overheating CHRYSLER 300 SRT 2005 1.G Owners Manual

complete the programming of a rolling code equipped
device (most common garage door openers require this
step.
6. At the garage door opener receiver (motor-head unit)
in the garage, locate thelearnorsmartbutton. This
can usually be found where the hanging antenna wire is
attached to the motor-head unit.
7. Firmly press and release thelearnorsmartbutton.
(The name and color of the button may vary by manu-
facturer.)
NOTE:There are 30 seconds in which to initiate step
eight.
8. Return to the vehicle and firmlypress, hold for two
seconds and releasethe programmed HomeLink button.
Repeat thepress/hold/releasesequence a second time,
and, depending on the brand of the garage door opener
(or other rolling code equipped device), repeat this
sequence a third time to complete the programming.
HomeLink should now activate your rolling code
equipped device.
NOTE:To program the remaining two HomeLink but-
tons, begin withProgrammingstep two. Do not repeat
step one. For questions or comments, please contact
HomeLink atwww.homelink.com or 1-800-355-3515.
Canadian Programming/Gate Programming
Canadian radio-frequency laws require transmitter sig-
nals totime-out(or quit) after several seconds of
transmission which may not be long enough for
HomeLink to pick up the signal during programming.
Similar to this Canadian law, some U.S. gate operators are
designed totime-outin the same manner.
If you live in Canada or you are having difficulties
programming a gate operator by using theProgram-
mingprocedures (regardless of where you live),replace
Programming HomeLinkstep 3with the following:
NOTE:If programming a garage door opener or gate
operator, it is advised to unplug the device during the
cyclingprocess to prevent possible overheating.
3. Continue to press and hold the HomeLink button
while youpress and release every two seconds(cycle)
your hand-held transmitter until the frequency signal has
successfully been accepted by HomeLink. The EVIC
118 UNDERSTANDING THE FEATURES OF YOUR VEHICLE

ON. The defroster automatically turns off after approxi-
mately 10 minutes of operation for the first push of the
button, and will turn off after approximately 5 minutes
for the second push of the button.
CAUTION!
To avoid damaging the electrical conductors of the
rear window defroster, do not use scrapers, sharp
instruments, or abrasive window cleaners on the
interior surface of the window.
Labels can be peeled off after soaking with warm
water.
This button can be used to block out smoke,
odors, dust, high humidity, or if rapid cooling
is desired. The recirculation mode should only
be used temporarily. The button includes an
LED that illuminates, and an audible beep indicates that
the recirculation mode is active. You may use this feature
separately.
NOTE:Extended use of recirculation may cause the
windows to fog. If the interior of the windows begins to
fog, press the “Recirculate” icon button to return to
outside air. Some temp./humidity conditions will cause
captured interior air to condense on windows and ham-
per visibility. For this reason, the system will not allow
“Recirculate” to be selected while in the defrost or
defrost/floor modes. Attempting to use the recirculation
while in these modes will cause the LED in the button to
blink and then turn off.
Summer Operation
The engine cooling system in air conditioned vehicles
must be protected with a high-quality antifreeze coolant
to provide proper corrosion protection and to protect
against engine overheating. A 50% solution of ethylene
glycol antifreeze coolant in water is recommended. Refer
to section 7, Maintenance Procedures, of this manual for
proper coolant selection.
176 UNDERSTANDING YOUR INSTRUMENT PANEL

IF YOUR ENGINE OVERHEATS
In any of the following situations, you can reduce the
potential for overheating by taking the appropriate ac-
tion.
•On the highways — Slow down.
•In city traffic — While stopped, put transmission in
neutral, but do not increase engine idle speed.
NOTE:There are steps that you can take to slow down
an impending overheat condition. If your air conditioner
is on, turn it off. The air conditioning system adds heat to
the engine cooling system and turning off the A/C
removes this heat. You can also turn the Temperature
control to maximum heat, the Mode control to floor, and
the fan control to High. This allows the heater core to act
as a supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If temperature gauge reads “H”, pull
over and stop the vehicle. Idle the vehicle with the
air conditioner turned off until the pointer drops
back into the normal range. If the pointer remains on
the “H”, turn the engine off immediately, and call for
service.
WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call a service center if your
vehicle overheats. If you decide to look under the
hood yourself, see Section 7, Maintenance, of this
manual. Follow the warnings under the Cooling
System Pressure Cap paragraph.
WHAT TO DO IN EMERGENCIES 225
6

