suspension Citroen BERLINGO 2005 1.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine PRESENTATION
THIS HANDBOOKsummarises the specifications, adjustments, checks and special features of CITROËN private vehicles, not including UTILITY vehicles for which there exists a separate
handbook.
The handbook is divided into groups representing the main functions:
GENERAL - ENGINE - INJECTION - IGNITION - CLUTCH, GEARBOX, DRIVESHAFTS - AXLES, SUSPENSION, STEERING - BRAKES - AIR CONDITIONING.
In each section, the vehicles are dealt with in the following order: C4 - XSARA - XSARA PICASSO - BERLINGO and all models where applicable.
The information given in this handbook is based on vehicles marketed in EUROPE.
Angl-t2-Index-2005 9/01/06 10:05 Page I

Downloaded from www.Manualslib.com manuals search engine CLUTCH - GEARBOX - TRANSMISSION (continued)
Gearbox specifications312 - 314
Clutch specifications315 - 316
Checking and adjusting the hydraulic
clutch control317 - 318
Tightening torques: manual gearbox
319 - 330
Manual gearbox controls
331 - 343
Recommendations - precautions:
automatic gearbox344 - 346
Tightening torques: manual gearbox
347 - 349
Automatic gearbox controls
350 - 359
Driveshafts360
AXLES - SUSPENSION - STEERING
Axle geometry: C4361 - 364
Tightening torques: front axle365 - 366
Tightening torques: rear axle367
Tightening torques: power steering368 - 369
Setting the steering rack mid-point370
Checking the power steering pressure371 - 374
Axle geometry: Xsara375 - 379Adjusting the handbrake 426
Filling, bleeding the brakes427
AIR CONDITIONING
R134.a: quantities428
Checking the compressor lubricant429 - 430
Pollen filter: all types431 - 433
Filtering and drying cartridge434 - 436
Checking the efficiency of the circuit437 - 446
C4447 - 451
Xsara452
Xsara picasso453 - 456
CONTENTS
Tightening torques: front axle380
Tightening torques: rear axle382
Tightening torques: steering 383 - 384
Tightening torques: power steering385 - 387
Axle geometry: Xsara Picasso388 - 392
Tightening torques: front axle393
Tightening torques: rear axle394
Tightening torques: power steering395 - 397
BRAKES
Brake specifications: C4398 - 399
Tightening torques: Brakes401 - 403
Adjusting the handbrake 405
Filling, bleeding the brakes406 - 410
Brake specifications: Xsara411
Tightening torques 414
Brake specifications415 - 418
Adjusting the handbrake 419
Filling, bleeding the brakes420
Brake specifications: Xsara Picasso421 - 422
Brake specifications423 - 424
Aircon circuit
Angl-t2-Index-2005 9/01/06 10:05 Page IV

Downloaded from www.Manualslib.com manuals search engine 10
GENERAL
Draining methods
Oil capacities are defined according to the following methods
CAPACITIES (in litres)
Draining of the engine lubrication system by GRAVITY
Place the vehicle on horizontal ground
(in the high position if
hydropneumatic suspension)
.
The engine should be hot
(oil temperature 80°C).
Drain the sump by gravity.
Remove the oil filter cartridge
(time for draining and drip-drip = 15
minutes approx.)
.
Refit the cap with a new seal.
Refit a new oil filter cartridge.
Refill the engine with oil
(see table for oil capacity).
Start the engine to fill the oil filter cartridge.
Stop the engine
(allow to stabilise for 5 minutes).Draining of the engine lubrication system by SUCTION
Place the vehicle on horizontal ground
(in the high position if
hydropneumatic suspension).
The engine should be hot (oil temperature 80°C).
Remove the oil by suction through the dipstick tube.
Remove the oil filter cartridge.
Maintain the suction of oil in the sump
(15 minutes approx.).
Refit a new oil filter cartridge.
Refill the engine with oil
(see table for oil capacity).
Start the engine to fill the oil filter cartridge.
Stop the engine
(allow to stabilise for 5 minutes).
WARNING: Remove the suction container before starting the engine.
ESSENTIAL: Systematically check the oil level using the oil dipstick.
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 10

Downloaded from www.Manualslib.com manuals search engine 37
GENERAL
LUBRICANTS - TOTAL recommended oils
BRAKE FLUID
Synthetic brake fluid
HYDRAULIC SYSTEM
WARNING: TOTAL FLUIDE LDS fluid cannot be blended withTOTAL LHM PLUS.
WARNING: CITROËN C5: Use exclusively TOTAL FLUIDE LDS suspension fluid.
All countriesTOTAL HYDRAURINCAGE
All countriesCITROËN fluid0,5Litre
1 Litre
5 Litres9979 05
9979 06
9979 07 PacksCITROËN Part No.
PacksCITROËN Part No.
Norm
Colour All countries
TOTAL FLUIDE LDS
TOTAL LHM PLUS
TOTAL LHM PLUS
Very cold countriesOrange 9979 A3
9979 A1
9979 A2 Green1 Litre
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 37

