towing CITROEN BERLINGO FIRST 2011 Handbook (in English)

Page 5 of 132

3CONTENTS
-
109 - 120  AUDIO
Audio system 109
121 - 128  VISUAL INDEX 56 - 61  LIFE ON BOARD
Front layout 56
Courtesy lights 57
Headlamp adjustment 58
Steering wheel adjustment 58
Lashing rings 59
Rear layout 60
62 - 69  DRIVING
Handbrake 62
ABS and EBFD systems 62
Speed limiter 63
Cruise control 65
Airbags 67
70 - 95  PRACTICAL INFORMATIONUnder the bonnet 70
Levels 75
Checks 76
Changing a wheel 77
Changing a bulb 80
Changing a fuse 86
Battery 90
Energy economy mode 90
Fitting audio equipment,
speakers 91
Snow screen 92
Towing 93
Towing a trailer 94
Accessories 95
96 - 108  TECHNICAL DATA
Dimensions 96
Engines 100
Light van weights and loads 104
Ludospace weights
and loads 106
Identifi cation features 108

Page 17 of 132

15 FAMILIARISATION
-
REAR FITTINGS



Stowing rings
For greater safety, always en-
sure that the loads transported
are secured fi rmly.



59



1.
Load space cover.

2.
High load retaining net.

3.
Stowing rings.

4.
Side door storage compartment.

5.
Trays between the front and rear
seats.

6.
Seat back storage pockets.



60

Page 63 of 132

61 LIFE ON BOARD-

1. Load-space cover
To install it:


- position the front ends of the load
space cover on its support and
press gently to put it in place,

- unfold the load space cover fully,

- position the rear ends of the load
space cover on its support and
press gently to put it in place.
To remove it:


- unclip the rear ends,

- fold the load space cover fully,

- unclip the front ends and remove
the load space cover.
To store it, fold it like an accordion.
Do not roll it
.
2. High load retaining net
The high load retaining net can be fi t-
ted behind the front or rear seats.
Open the covers A
of the correspond-
ing upper fastenings.
Fit the ends of the metal bar in these
fastenings.
Secure the two net strap hooks be-
hind the front seats, with the rear
seat folded, or in the stowing rings B

on the fl oor.
The rings are located directly below
the corresponding upper fastenings.
Pull the two straps C
taut.
3. Stowing rings

4. Side door storage compartments

5. Trays between the front and
rear seats

6. Seat back storage pockets

Page 94 of 132

PRACTICAL INFORMATION
92 -
SNOW SCREEN *

The snow screen is installed on the
lower part of the front bumper to pre-
vent the accumulation of snow at the
radiator cooling fan.
Remove the snow screen:


- when the exterior temperature is
higher than 10 °C,

- when towing,

- for speeds higher than 75 mph
(120 km/h).


FITTING



)
Offer up the snow screen facing
the front bumper.

)
Put it in place positioning the lower
clips A
in the bumper.

)
Press the snow screen at each
upper clip B
.



REMOVAL



)
Press the two upper clips B
and
pull the snow screen.


*
As an accessory or according to country.

Page 95 of 132

93 PRACTICAL INFORMATION
-

Without lifting
(four wheels on the ground)
You must always use a towbar.

By lifting
(two wheels only on the ground)
It is preferable to lift the vehicle by
the wheels.

TOWING YOUR VEHICLE


From the front or the rear
Attach the towbar to the towing eye.
Never use the radiator cross-
member.
When towing another vehi-
cle, it must freewheel.
Place the gearbox in "neutral".
Failure to observe this instruction
may result in damage to certain brak-
ing components and the absence of
braking assistance when the engine
is started again.

Page 96 of 132

PRACTICAL INFORMATION
94 -
TOWING A TRAILER,CARAVAN, BOAT, ETC.
We recommend the use of original
CITROËN towbars and their har-
nesses that have been tested and
approved from the design stage of
your vehicle and that the fi tting of the
towbar is entrusted to a CITROËN
dealer.
If the towbar is not fi tted by a
CITROËN dealer, it is imperative that
it is fi tted using the electrical pre-
equipment installed at the rear of the
vehicle, in accordance with the man-
ufacturer's instructions.
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
Driving with a trailer subjects the tow-
ing vehicle to more signifi cant stress
and its driver must be particularly
careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres of
altitude.

Driving advice


Tyres:
Check the tyre pressures of
the towing vehicle and of the trailer,
observing the recommended pres-
sures.

Braking:
Towing increases the braking
distance.

Lights:
Check the electrical signalling
on the trailer.

Side wind:
Take into account the
increased sensitivity to side wind.
Cooling:
Towing a trailer on a slope
increases the temperature of the
coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
On the contrary, use a high gear to
lower the engine speed and reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature.
In all cases, pay attention to the coolant
temperature.
In certain cases of particularly ardu-
ous use (towing the maximum load on
a steep gradient in high temperatures),
switching off the air conditioning permits
the recovery of engine power and there-
fore an increase in the towing capacity.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible.
Distribution of loads:
Distribute the
load in the trailer so that the heaviest
items are as close as possible to the
axle and the nose weight approach-
es the maximum permitted without
exceeding it.

