fuel filter CITROEN C4 2019 Owners Manual

8
C4-cactus_en_Chap00b_vue-ensemble_ed01-2016
Running out of fuel, Diesel 
( priming   pump)  2 18
AdBlue
® additive and SCR system (
BlueHDi   Diesel)  1 75 -181
Maintenance - Technical data
Checking levels 1 70 -172
- oil
-
 
b
rake   fluid
-


coolant
-

s
creenwash fluid
-

a
dditive (Diesel with particle filter)
Checking
  components  
1
73 -174
-


battery
-
 
a
ir   /   passenger   compartment   filter
-

o
il filter
-

p
article filter (Diesel)
-
 
b
rake   pads   /   discs
Changing
 bu

lbs
 1
97-204
-
 
f
ront   lamps
-
 
r
ear   lamps
-
 i

nterior
 l
ighting Dimensions
 2

23
Identification
 ma

rkings
 2
24
Petrol
  weights  
2
20
Diesel   weights  
2
22
Opening   the   bonnet  
1
67
Under the bonnet, petrol

1
68
Under
  the   bonnet,   Diesel  
1
69
Petrol
  engines  
2
19
Diesel
  engines  
2
21
12V
  battery  
2
12-215
Load   reduction,   economy   mode  
1
60
Engine
 c
ompartment
 
f
uses  
2
05 -206,   210 -211
Over view

10
C4-cactus_en_Chap00c_eco-conduite_ed01-2016
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   in   the   personalised   servicing   schedule   for   your   vehicle.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   develops   a   fault,  
y

our   vehicle   becomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified  
w

orkshop   without   delay   to   have   the   emissions   of   nitrous   oxides   brought  
w

ithin   the   limits   set   by   the   directive.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(3
  000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
Eco-driving

172
C4-cactus_en_Chap07_info-pratiques_ed01-2016
Coolant level
The coolant level should be close
to  the   "MA X"   mark   but   should   never  
e

xceed   it.
In
 
addition,   as   the   cooling   system   is   pressurised,
 w

ait
 
at
 
least   one   hour   after   switching   off   the
 e

ngine
 
before   carrying   out   any   work.
To
 
avoid
 
any   risk   of   scalding,   unscrew   the   cap   by
 t

wo
 
turns
 
to   allow   the   pressure   to   drop.   When   the
 p

ressure
 
has   dropped,   remove   the   cap   and   top
 u

p
 
the
 
level.
Changing the coolant
The coolant does not have to be replaced at routine services.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When   the   engine   is   warm,   the   temperature   of  
t

he   coolant   is   regulated   by   the   fan.
Fluid specification
The coolant must conform to the ma
nufacturer's r ecommendations.
Fluid specification
For optimum cleaning and to avoid freezing, this   fluid   must   not   be   topped   up   or   replaced  
w

ith   plain   water.
In
 
w
intry  
c
onditions,  
i
t  
i
s  
r
ecommended  
t
hat  
y
ou  
u

se   an   ethyl   alcohol   or   methanol   based   fluid.
Screenwash fluid level
Top up the level when necessary.
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive
level (Diesel with particle
filter)
The additive reservoir low level is
indicated  by   fixed   illumination   of  
A
void   prolonged   contact   of   used   oil   or  
f

luids   with   the   skin.
Most   of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do not discard used oil or fluids into
sewers   or   onto   the   ground.
Take   used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
this warning lamp, accompanied by an audible s
ignal   and   a   message   that   the   particle   filter  
a

dditive   level   is   too   low.
Practical information

175
C4-cactus_en_Chap07_info-pratiques_ed01-2016
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates SCR (Selective Catalytic Reduction)
with
  a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing urea, a
 
catalytic
 
converter
 
turns
 
up
 
to
 
85%   of   nitrous o

xides
 
(NOx)
 
into
 
nitrogen
 
and
 
water,   which   are
 h

armless
 
to
 
health
 
and
 
the
 
environment. Once the AdBlue
® tank is empty, a s
ystem
 
required
 
by   regulations   prevents  
s

tarting
 
of
 
the
 
engine.
If the SCR is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   your  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after   a  
r

unning
 
distance
 
of   650   miles  
(1
 
100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
The AdBlue® additive is held in a special
tank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out.
7
Practical information

