cooling CHEVROLET TRACKER 1994 User Guide

Service and Appearance Care
If you need to replace any of your wheels,
wheel bolts, or wheel nuts, replace them
only
with new GM original equipment
parts. This way, you
will be sure to have
the right wheel, wheel bolts, and wheel
nuts for your Geo model.
NOTICE:
The wrong wheel can also cause
problems
with bearing life, brake
cooling, speedometer/odometer
calibration, headlight aim, bumper
height, vehicle ground clearance,
and
tire or tire chain clearance to the
body and chassis.
Used Replacement Wheels
A CAUTION:
Putting a used wheel on your vehicle
is dangerous. You can’t know how
it’s been used or how many miles it’s
been driven. It could
fail suddenly
and cause an accident.
If you have
to replace a wheel
use a new GM
original equipment wheel.
Tire Chains
NOTICE:
Use tire chains only where legal and
only when you must. Use only SAE
Class “S” type chains that are the
proper size for your tires. Install them
on the tires of the drive axle (four-
wheel drive vehicles can use chains
on both axles). Tighten them
as
tightly as possible with the ends
securely fastened. Drive slowly and
follow the chain manufacturer’s
instructions.
If you can hear the
chains contacting your vehicle, stop
and retighten them.
If the contact
continues, slow down until
it stops.
Driving too fast with chains
on will
damage your vehicle.
. . .188 ProCarManuals.com

Capacities (Approximate)
The following approximate capacities are given in U.S. and metric conversions.
Air Conditioning”
............. See the refrigerant information label under hood.
Automatic Transmission Drain and Refill
....................................... 3.0 qt. (2.8 L)**
Overhaul ............................................. 5.4 qt. (5.1 L)
Automatic Transmission ................................ 5.5 qt. (5.2 L)
Manual Transmission ................................... 5.6 qt. (5.3 L)
With Filter Change ..................................... 4.5 qt. (4.2 L)*
Without Filter Change .................................. 4.2 qt. (4.0 L)
Front Differential ........................................ 1.1 qt. (1 .O L)
Fuel Tank ............................................. 11.1 gal. (42 L)
Manual Transmission
Cooling System
Crankcase
Four-wheel Drive
.................................... 1.6 qt. ( 1.5 L) **
Two-Wheel Drive ..................................... 1.8 qt. (1.7 L) **
Rear Differential ........................................ 2.3 qt. (2.2 L)
Transfer Case ........................................... 1.8 qt. ( 1.7 L)
T Not all air conditioning refrigerants are the same. If the air conditioning system
in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re
not sure, ask your Geo dealer.
* When changing the oil filter, additional oil may be needed. Recheck the oil level
after filling. See “Engine Oil”
in the Index.
** Recheck fluid level after filling. See “Automatic Transmission Fluid” or “Manual
Transmission Fluid”
in the Index.
201 ...
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule l
Follow Schedule I if your vehicle is
MAINLY driven under one or more of
the following conditions:
e
a
a
a
When most trips are less than 4 miles
(6 km).
When most trips are less than
10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When towing
a trailer.
When operating in dusty areas or
off-road frequently.
Schedule
I should also be followed if the
taxi or other commercial applications.
* An Emission Control Service.
t The U.S. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to perform this
maintenance item will not
nullify the emission
warranty or limit recall liability prior
to the
completion
of vehicle useful lfc. General
Morors, howeve); urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance
be
recorded in “Section E: Maintenance Record.”
9%
. . .206
ITEM NO.
-
1
2
3
-
4
5
6
7
-
-
-
8
-
9
10
11
-
-
7
12
13
WHAT TO SERVICE
See “E,xplanation of Scheduled
Maintenance Services” following
Schedules
I und 11.
Engine OTI and Filter Change*
Tire and Wheel Rotation and Inspection
Fan (Water Pump) Drive Belt Service
Camshaft Timing Belt Replacement*
Cooling System Service”
Wheel Bearine Insuection
Transmission
(All) and Transfer Case
Differential (Four-wheel Drive) Service
Propeller Shafts and
U-Joints Inspection
Freewheeling Hubs Inspection
(if equipped)
Spark Plug Replacement*
Spark Plug Wire Replacement”
Positive Crankcase Ventilation (PCV) Valve
Reulacement*
Exhaust Gas Recirculation
(EGR) System
Inspection*
WHEN TO PERFORM
Miles (kilomerers) or Months
(whichever occursfirst).
Every 3,000 miles (5 000 km) or 3 months.
Every
6,000 miles (10 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
At 60,000 miles (100 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30,000 miles (50 000 krn) or 30 months.
Every 15,000 miles
(25 000 km) or 15 rnonlhs.
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 3,000 miles (5 000 km) or 3 months.
Every 30,000 miles (50
000 km).
Every
60,000 miles (100 000 km) or 60 months.
Every 50.000 miles
(X3 000 km).
Every 50,000 miles (83 000 km).
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
&planation of Scheduled
Maintenance Services
?allowing are explanations of the services
isted in Schedule
I and Schedule II.
he proper fluids and lubricants to use are
.isted
in Section D. Make sure whoever
rervices your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
~ives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification” in the
Index.
ITEM
NO. SERVICE
1 -e Oil and Filter Change* -
Always use SH or SG Energy
Conserving
II oils of proper
viscosity. The
“SH” or “SG”
designation may be shown
alone, or in combination with
others, such as “SHKD,”
“SH,
SG, CD,” “SG/CD,” etc.
* An Emission Control Service.
ITEM
NO. SERVICE
2
3
4
To determine the preferred
viscosity for your vehicle’s
engine (e.g.,
SAE 5W-30 or SAE
10W-30), see “Engine Oil” in
the Index.
Tire Wheel Rotation and
Jnspectioq
- For proper wear and
maximum tire life, rotate your
tires following the instructions
in this manual. See
“Ties,
Inspection and Rotation’’ in the
Index. Check the tires for
uneven wear or damage.
If you
see irregular or premature wear,
check the wheel alignment.
Check for damaged wheels also.
Fan (Water Pump) Drive Belt
Servk
- Inspect and adjust if
necessary at
30,000 mile
(50 000 km), or 30 month
intervals. Replace the belt at
60,000 miles (100 000 km) and
120,000 miles (200 000 km).
-shaft Timin? Belt
Replacemeat”
- Replace every
60,000 miles (100 000 km) and
ITEM NO.
SERVICE
then inspect after 30,000 miles
(50 000 km).
Drain, flush and refill the system
with new or approved recycled
coolant conforming to
GM
Specification 182SM. Keep
coolant at the proper mixture
as
specified. See “Coolant” in the
Index. This provides proper
freeze and boil protection,
corrosion inhibitor level and
maintains proper engine
operating temperature.
Inspect hoses and replace
if
they are cracked, swollen or
deteriorated. Tighten screw-type
hose clamps. Clean the outside
of the radiator and air
conditioning condenser. Wash
the pressure cap and neck.
To help ensure proper operation,
we recommend a pressure test
of
both the cooling system and the
nressure cap.
5 Coolin? Sys&nSemice* -
. . ,214
ProCarManuals.com

