coolant level CHRYSLER 300 2011 2.G Owners Manual

•Mix a minimum solution of 50% HOAT engine coolant
and distilled water. Use higher concentrations (not to
exceed 70%) if temperatures below34°F (37°C) are
anticipated.
•Use only high purity water such as distilled or deion-
ized water when mixing the water/engine coolant
(antifreeze) solution. The use of lower quality water
will reduce the amount of corrosion protection in the
engine cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE: Mixing engine coolant (antifreeze) types will
decrease the life of the engine coolant (antifreeze) and
will require more frequent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of coolant,
and to ensure that engine coolant (antifreeze) will return
to the radiator from the coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
(Continued)
7
MAINTAINING YOUR VEHICLE 453

WARNING! (Continued)
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With theengine OFF and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month.
When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the
coolant bottle. Do not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
454 MAINTAINING YOUR VEHICLE

humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, contents of
coolant recovery bottle must also be protected against
freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (antifreeze) (minimum) and distilled water for
proper corrosion protection of your engine, which
contains aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
7
MAINTAINING YOUR VEHICLE 455

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
All Engines 19 Gallons72 Liters
Engine Oil with Filter
3.6 Liter Engine (SAE 5W-30, API Certified) 6 Quarts5.6 Liters
5.7 Liter Engine (SAE 5W-20, API Certified) 7 Quarts6.6 Liters
Cooling System *
3.6 Liter Engine without All Wheel Drive (MOPAR Antifreeze/
Coolant 5 Year/100,000 Mile Formula or equivalent) 11.1 Quarts 10.5 Liters
3.6 Liter Engine with All Wheel Drive (MOPAR Antifreeze/Coolant
5 Year/100,000 Mile Formula or equivalent) 11.4 Quarts 10.8 Liters
5.7 Liter Engine without Severe Duty II Cooling System (MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula or equivalent) 14.7 Quarts 13.9 Liters
5.7 Liter Engine with Severe Duty II Cooling System (MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula or equivalent) 15.1 Quarts 14.3 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
480 MAINTAINING YOUR VEHICLE

Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering, and add as
needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S486 MAINTENANCE SCHEDULES

ConnectorUCI .............................. 299
Universal Consumer Interface (UCI) ....... 299
Conserving Fuel ........................ 278
Console, Floor .......................... 246
Console, Overhead ....................... 221
Contract, Service ........................ 505
Coolant Pressure Cap (Radiator Cap) .......... 453
Cooling System ......................... 450
Adding Coolant (Antifreeze) ............. 452
Coolant Capacity ..................... 480
Coolant Level .................... 451,454
Disposal of Used Coolant ............... 454
Drain, Flush, and Refill ................ 451
Inspection .......................... 454
Points to Remember .................. 454
Pressure Cap ........................ 453
Radiator Cap ....................... 453
Selection of Coolant (Antifreeze) ....451,480,481 Corrosion Protection
..................... 461
Cruise Control (Speed Control) .............. 186
Cupholders ......................... 242,466
Customer Assistance ..................... 503
Data Recorder, Event ...................... 70
Daytime Brightness, Interior Lights ........... 173
Daytime Running Lights ................... 166
Dealer Service .......................... 435
Deck Lid, Emergency Release ................ 42
Deck Lid, Power Release ................... 41
Defroster, Rear Window ................... 250
Defroster, Windshield ................... 84,306
Delay (Intermittent) Wipers ................. 174
Diagnostic System, Onboard ................ 433
Dimmer Switch, Headlight ................. 169
Dipsticks Oil (Engine) ........................ 437
Disabled Vehicle Towing ................... 425
10
INDEX 515

Break-In Recommendations.............. 81
Checking Oil Level ................... 437
Compartment .................... 431,432
Compartment Identification ............. 431
Coolant (Antifreeze) ................ 451,481
Cooling ........................... 450
Exhaust Gas Caution ................83,384
Fails to Start ........................ 321
Flooded, Starting ..................... 321
Fuel Requirements .................... 380
Jump Starting ....................... 418
Multi-Displacement ................... 335
Oil ......................... 437,480,481
Oil Change Interval ................ 277,438
Oil Filler Cap .................... 438,439
Oil Filter ........................... 440
Oil Filter Disposal .................... 440
Oil Selection ..................... 438,480
Oil Synthetic ........................ 439 Overheating
........................ 408
Starting ........................... 318
Temperature Gauge ................... 267
Engine Oil Viscosity ................... 438,439
Enhanced Accident Response Feature .......... 66
Entry System, Illuminated .................. 20
Ethanol ............................... 381
Event Data Recorder ...................... 70
Exhaust Gas Caution ................... 83,384
Exhaust System ....................... 83,448
Exterior Folding Mirrors ................... 95
Exterior Lighting ........................ 164
Exterior Lights .......................... 86
Filler Location Fuel ...................... 264
Filters Air Cleaner ......................... 440
Air Conditioning .................. 31 1,444
Engine Oil ....................... 440,481
10
INDEX 517