engine coolant CHRYSLER SEBRING 2010 3.G User Guide

WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposalrules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
Four-Cylinder Engines –
the coolant bottle provides a
quick visual method for determining that the engine
coolant (antifreeze) level is adequate. With the engine
idling and warm to normal operating temperature, the
level of the engine coolant (antifreeze) in the bottle
should be between the “ADD” and “FULL” lines, shown
on the bottle.
Six-Cylinder Engines – the level of the engine coolant
(antifreeze) in the pressurized coolant bottle should be
between the “COLD” and “FULL” range on the bottle
when the engine is cold.
364 MAINTAINING YOUR VEHICLE

The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month. When addi-
tional engine coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator. If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, the contents of
the coolant recovery bottle must also be protected
against freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
7
MAINTAINING YOUR VEHICLE 365

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
All Engines — (Except 2.4L PZEV) 16.9 Gallons64 Liters
2.4L PZEV (Partial Zero Emissions Vehicle) 18.5 Gallons70 Liters
Engine Oil with Filter
2.4L Engine (SAE 5W-20, API Certified) 4.5 Quarts4.4 Liters
2.7L Engine (SAE 5W-20, API Certified) 5.5 Quarts5.2 Liters
3.5L Engine (SAE 10W-30, API Certified) 5.5 Quarts5.2 Liters
Cooling System*
2.4L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 7.7 Quarts
7.3 Liters
2.7L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 9.8 Quarts
9.3 Liters
3.5L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 11.6 Quarts
11 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
392 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid
Organic Additive Technology) or equivalent.
Engine Oil – 2.4L and 2.7L En-
gines Use API Certified SAE 5W-20 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to your engine oil filler cap for
correct SAE grade.
Engine Oil – 3.5L Engine Use API Certified SAE 10W-30 Engine Oil, meeting Chrysler Material Stan-
dard MS-6395. Refer to your engine oil filler cap for correct SAE grade.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs – 2.4L Engine except
PZEV* ZFR5F-11 (Gap 0.043 in [1.11 mm])
Spark Plugs – 2.4L with PZEV* ZFR5AP (Gap 0.031 in [0.8 mm])
7
MAINTAINING YOUR VEHICLE 393

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S398 MAINTENANCE SCHEDULES

102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Replace the spark plugs (2.4L PZEV*,
2.7L and 3.5L Engines).
❏ Replace the timing belt (3.5L Engine).
❏ Flush and replace the engine coolant.
❏ Inspect accessory drive belt, replace if
necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
108,000 Miles (180,000 km) or 108 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and
replace if necessary.
❏ Inspect the brake linings, and replace as necessary.
❏ Replace the air conditioning filter (if equipped).
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 407

About Your Brakes....................... 254
ABS (Anti-Lock Brake System) .............. 256
Adding Engine Coolant (Antifreeze) .......... 362
Adding Fuel ........................... 303
Adding Washer Fluid ..................... 358
Additives, Fuel ......................... 297
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 352
Air Conditioner Maintenance ............... 354
Air Conditioning ........................ 219
Air Conditioning Controls ................. 219
Air Conditioning Filter .................230,355
Air Conditioning, Operating Tips ............ 231
Air Conditioning Refrigerant .............354,355
Air Conditioning System .............219,223,354
Air Pressure, Tires ....................... 277
Airbag .............................. 53,63
Airbag Deployment ....................... 64
Airbag Light ..................... 62,67,82,146
Airbag Maintenance ....................... 66 Airbag, Side
........................ 56,60,63
Airbag, Window (Side Curtain) ...........57,60,63
Alarm System (Security Alarm) ............18,153
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 212
Antifreeze (Engine Coolant) ..............362,392
Disposal ............................ 364
Anti-Lock Brake System (ABS) .............. 256
Anti-Lock Warning Light .................. 256
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Appearance Care ........................ 371
Ashtray ............................... 131
Auto Down Power Windows ................ 34
Auto Unlock, Doors ....................... 31
Auto Up Power Windows ................35,128
Automatic Dimming Mirror ................. 90
Automatic Door Locks ................... 30,31
Automatic Oil Change Indicator ........151,161,396
Automatic Temperature Control (ATC) ......... 223
424 INDEX