Index
Care Appearance
................. 189
Canvas Top
.................. 193
Cassette Tape Player .......... 97
Compact Discs
............... 98
Safety Belts
................. 191
Case. Transfer ................. 47
Case. Transfer (Service)
.......... 170
and Cornpact Disc Player
..... 94
Player
.................... 90
AM/FM Stereo with ........... 93
Stereo with ................ 89
ofYour
..................... 97
Certification/Tire Label .......... 18 1
Chains. Tire ................... 188
Changing a Flat Tire
............. 146
Charging System Light
.......... 70
Check Engine Light
............. 71
Cassette
Tape. To Play a
AM/FM Stereo with Cassette Tape
AM/FM Stereo with Cassette Tape
Cassette Tape and Compact Disc Player.
Cassette Tape Player. AM/FM
Cassette Tape Player. Care
Checking Things under the
Hood
....................... 159
Checking Your Restraint Systems . . 33
Chemical Paint Spotting
.......... 194
Chevrolet/Geo Roadside Assistance Program
.................... 237
... 244
Chevrolet/Geo Service Publications
(Ordering Information)
........ 240
Child Restraints
.............. 27
Rear Seat
.............. . 28
Right Front Seat
............ 30
Top Strap
................... 28
Where to Put the
.............. 27
Children (Safety Belts)
........... 26
Children. Larger (Safely Belts)
.... 32
Cigarette Lighter ............... 62
Circuit Breakers. Fuses and ....... 196
City Driving ................... I19
Cleaner. Air ................. 165
Cleaning
Aluminum Wheels
........ 193
Canvas Top
.................. 193
Fabric
...................... I90
Glass
....................... 191
Inside of Your Geo ............ 189
Instrument Panel. Top of
....... 19 1
Leather ..................... 19 1
Outside of Your Geo .......... 192
Problems. Special
............. 190
Vinyl
...................... 191
Clock. Setting the ............... 88
Clutch Adjustment
.............. I69
Coinholder and Bin ............. 61
Comfort Controls
............... 84
Comfort Controls and Audio Systems
.................... 83
Windshield and Wiper Blades ... 192 Compact
Disc.
To Play a ......... 95
with Cassette Tape and
......... 93
Compact Disc Player. AM/FM Stereo
Compact Discs. Care
of Your ...... 98
Compartments. Door Storage ...... 60
Compartments. Storage and ....... 60
Control of a Vehicle ............. 102
Control.
Loss of ................ 107
Controls Air Conditioner
.............. 85
Brightness .................. 57
Comfort
.................... 84
Features and
................. 35
Heater ...................... 84
Seat ........................ 10
Convertible Top
................ 72
Convex Outside Mirror
..... 59
Coolant Adding
..................... 171
Heater. Engine ............... 41
Recovery Tank
............. 142
Cooling
....................... 85
Cooling System ................ 141
Courtesy Transportation .......... 237
Cupholder
..................... 61
Curves. Driving on .............. 104
Engine
..................... 170
How to Add
to the Coolant
How to Add
to the Radiator ..... 144
Temperature Gage. Engine ...... 70
ProCarManuals.com

Service Station Information
See Page 163
(I I Ill1 n
Cooling System Reservoir Hood Release
Check and add coolant gdy at the coolant See Page 159
recovery tank. The fluid should be at the
“FULL” mark when the engine is warm.
If the engine is cool, the level should be
at the “LOW” mark or
a little higher.
See Page 170 Windshield Washer
Fluid Reservoir
See Page 174 Engine Oil Dipstick
See Page 162
Battery
Engine Oil Fill Cap
The Delco Freedom“ battery needs
no water. See Page 176
See Tire-Loading Information label on the
inside of the rear edge
of the driver’s door.
See Page 181
Spare Tire Pressure Fuel Cap
See Tire-Loading Information label on the Capacity I1 U.S. Gal. (42 L).
inside of the rear edge of the driver‘s door. LJse unleaded gas only, 87 octane or
See Page 181 higher.
See Page 156
Ill IIII H 1
ProCarManuals.com