 1.G Owners Manual

Coolant Surge Tank Pressure Cap
SeeEngine Compartment
Overview on page 5-14
for more information
on location.
The coolant surge tank pressure cap must be fully
installed on the coolant surge tank.
Notice:If the pressure cap is not tightly
installed, coolant loss and possible engine
damage may occur. Be sure the cap is properly
and tightly secured.
Engine Overheating
You will nd a coolant temperature gage on your
vehicle’s instrument panel. SeeEngine Coolant
Temperature Gage on page 3-46. In addition, you will
nd a ENGINE OVERHEATED and a REDUCED
ENGINE POWER message in the Driver Information
Center on the instrument panel. SeeDriver Information
Center (DIC) on page 3-53.
Overheated Engine Protection
Operating Mode (V8 Engines Only)
If an overheated engine condition exists and the
REDUCED ENGINE POWER message is displayed, an
overheat protection mode which alternates ring
groups of cylinders helps prevent engine damage. In
this mode, you will notice a loss in power and engine
performance. This operating mode allows your vehicle to
be driven to a safe place in an emergency. Driving
extended miles (km) and/or towing a trailer in the
overheat protection mode should be avoided.
Notice:After driving in the overheated engine
protection operating mode, to avoid engine damage,
allow the engine to cool before attempting any repair.
The engine oil will be severely degraded. Repair the
cause of coolant loss, change the oil and reset the oil
life system. SeeEngine Oil on page 5-20.
5-38

Adding Washer Fluid
Your vehicle has a low washer uid message that
comes on when the washer uid is low. The message is
displayed for 15 seconds at the start of each ignition
cycle. When the CHECK WASHER FLUID message is
displayed, you will need to add washer uid to the
windshield washer uid reservoir.
The windshield washer
uid reservoir is located in
the engine compartment
toward the front of the
vehicle on the driver’s side.
Open the cap with the washer symbol on it. Add washer
uid until the tank is full.Notice:When using concentrated washer uid,
follow the manufacturer’s instructions for
adding water.
Do not mix water with ready-to-use washer uid.
Water can cause the solution to freeze and
damage your washer uid tank and other parts
of the washer system. Also, water does not
clean as well as washer uid.
Fill your washer uid tank only three-quarters
full when it is very cold. This allows for
expansion if freezing occurs, which could
damage the tank if it is completely full.
Do not use engine coolant (antifreeze) in your
windshield washer. It can damage your washer
system and paint.
5-48

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number or specication may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM Goodwrench
oil meets all the requirements for
your vehicle. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on
page 5-20.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-35.
Usage Fluid/Lubricant
Hydraulic
Brake SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Hydraulic
Clutch System
(5–Speed
Trans.)Hydraulic Clutch Fluid
(GM Part No. U.S. 12345347, in
Canada 10953517) or equivalent
DOT-3 brake uid.
Hydraulic
Clutch System
(6–Speed
Trans.)Hydraulic Clutch Fluid. Use only
GM Part No. U.S. 88958860, in
Canada 88901244, DOT-4
brake uid.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184, in
Canada 89021186).
Manual
Transmission
(5–Speed with
Low Gear,
RPO MW3)GM Goodwrench Synthetic Manual
Transmission Fluid
(GM Part No. U.S. 12346190, in
Canada 10953477) or equivalent
SAE 75W-85 GL-4 gear oil.
6-13

D
Daytime Running Lamps..................................3-15
Defensive Driving............................................. 4-2
Defogging and Defrosting.........................3-23, 3-31
Delayed Locking.............................................2-10
Dinghy Towing................................................4-53
Doing Your Own Service Work........................... 5-4
Dolly Towing..................................................4-55
Dome Lamps.................................................3-18
Door
Delayed Locking..........................................2-10
Locks.......................................................... 2-8
Power Door Locks......................................... 2-9
Programmable Automatic Door Locks.............2-10
Rear Door Security Locks.............................2-13
Rear Doors.................................................2-14
Driver
Position, Safety Belt.....................................1-16
DRIVER DOOR AJAR.....................................3-66
Driver Information Center (DIC).........................3-53
DIC Operation and Displays..........................3-54
DIC Warnings and Messages........................3-64
Driving
At Night.....................................................4-36
City...........................................................4-40
Defensive..................................................... 4-2Driving (cont.)
Drunken....................................................... 4-2
Freeway.....................................................4-41
Hill and Mountain Roads..............................4-44
In Rain and on Wet Roads...........................4-37
Off-Road....................................................4-21
Winter........................................................4-46
Driving Across an Incline..................................4-32
Driving Downhill..............................................4-31
Driving in Mud, Sand, Snow or Ice....................4-34
Driving in Water..............................................4-34
Driving On Grades..........................................4-92
Driving on Off-Road Hills.................................4-27
Driving on Snow or Ice....................................4-46
Driving Through Deep Standing Water...............4-39
Driving Through Flowing Water.........................4-39
Driving Uphill..................................................4-28
Driving with a Trailer.......................................4-91
Dual Automatic Climate Control System.............3-25
Dual Climate Control System............................3-22
Dual Stage Air Bags........................................1-70
Dual Tire Operation.........................................5-83
DVD
Rear Seat Entertainment System..................3-114
DVD Distortion..............................................3-125
DVD Messages.............................................3-124
DVD Player..................................................3-117
5