Automatic Transaxle..............12,238,241,368
Adding Fluid ................... 369,370,394
Filter ............................... 370
Fluid and Filter Changes ................. 370
Fluid Level Check ................... 369,370
Interlock System .................... 243,244
Reset Mode .......................... 247
Selection Of Lubricant ................... 394
Shifting ............................. 241
Special Additives ...................... 370
Autostick ............................. 248
Back-Up Lights ......................... 387
Battery ............................... 352
Jump Starting ......................... 29
Keyless Transmitter Replacement (RKE) ....... 25
Location ............................ 352
Belts, Seat .............................. 82
Body Mechanism Lubrication ............... 356B-Pillar Location
........................ 272
Brake Assist System ...................... 260
Brake, Parking .......................... 254
Brake System ........................... 366
Anti-Lock (ABS) ....................... 256
Fluid Check ....................... 366,394
Master Cylinder ....................... 366
Parking ............................. 254
Warning Light ........................ 147
Brakes ............................... 366
Brake/Transaxle Interlock .................. 243
Break-In Recommendations, New Vehicle ........ 79
Bulb Replacement ..................... 382,383
Bulbs, Light .......................... 84,382
Calibration, Compass ..................... 164
Capacities, Antifreeze (Engine Coolant) ......... 20
Capacities, Fluid ........................ 392
10
INDEX 425

Caps, FillerFuel ............................... 303
Oil (Engine) .................. 341,342,343,350
Power Steering ........................ 253
Radiator (Coolant Pressure) ............... 363
Car Washes ............................ 372
Carbon Monoxide Warning ...............81,298
Cargo Area Features ...................... 134
Cargo Compartment ...................... 134
Cargo Load Floor ........................ 134
Cargo (Vehicle Loading) ................... 134
Cellular Phone ........................ 93,219
Center High Mounted Stop Light ............ 391
Chains, Tire ............................ 283
Changing A Flat Tire ..................... 323
Chart, Tire Sizing ........................ 268
Check Engine Light
(Malfunction Indicator Light) ............... 345
Checking Your Vehicle For Safety ............. 80Checks, Safety
........................... 80
Child Restraint .................... 69,71,75,78
Child Restraint Tether Anchors .............73,75
Child Safety Locks ........................ 32
Cigar Lighter ........................... 131
Clean Air Gasoline ....................... 295
Cleaning Wheels ............................. 373
Windshield Wiper Blades ................ 357
Climate Control ......................... 219
Clock .................. 169,171,186,187,190,200
Coin Holder ........................... 135
Compact Disc (CD) Maintenance ............. 218
Compact Spare Tire ...................... 279
Compass .............................. 163
Compass Calibration ..................... 164
Compass Variance ....................... 165
Computer, Trip/Travel .................. 20,162
Console ............................ 103,135
426 INDEX

Console, Floor....................... 103,135
Contract, Service ........................ 417
Coolant Pressure Cap (Radiator Cap) .......... 363
Cooling System ......................... 361
Adding Coolant (Antifreeze) .............. 362
Coolant Capacity ...................... 392
Coolant Level ...................... 361,364
Disposal of Used Coolant ................ 364
Drain, Flush, and Refill .................. 361
Inspection ........................... 364
Points to Remember .................... 365
Pressure Cap ......................... 363
Radiator Cap ......................... 363
Selection of Coolant (Antifreeze) ......362,392,393
Corrosion Protection ..................... 371
Crankcase Ventilation Module ............... 20
Cruise Control (Speed Control) .............. 117
Cruise Light ........................... 152
Cupholders ...................... 103,132,376Customer Assistance
..................... 415
Customer Programmable Features ............ 166
Daytime Running Lights ................... 109
Dealer Service .......................... 346
Deck Lid, Power Release ................... 36
Defroster, Rear Window ................... 138
Defroster, Windshield ................82,221,227
Delay (Intermittent) Wipers ...............29,113
Diagnostic System, Onboard ................ 344
Dimmer Switch, Headlight ................. 108
Dipsticks Automatic Transaxle ................. 369,370
Oil (Engine) .......................... 348
Power Steering ........................ 253
Disabled Vehicle Towing ................... 335
Disposal Antifreeze (Engine Coolant) ............... 364
Engine Oil ........................... 351
10
INDEX 427