221
C4-cactus_en_Chap09_caracteristiques-techniques_ed01-2016
Enginee-HDi 92BlueHDi 100 BlueHDi 100 S&S
Gearbox ETG6 electronic
(6-speed) Manual
(5-speed) Manual
(5-speed) ETG6 electronic
(6-speed)
Model code 0B9HP0BBHY 0BBHY
Cubic capacity (cc) 1
  5601
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.375
  x   88.3
Max
  power:   EU   standard   (kW)* 6873 73
Max
  power   engine   speed   (rpm) 4 0003
  7503
  750
Max
  torque:   EU   standard   (Nm) 230254 254
Max
  torque   engine   speed   (rpm) 1
  7501
  7501
  750
Fuel DieselDiesel Diesel
Catalytic converter yesyes yes
Particle filter yesyes yes
Engine
  oil   capacity   with   replacement   of   the   oil  
f

ilter (in litres) 3.75
3.75 3.75
*
  
T
he   maximum   power   corresponds   to   the   value   type   approved   on   a   test   bed,   under   conditions   defined   by   European   legislation  
(Directive
 1

999/99/EC).
Engines and gearboxes - DIESEL
9
Technical data

291
C4-cactus_en_Chap11_index-alpha_ed01-2016
D
Earth point, remote ...............................16 8, 16 9
EBA ............................................................. ....91
Eco-driving
 (

advice)
 .......................................... 9
E

conomy   mode  
...............................
..............160
Electronic
  brake   force   distribution  
(EBFD)
 ...............................

...........................91
Electronic
  gearbox   system  
...........................13

0
Emergency
 c

all
 ...................................... 9
0,   226
Emissions
  control   system,   SCR  
.....................20
E

nergy   economy   mode  
.................................16

0
Engine
 c

ompartment
 ............................ 16

8,
 16
9
Engine,
  Diesel  
.........1
4,   156,   169,   218,   221,   222 Hazard
 w

arning
 lam
ps
 ............................9
0,   184
Headlamps,   automatic   illumination  
..........7
9,   82
Headlamps,   dipped   beam  
.................7
8,   79,   198
Headlamps,   main   beam  
............ 7
8,   79,   197,   199
Head restraints, front  
......................................
50
H
ead restraints, rear  
.......................................
52
H
eating
 ................
............................ 9,   57,   59,   61
Hill start assist  ...............................................
13 1
Horn ................................................................. 90
F
H
Filling the fuel tank ........................153,   155,   156
Filter, air ............... ......................................... 173
Filter, oil
 ......................................................... 17

3
Filter, particle
 ........................................ 17

2 ,
 17
3
Filter,
 p

assenger
 c
ompartment
 .....................17

3
Fitting
  roof   bars  
............................................. 16

4
Fittings,
  boot  
.............................................7
5,   77
Fittings,
 in

terior
 .......................................... 6

9 -74
Flap, fuel filler
 
...............................
.........153,
 15

5
Foglamp,
 r

ear
 ...............................
...........80, 202
Foglamps,
 f

ront
 .........................8
0,   85,   197,   200
Frequency
  (radio)  
..................................2
42,   243
Fuel ................................................................ 15 6
Fuel
 c

onsumption
 .............................................. 9
F

uel   tank........................................................ 153
Fuses
 ................

.....................................205,   207
E
DAB (Digital Audio Broadcasting) - 
D igital r adio ......................................... 244,   245
Date
  (setting)  
...............................
....................38
Daytime
  running   lamps  
.......................7
8,   79,   83
Daytime
  running   lamps,   LED  
................19

7,
 19
8
Deactivating
 t

he
 p
assenger
 
ai

rbag
 .................................................. 10

0, 107
Defrosting
 ...............................

...................65,   66
Demisting
 ...............................

...................65,   66
Diesel
 ...............................

.............................15 6
Dimensions
 ..............................

.....................223
Dipstick
 ................

.................................... 2 7, 17 0
Direction indicators
 ........... 8

1,   83,   197,   199,   202
Doors
 ..............................................................

.45
Driving
 e

conomically ......................................... 9
Dynamic
  stability   control  
(

DSC)
 ....................................1
6,   18,   91,   93,   95Engine,
  petrol  ........................1 56,   168,   219,   220
Engines ..............................
...................219, 2
21
Environment
 ...............................

................. 9,   42
ESC (electronic stability control)
 .............. 1

6,   91,   94Gauge,
  fuel.............................................. 11,   153
Gearbox, e
lectronic ....................9
,   23,   70,   73,   127,  
1
32,   133,   174
Gearbox,
 m

anual
 ...........9

,   69,   73,   125,   131,   132,  

1

33,   174
Gear shift indicator
 ....................................... 12

6
Gear
  lever,   manual   gearbox  
.........................12

5
Glove
  box  
...................................................6

9 -71
Grip control
 
.....................................................94
G
Identification, vehicle ....................................2 24
Ignition ................ .....................................64,   123
I
.
Alphabetical index

293
C4-cactus_en_Chap11_index-alpha_ed01-2016
Radio ............................................................. 242
Radio,   digital   (Digital   Audio   Broadcasting   -  
D

A B) ............................................................ 244
RDS
 ................