5.Unscrew the valve cap from the valve on the deflated tire.
6. Screw the filler hose (6) from the sealant bottle (5) on
the tire valve.
7. Insert the power plug (2) into the power point on the
instrument panel.
8. Turn the ignition key to the ON/RUN position.
9. Press the switch (3) on the air pump to 1. The air pump
should start to inflate the tire.
10. After five minutes, the tire should be inflated to at
least 26 psi (1.8 bar) on the pressure gauge (4).
11. If the tire doesn’t inflate to this level, press the air
pump switch (3) to 0, disconnect the TIREFIT system
from the tire, and drive the vehicle back and forth
approximately 30 feet (9.1 m) to distribute the sealant
more evenly within the tire.
12. Attach the air pump hose (1) directly to the tire, press
the switch (3) to 1, and inflate the tire again.NOTE:If a
tire pressure of 26 psi (1.8 bar) is not reached after five
minutes, the tire is too badly damaged. Do not attempt to
drive the vehicle further, and call for assistance.13. If a tire pressure of 26 psi (1.8 bar) is obtained, press
the air pump switch (3) to 0, turn the ignition switch to
the OFF/LOCK position, and disconnect the TIREFIT
system.
14. Drive the vehicle for about 10 minutes to ensure
optimum distribution of the tire sealant within the tire.
15. Check the pressure in the tire. If the pressure is above
19 psi (1.3 bar), inflate the tire to the pressure indicated
on the tire pressure label on the driver side latch pillar.
16. Have the tire inspected at the earliest opportunity at
an authorized dealer or tire service center.
NOTE:
•
If a pressure of at least 19 psi (1.3 bar) cannot be
maintained in the tire, the tire is too badly damaged.
Do not attempt to drive the vehicle further, and call for
assistance.
•Do not operate the electric air pump for more than
eight minutes to avoid overheating. The air pump may
be used again once it has cooled down.
228 WHAT TO DO IN EMERGENCIES

WARNING!
Fast spinning tires can be dangerous. Forces gener-
ated by excessive wheel speeds may cause tire dam-
age or failure. A tire could explode and injure
someone. Do not spin your vehicle’s wheels faster
than 35 mph (55 km/h) when you are stuck. And
don’t let anyone near a spinning wheel, no matter
what the speed.
CAUTION!
Racing the engine or spinning the wheels too fast
may lead to transmission overheating and failure. It
can also damage the tires. Do not spin the wheels
above 35 mph (55 km/h).
TOWING A DISABLED VEHICLE
With Ignition Key
Your vehicle may be towed under the following condi-
tions: The gear selector must be in NEUTRAL, the
distance to be traveled must not exceed 30 miles (48 km),
and the towing speed must not exceed 30 mph (48
km/h). Exceeding these towing limits may cause a trans-
mission geartrain failure. If the transmission is not op-
erative, or if the vehicle is to be towed more than 30 miles
(48 km), the vehicle must be transported using a flat bed
or the drive shaft disconnected at the rear axle drive
flange.
WHAT TO DO IN EMERGENCIES 233
6

WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may indicate severe
and abnormal catalyst overheating. If this occurs, the
vehicle should be stopped, the engine shut off and the
vehicle allowed to cool. Thereafter, service, including a
tune-up to manufacturer’s specifications, should be ob-
tained immediately.To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idling or malfunctioning operating conditions.
246 MAINTAINING YOUR VEHICLE