E
Easy Exit Seat...............................................2-72
Electrical System
Add-On Equipment.....................................5-123
Fuses and Circuit Breakers.........................5-123
Power Windows and Other Power Options.......5-123
Windshield Wiper Fuses.............................5-123
Electronic Transfer Case..................................2-44
Emissions Inspection and Maintenance
Programs...................................................3-50
Engine
Air Cleaner/Filter.........................................5-25
Battery.......................................................5-52
Check and Service Engine Soon Light............3-48
Coolant......................................................5-35
Coolant Heater............................................2-26
Coolant Temperature Gage...........................3-46
Drive Belt Routing.......................................6-18
Engine Compartment Overview......................5-14
Exhaust.....................................................2-53
Fan Noise..................................................5-46
Oil .............................................................5-20
Overheating................................................5-38
Starting......................................................2-24
ENGINE COOLANT HOT.................................3-66
Engine Hour Meter Display...............................3-35
Engine Oil Additives........................................5-23
ENGINE OVERHEATED..................................3-66Entry Lighting.................................................3-18
Environmental Concerns..................................4-25
Event Data Recorders (EDR)............................. 7-9
Exit Lighting...................................................3-18
Express Down Windows..................................2-18
Extended Cab........................................1-56, 2-14
Extended Cab and Crew Cab...........................1-53
Extender, Safety Belt.......................................1-31
Exterior Lamps...............................................3-13
F
Fifth Wheel and Gooseneck Trailering................4-89
Filter
Engine Air Cleaner......................................5-25
Finding a Program Type (PTY) Station
(RDS and XM™).......................3-79, 3-90, 3-104
Finding a Station..................3-74, 3-77, 3-88, 3-102
Finish Care..................................................5-118
Finish Damage.............................................5-120
Five-Speed (VORTEC™ 4300 V6 and
4800 V8 Engines)........................................2-32
Five-Speed (VORTEC™ 6000 V8 Engine)...........2-31
Fixed Mast Antenna.......................................3-130
Flash-to-Pass................................................... 3-9
Flat Tire........................................................5-92
Flat Tire, Changing.........................................5-93
6

Loss of Control...............................................4-20
LOW COOLANT LEVEL..................................3-67
Low Fuel Warning Light...................................3-53
Lumbar
Power Controls............................................. 1-5
M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill.........................................6-10
At Least Once a Month................................6-10
At Least Once a Year..................................6-11
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000km).......................6-10
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-8
Maintenance Record....................................6-19
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-16
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-13
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-3
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-94
Making Turns.................................................4-92
Malfunction Indicator Light................................3-48Manual Seats................................................... 1-3
Manual Selectable Ride...................................4-11
Manual Transfer Case.....................................2-37
Manual Transmission...............................2-25, 2-52
Fluid..........................................................5-33
Operation...................................................2-31
Manual Windows............................................2-17
Matching Transmitter(s) to Your Vehicle............... 2-6
Memory Seat.................................................2-70
Message
DIC Warnings and Messages........................3-64
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) – Customer Assistance....... 7-5
Mirrors
Automatic Dimming Rearview with Compass
and Temperature Display...........................2-58
Automatic Dimming Rearview with OnStar
®,
Compass and Temperature Display.............2-55
Manual Rearview Mirror................................2-55
Outside Automatic Dimming Mirror.................2-64
Outside Camper-Type Mirrors........................2-61
Outside Convex Mirror.................................2-65
Outside Curb View Assist Mirrors...................2-64
Outside Heated Mirrors................................2-65
Outside Manual Mirrors................................2-60
Outside Power Camper-Type.........................2-62
Outside Power Foldaway Mirrors....................2-63
10