............................................... 243
Rear
  screen,   demisting   /   defrosting................66
Recharging
  the   battery  
.........................21

2, 214
Recirculation, air
 ...............................

. 58,   60,   64Safety, children
 ...............
10

0, 104 -107, 110 -118
Screen,
  cold   climate  
.....................................15

8
Screen, colour
 ................................ 2

9,   234,   235
S
R
Screenwash, front ...........................................87
S creenwash, rear ............................... .............87
SCR (Selective Catalytic Reduction)
 ............ 17

5
Seat belts
 .......................................... 9

6 -98,   110
Seat, rear bench
 ..............................

...............51
Seats, front
 ...............................

.......................49
Seats, heated
 ...............................

...................50
Seats, rear
 ....................................................... 51
S

erial   number,   vehicle  
..................................2

24
Service indicator
 ............................................. 24
S

ervicing
 ...............................
..........................10
Settings,
 e

quipment
 ........................................ 28
S

ettings
 (
Menus)
 ...............................
............264
Settings,
  system  
...............................
.............271
Sidelamps
 ......................... 7

8,   83,   197,   198,   202
Side repeater
 ..............................

..................201
Snow chains
 .................................................. 15

7
Socket,
  12   V   accessory  
.............................6

9 -71
Socket,
  auxiliary  
...............................
.......72, 246
Socket,
  JACK  
...............................
...........72, 246
Sockets,
  audio  
................................................ 72
Spe

ed
 l
imiter
 ...............................
.......... 135,   141
Stability control (ESC) ............................... 16,
  91
Starting
  the   engine  
............................... 12

1, 127
Starting
  using   another   battery  
......................2

13
Station, radio
 .........................................2

42,   243
Stay, bonnet
 ...............................

...................167
Steering
  wheel,   adjustment  
............................54
S

topping   the   vehicle  
..................................... 12

1
Stop & Start
 ........................ 1

5,   36,   65,   132,   145,
153,
  167,   173,   212,   215
Stop
  (warning   lamp)  
........................................ 17
St

orage
 ................
...................................... 71,   73
Sun visor
 .................................................... 6

9 -71
Switching
  off   the   engine  
...............................12

1
Synchronising
  the   remote  
control
 ........................................................... 42
P

aint colour code
 .......................................... 2
24
Panoramic
 
glass
 

sunroof
 ................

.......................................... 68
Parcel shelf, rear
 ....................................... 76

, 77
Park
 
Assist
 
...............................

..................... 145
Parking
 
brake
 
........................................ 1

2 4 , 174
Parking
 
sensors,
 
front
 
................................... 14

3
Parking
 
sensors,
 
rear.................................... 142
Plates, identification ...................................... 224
Player, Apple
® .............................. .................248
Player,
 
MP3
 
CD  ............................... ..............246
Player, USB
 
................................................... 24

6
Plip
 ..............................

.............................. 4 0 , 41
Pre-heater, Diesel
 ...............................

............14
Pressures, tyres
 ............................

185,   190,   224
Pre-tensioning
  seat   belts  
................................ 98
P

riming
 pu

mp
 ...............................
.................218
Priming
 
the
 
fuel   system  
................................ 2

18
Protecting
 
c

hildren
 ......................... 10

0, 104 -107, 110 -118
Protectors
 ...................................................... 18

2
Puncture
 ................

........................................ 185
PReduction of electrical load ..........................16 0
Regeneration   of   the   particle  
filter
 ........

..................................................... 173
Reinitialisation of the under-inflation detection
  system  
......................................... 1

51
Reinitialising
  the   remote   control  
.....................42
R

eminder,   lighting   on  
...................................... 81
R

emote   control  
................................................ 40
R

emoving   a   wheel  
..............................
..........193
Removing
  the   mat  
...............................
............74
Replacing
 bu

lbs
 ..............................
..............197
Replacing
 f

uses
 ..............................
..............205
Replacing
  the   air   filter  
...................................17

3
Replacing
  the   oil   filter  
................................... 17

3
Replacing
 t

he
 p
assenger
 
c

ompartment   filter  
...................................... 17

3
Reservoir, screenwash
 ................................. 17

2
Resetting
  the   service  
indicator
 ...............................

.........................26
Resetting
  the   trip   recorder  
..............................37
R

eversing
 c
amera
 ...............................
..........14 4
Reversing
 lam

p
 ............................................. 2

02
Risk
  areas   (update)  
....................................... 2

61
Roof bars
 ....................................................... 16

4
Running
  out   of   fuel  
(Diesel)
 ....................................................... 2

18
.
Alphabetical index