Downloaded from www.Manualslib.com manuals search engine Gearbox under the engine
SPECIAL FEATURES - TIGHTENINGING TORQUES (m.daN)
1 6 ± 0,6
2 6 ± 0,1
3 4,5 ± 0,4
11 4 ± 0,4
12 4 ± 0,4
13 4 ± 0,4
14 4 ± 0,4
15 4 ± 0,4
16 2 ± 0,2
17 4 ± 0,4
18 5,4 ± 0,5
B1BP36BD
Suspensions for engine/gearbox assembly
46
ENGINE
Engine: KFU
Gearbox on RH side Gearbox on LH side
B1BP36DD
B1BP36CD
4 1 ± 0,2
5 1,8 ± 0,2
6 2 ± 0,2
7 3 ± 0,3
8 1,9 ± 0,1
9 2,5 ± 0,2
10 6,5 ± 0,6
C4
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 46

Downloaded from www.Manualslib.com manuals search engine 54
Gearbox below the engine
SPECIAL FEATURES - TIGHTENING TORQUES (m.daN)
1 6 ± 0,62 6 ± 0,63 4,5 ± 0,4
13 4 ± 0,414 4 ± 0,415 5,4 ± 0,516 6 ± 0,617 4 ± 0,418 6 ± 0,619 2 ± 0,220 4 ± 0,421 4 ± 0,4
B1BP35WD
Suspensions for engine/gearbox assembly
Engine: NFU
Gearbox on RH side Gearbox on LH side
B1BP35YD
B1BP35XD
4 1,8 ± 0,25 2 ± 0,26 6,5 ± 0,67 1,9 ± 0,18 4 ± 0,49 3 ± 0,310 1,8± 0,211 1 ± 0,2
12 2,5 ± 0,2
(A)MA manual gearbox
(B)AL4 automatic gearbox
ENGINEC4
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 54

Downloaded from www.Manualslib.com manuals search engine 61
ENGINE
SPECIAL FEATURES - TIGHTENING TORQUES (m.daN)
1 6 ± 0,62 6 ± 0,63 4,5 ± 0,4
7 1 ± 0,18 5 ± 0,59 6,5 ± 0,610 3 ± 0,311 3 ± 0,312 6 ± 0,613 1,9 ± 0,2
B1BP35TD
Suspensions for engine/gearbox assembly
Engine: RFJ
RH side Torque reaction rod
B1BP35VD
B1BP35UD
4 4,5 ± 0,45 3,9 ± 0,46 5,4 ± 0,6
C4
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 61

Downloaded from www.Manualslib.com manuals search engine 75
ENGINE
SPECIAL FEATURES - TIGHTENING TORQUES (m.daN)
1 6 ± 0,62 6 ± 0,63 4,5 ± 0,4
7 1 ± 0,18 5 ± 0,59 6,5 ± 0,610 3 ± 0,311 3 ± 0,312 6 ± 0,613 1,9 ± 0,2
B1BP35TD
Suspensions for engine/gearbox assembly
Engine: RFN
Gearbox on RH side Gearbox at torque reaction rod
B1BP35VD
B1BP35UD
4 4,5 ± 0,45 3,9 ± 0,46 5,4 ± 0,6
Gearbox on LH side
C4
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 75

Downloaded from www.Manualslib.com manuals search engine 85
ENGINE
SPECIAL FEATURES - TIGHTENING TORQUES (m.daN)
1 6 ± 0,62 6 ± 0,63 4,5 ± 0,4
7 1 ± 0,18 5 ± 0,59 6,5 ± 0,610 3 ± 0,311 3 ± 0,312 6 ± 0,613 1,9 ± 0,2
B1BP35TD
Suspensions for engine/gearbox assembly
Engine: RFK
Gearbox on RH side Gearbox at torque reaction rod
B1BP35VD
B1BP35UD
4 4,5 ± 0,45 3,9 ± 0,46 5,4 ± 0,6
Gearbox on LH side
C4
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 85

Downloaded from www.Manualslib.com manuals search engine 99
ENGINE
Impact absorber LH engine support on gearbox
SPECIAL FEATURES - TIGHTENING TORQUES (m.daN)
1 6 ± 0,6
2 5,5 ± 0,5
3 6 ± 0,6
7
8
9 4 ± 0,4
10
11
B1BP38CC
Suspensions for engine/gearbox assembly
Engines: 9HX - 9HY - 9HZ
RH engine support Torque reaction rod
B1BP38EC
B1BP38DC
4 6 ± 0,6
5 3,9 ± 0,4
6 5,4 ± 0,8
12 2 ± 0,3
13 6,5 ± 0,6
14 3 ± 0,3
15 6 ± 0,6
16 2 ± 0,2
B1BP38FC
C4
Angl.-t2-page040-134-2005 9/01/06 10:11 Page 99