Radios (cont.)
Theft-Deterrent..........................................3-127
Understanding Reception............................3-128
RANGE SHIFT INHIBITED (Allison
Transmission
®Only).....................................3-67
RDS Messages.............................3-80, 3-91, 3-105
Rear Axle......................................................5-59
Locking......................................................4-12
Rear Door Security Locks................................2-13
Rear Doors....................................................2-14
Rear Safety Belt Comfort Guides......................1-29
Rear Seat Audio (RSA)..................................3-125
Rear Seat Entertainment System.....................3-114
Rear Seat Operation......................................... 1-9
Rear Seat Outside Passenger Positions
(Extended Cab and Crew Cab)......................1-26
Rear Seat Passengers, Safety Belts..................1-26
Rear Seat Top Strap Anchors (Crew
Cab Models)...............................................1-46
Rear Seat Top Strap Anchors (Extended
Cab Models)...............................................1-45
Rear Window Defogger............................3-24, 3-31
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-58
Rearview Mirror, Automatic Dimming with OnStar
®,
Compass and Temperature Display..................2-55
Rearview Mirrors.............................................2-55
Reclining Seatbacks.......................................... 1-6
Recommended Fluids and Lubricants.................6-13
Recreational Vehicle Towing.............................4-53REDUCED ENGINE POWER...........................3-67
Regular Cab and Extended Cab Models.............1-73
Remote Control.............................................3-119
Remote Keyless Entry System............................ 2-4
Remote Keyless Entry System, Operation............ 2-5
Removing the Flat Tire and Installing the
Spare Tire..................................................5-98
Removing the Spare Tire and Tools...................5-94
Replacement Bulbs.........................................5-72
Replacing Brake System Parts..........................5-52
Reporting Safety Defects
Canadian Government..................................7-11
General Motors...........................................7-11
United States Government............................7-10
Restraint System Check
Checking Your Restraint Systems...................1-84
Replacing Restraint System Parts After
a Crash..................................................1-85
Restraint Systems
Checking....................................................1-84
Replacing Parts...........................................1-85
Resynchronization............................................. 2-7
Retained Accessory Power (RAP)......................2-24
Right Front Passenger Position, Safety Belts......1-24
Right Front Passenger Position Top Strap Anchor
(Regular and Extended Models).....................1-43
RIGHT REAR DOOR AJAR (Crew Cab).............3-68
Roadside
Assistance Program....................................... 7-6
13

Service Bulletins.............................................7-12
Service Manuals.............................................7-11
SERVICE RIDE CONTROL..............................3-69
Setting Preset PTYs (RDS Only).......3-80, 3-91, 3-105
Setting Preset Stations..........3-74, 3-78, 3-89, 3-103
Setting the Time
Radios with Radio Data Systems (RDS).........3-73
Radios without Radio Data Systems (RDS).....3-72
Setting the Tone
(Bass/Treble)....................3-74, 3-78, 3-89, 3-103
Sheet Metal Damage.....................................5-120
Shift Speeds..................................................2-35
Shifting Into Park (P).......................................2-49
Shifting Out of Park (P)...................................2-51
Single Stage Air Bags.....................................1-71
Single Stage vs. Dual Stage Air Bags................1-70
Six-Speed (VORTEC™ 8100 V8 and
DURAMAX™ 6600 V8 Engines)...................2-33
Skidding........................................................4-20
Sliding Rear Windows.....................................2-19
Snow Plow....................................................4-63
Some Other Rainy Weather Tips.......................4-40
Spare Tire....................................................5-113
Special Fabric Cleaning Problems....................5-115
Specications, Capacities...............................5-132
Speedometer..................................................3-35
Stalling on an Incline.......................................4-33
Starting Your Engine.......................................2-24
Starting Your V8 Engine..................................2-25Steering........................................................4-13
Steering in Emergencies..................................4-14
Steering Tips..................................................4-13
Steering Wheel Controls, Audio.......................3-127
Steering Wheel, Tilt Wheel................................. 3-7
Step-Bumper Pad..........................................4-102
Stereo RCA Jacks.........................................3-115
Storage Areas................................................2-67
Center Console Storage Area........................2-68
Cupholder(s)...............................................2-67
Front Storage Area......................................2-68
Glove Box..................................................2-67
Storing a Flat or Spare Tire, Jack and Tools.....5-106
Stuck in Sand, Mud, Ice or Snow......................4-50
Sun Visors.....................................................2-19
Supplemental Brake Assist System...................... 4-9
Swing-Out Windows........................................2-19
T
Tachometer....................................................3-35
Tailgate.........................................................2-15
Tailgate Removal............................................2-15
Taillamps.......................................................5-70
Taillamps (Chassis Cab Models)........................5-72
Temperature and Compass Display....................2-55
Temperature Display........................................2-58
Testing the Alarm............................................2-21
Theft-Deterrent, Radio....................................3-127
15