Cooling System........................ 252
Adding Coolant (Antifreeze)............. 253
Coolant Capacity..................... 275
Coolant Level.....................252,255
Disposal of Used Coolant............... 255
Drain, Flush, and Refill................. 252
Inspection........................... 255
Points to Remember................... 255
Pressure Cap........................ 254
Radiator Cap........................ 254
Selection of Coolant.............253,275,276
Cruise Control (Speed Control)............. 111
Cup Holder........................125,264
Customer Assistance.................... 294
Data Recorder, Event..................... 47
Dealer Service......................... 240
Defroster, Windshield..................57,175
Delay (Intermittent) Wipers............... 104
Diagnostic System, Onboard............... 238
Dimmer Switch, Headlight................ 101
Disposal
Antifreeze (Engine Coolant)............. 255Door Locks............................ 15
Door Locks, Automatic................... 17
Door Opener, Garage.................... 115
Drive Belts............................ 244
Driver’s Seat Glide Feature................ 91
Driving
On Slippery Surfaces.................. 231
Electric Remote Mirrors................... 64
Electrical Power Outlets.................. 123
Electronic Speed Control.................. 111
Electronic Stability Program............... 109
Electronic Vehicle Information Center........ 140
Emergency, In Case of
Freeing Vehicle When Stuck............. 232
Hazard Warning Flasher................ 224
Jump Starting........................ 229
Overheating......................... 225
Towing............................. 233
Emission Control System Maintenance....239,278
Engine............................... 237
Air Cleaner.......................... 245
Air Cleaner Filter..................... 244
306 INDEX

Break-In Recommendations............... 56
Checking Oil Level.................... 241
Compartment........................ 237
Coolant (Antifreeze)................252,276
Cooling............................ 252
Exhaust Gas Caution................56,217
Fails to Start......................... 182
Fuel Requirements.................214,275
Oil ..........................241,275,276
Oil Change Interval................... 242
Oil Selection......................242,275
Overheating......................... 225
Temperature Gauge................... 137
Engine Oil Viscosity..................... 243
Engine Oil Viscosity Chart................ 243
Enhanced Accident Response Feature......... 46
Event Data Recorder..................... 47
Exhaust Gas Caution...............56,217,251
Exhaust System........................ 251
Exterior Folding Mirrors.................. 64
Filters
Air Cleaner.......................... 244Air Conditioning..................177,249
Engine Fuel......................... 245
Engine Oil.......................243,276
Engine Oil Disposal................... 243
Flashers
Hazard Warning...................... 224
Turn Signal.......................... 134
Flash-To-Pass.......................... 101
Floor Console.......................... 126
Fluid Capacities........................ 275
Fluid Leaks............................ 58
Fluid Level Checks
Brake.............................. 258
Cooling System....................... 252
Engine Oil.......................... 241
Power Steering....................... 249
Fluids............................... 276
Fog Lights.........................101,134
Folding Rear Seat....................... 93
Freeing A Stuck Vehicle.................. 232
Fuel................................. 214
Adding............................. 218
Additives........................... 216
INDEX 307
10

Multi-Function Control Lever............... 99
Navigation System...................... 166
New Vehicle Break-In Period............... 56
Occupant Restraints...................... 28
Oil, Engine.........................241,276
Capacity............................ 275
Change Interval...................... 242
Checking........................... 241
Disposal............................ 243
Filter...........................243,276
Filter Disposal....................... 243
Materials Added to.................... 243
Recommendation..................242,275
Viscosity............................ 275
Onboard Diagnostic System............238,239
Opener, Garage Door.................... 115
Operator Manuals (Owner’s Manuals)......... 4
Overhead Console...................... 114
Overheating, Engine..................137,225
Owner’s Manual......................4,299Panic Alarm........................... 20
Park Assist System, Rear.................. 85
Parking Brake......................... 191
Parking On Hill........................ 192
Passing Light.......................... 101
Pedals, Adjustable....................... 94
Personal Settings....................... 147
Pets.................................. 55
Phone, Cellular......................... 66
Phone, Hands-Free....................... 66
Placard, Tire and Loading Information....... 201
Power
Brakes............................. 193
Distribution Center.................... 264
Door Locks.......................... 16
Mirrors............................. 64
Outlet.............................. 123
Seats............................... 87
Steering............................ 196
Steering, Checking.................... 249
Sunroof............................ 120
Tilt/Telescoping Steering Column......... 106
Windows............................ 23
INDEX 311
10