maintenance schedule CHRYSLER PACIFICA 2004 1.G User Guide

MAINTENANCE SCHEDULES
CONTENTS
mEmission Control System Maintenance........316
mMaintenance Schedules...................316NSchedule ªBº........................319
NSchedule ªAº........................330
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

EMISSION CONTROL SYSTEM MAINTENANCE
The ªScheduledº maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is ScheduleªBº. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.L
316 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBº of the
9Maintenance Schedules9section of this manual.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.NOTE:Under no circumstances should oil change in-
tervals exceed 6000 miles (10 000 km) or 6 months
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 317
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant bottle, brake master
cylinder and transmission, add as needed.
²Check all lights and all other electrical items for correct
operation.
At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints and front suspension compo-
nents.
²Check the automatic transmission fluid level.
²Check the coolant level, hoses, and clamps.
²Rotate the tires at each oil change interval shown on
Schedule ªAº 6,000 miles (10 000 km) or every other
interval shown on Schedule ªBº 6,000 miles (10 000
km).
318 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE ªBº
Follow schedule ªBº if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with anL.
²Day or night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.L
²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule ªBº of the
9Maintenance Schedules9section of this manual.
If none of these apply to you, then change your engine oil
at every interval shown on schedule9A9of the9Mainte-
nance Schedules9section of this manual.
SCHEDULE ªBº 319
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.NOTE:The AWD power transfer unit fluid and the
AWD overrunning clutch/ rear carrier fluid must be
changed at the more frequent intervals shown in sched-
ule B if the vehicle is operated under any of the condi-
tions noted by a diamond (L) at the beginning of the
schedule.
SCHEDULE ªBº 329
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Change engine oil and engine oil filter. X X X X
Inspect the brake linings. X
Inspect the engine air cleaner filter, replace if necessary. * X X X
Replace theengine air cleaner filter.X
Inspect the tie rod ends and boot seals. (Front & Rear) X
Check thePCV valveand replace, if necessary.* X
Inspect the serpentine drive belt, replace if necessary. ³ X X
Flush and replace the engine coolant at 120 months, if not
done at 100,000 miles (160 000 km).X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE ªAº 333
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Load Leveling System.................... 132
Loading Vehicle......................241,243
Capacities........................... 243
Tires ............................... 218
Locks
Door................................ 16
Lower Anchors and Tether for CHildren
(LATCH)............................53,55
Lubrication, Body....................... 284
Luggage Rack.......................... 130
Maintenance Free Battery.................. 279
Maintenance Procedures................... 272
Maintenance Schedule.................... 316
Light Duty Schedule9A9................. 330
Light Duty Schedule9B9................. 319
Schedule9A9......................... 330
Schedule9B9.......................... 319
Malfunction Indicator Light..............143,270Manual, Service......................... 340
Memory Seat..........................72,88
Mini-Trip Computer...................... 153
Mirrors................................ 69
Automatic Dimming..................... 70
Electric Remote........................ 72
Exterior Folding........................ 70
Heated.............................. 72
Memory............................. 88
Outside.............................. 71
Rearview............................. 69
Vanity............................... 73
Modifications/Alterations, Vehicle............. 7
Monitor, Tire Pressure System............... 230
Mopar Parts.........................271,339
Multi-Function Control Lever............... 103
Navigation System....................... 182
New Vehicle Break-In Period................ 61
354 INDEX

Roof Rack............................. 130
Rotation, Tires.......................... 234
Safety Checks Inside Vehicle................. 62
Safety Checks Outside Vehicle............... 63
Safety, Exhaust Gas....................... 29
Safety Information, Tire................... 213
Safety Tips............................. 62
Schedule, Maintenance.................... 316
Seat Belt Maintenance.................... 304
Seat Belt Reminder....................... 40
Seat Belts.............................. 31
Adjustable Shoulder Belt.................. 37
Adjustable Upper Shoulder Anchorage........ 37
And Pregnant Women................... 41
Child Restraint......................... 53
Extender............................. 42
Front Seat............................ 32
Pretensioners.......................... 40Rear Seat............................. 32
Reminder............................ 144
Untwisting Procedure.................... 38
Seats................................. 85
Adjustment........................... 92
Easy Entry............................ 93
Heated.............................. 86
Memory............................. 88
Power............................... 85
Reclining............................. 91
Tilting............................... 93
Security Alarm.......................... 24
Selection of Coolant...................... 312
Sentry Key............................. 12
Service Assistance....................... 336
Service Contract......................... 338
Service Engine Soon Light................. 143
Service Manuals........................ 340
Setting the Clock........................ 154
INDEX 357
10