Page 106 of 132

TECHNICAL DATA
104 -

Engine


1.4 litre



Gearbox


Manual



Model codes


GB KFWC



GC KFWC



GD KFWC



GA KFWC



Length


L1



L2



Version (kg)


600



800



750



1 000





Kerb weight
1 055
1 080
1 116



Gross vehicle weight (GVW)
1 655
1 855
1 830
2 145



Gross train weight
2 555
2 755
2 740
2 880



Unbraked trailer
500
575
575



Braked trailer (within GTW)
900
910
735



Recommended nose weight
70
75

75



Recommended weight on roof rack
100
100
100
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High exterior temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the exterior temperature is above 37 °C, limit the towed load.
PETROL WEIGHTS AND TOWING LOADS (IN KG) FORLIGHT VAN

Page 107 of 132

105 TECHNICAL DATA
-
DIESEL WEIGHTS AND TOWING LOADS (IN KG) FOR LIGHT VAN


Engine


1.6 litre Turbo HDI 75



1.6 litre Turbo 92



1.9 litre



Gearbox


Manual



Manual



Manual



Model codes


GB
9HWC



GC
9HWC



GD
9HWC



GA
9HWC



GB
9HXC



GC
9HXC



GD
9HXC



GA
9HXC



GB
WJYB



GC
WJYB



GD
WJYB



GA
WJYB



Length


L1



L2



L1



L2



L1



L2



Version (kg)


600



800



750



1 000



600



800



750



1 000



600



800



750



1 000





Kerb weight
1 130
1 144
1 140
1 130
1 140
1 144
1 206
1 142
1 146



Gross vehicle weight
1 730
1 930
1 895
2 180
1 730
1 930
1 900
2 140
1 805
1 955
1 895
2 180



Gross train weight
2 830
3 030
3 005
3 005
2 830
3 030
3 005
3 005
2 855
3 055
3 005
3 005



Unbraked trailer
500
585
585
500
585
585
500
585
585



Braked trailer
(within GTW)
1 100
1 110
850
1 100
1 110
865
1 050
1 100
1 110
825



Recommended nose
weight
70
75
75
70
75
75
70
75
75



Recommended
weight on roof rack
100
100
100
100
-
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High exterior temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the exterior temperature is above 37 °C, limit the towed load.

Page 108 of 132

TECHNICAL DATA
106 -

PETROL WEIGHTS AND TOWING LOADS (IN KG) FOR LUDOSPACE
5 SEAT VERSION

Engine


1.4 litre



1.6 litre



Gearbox


Manual



Manual



Model codes


GJ KFWC



GF KFWC



GN NFUC



Length


L1



L2



L2



Version (kg)


-



750



1 000





Kerb weight
1 197
1 190
1 207



Gross vehicle weight (GVW)
1 780
1 680
2 170



Gross train weight (GTW)
2 680
2 580
2 880



Unbraked trailer
540
585
585



Braked trailer (within GTW)
900
900
710



Recommended nose weight
70
75
75




Recommended weight on roof rack
100
100
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the exterior temperature is above 37 °C, limit the towed load.

Page 109 of 132

107 TECHNICAL DATA
-

DIESEL WEIGHTS AND TOWING LOADS (IN KG) FOR LUDOSPACE
5 SEAT VERSION

Engine


1.6 litre Turbo HDI 75



1.6 litre Turbo HDI 92


1.9 litre



Gearbox


Manual



Manual



Manual



Model codes:


GJ
9HWC



GF
9HWC



GN
9HWC



GJ
9HXC



GF
9HXC



GN
9HXC



GJ
WJYB



GF
WJYB



GN
WJYB



Length


L1



L2



L1



L2



L1



L2



Version (kg)


-



750



1 000



-



750



1 000



-



750



1 000





Kerb weight

1 240

1 254
1 213
1 240
1 255
1 218
1 240
1 252
1 244



Gross vehicle weight
(GVW)

1 880
1 740
2 150
1 880
1 740
2 165
1 840
1 740
2 210



Gross train weight
(GTW)
2 980
2 840
3 005
2 980
2 840
3 010
2 940
2 840
3 005



Unbraked trailer

540
585
585
540
585
585
500
585
585



Braked trailer (within
GTW)
1 100
845
1 100
855

1 100
795



Recommended nose
weight
70
75
75
70
75
75
70
75
75



Recommended
weight on roof rack
100
100
100
The GTW and towing load values indicated are valid up to a maximum altitude of 1 000 metres; the towing load mentioned
must be reduced by 10 % for each additional 1 000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle in order to protect the engine; when
the exterior temperature is above 37 °C, limit the towed load.

Page:   1-10 11-20 next >