engine DACIA SANDERO STEPWAY 2016 2.G Workshop Manual

operating faults ..................................... (up to the end of the DU)
practical advice ..................................... (up to the end of the DU)
faults operating faults ............................... (up to the end of the DU)
5.34
ENG_UD19739_7
Anomalies de fonctionnement (B90 - U90 - L90 Ph2 - F90 Ph2 - R90 Ph2 - \
Dacia)
ENG_NU_817-10_B90_Dacia_5
Jaune NoirNoir texte
Operating faults
OPERATING FAULTS (1/5)
The following advice will enable you to carry out quick, temporary repairs. For safety reasons you should always contact
an approved dealer as soon as possible.
The starter is activated POSSIBLE CAUSESWHAT TO DO
Warning lights dim or fail to come on;
the starter does not run. Battery terminals disconnected,
oxidised or incorrectly secured.Retighten them, reconnect them or clean
them if they are oxidised.
Battery discharged or worn. Connect another battery to the faulty bat-
tery. Refer to the information on “Battery:
troubleshooting” in Section 5 or replace the
battery if necessary.
Do not push the vehicle if the steering
column is locked.
The engine will not start. Starting conditions are not fulfilled. Refer to the information on “Starting/stop-
ping the engine in Section 2.
The steering column remains locked. Steering wheel locked. To unlock, gently move the key and the
steering wheel (refer to the information on
the “Ignition switch” in Section 2).

JauneNoirNoir texte
5.35
ENG_UD19739_7
Anomalies de fonctionnement (B90 - U90 - L90 Ph2 - F90 Ph2 - R90 Ph2 - \
Dacia)
ENG_NU_817-10_B90_Dacia_5
OPERATING FAULTS (2/5)
On the road POSSIBLE CAUSES WHAT TO DO
Vibrations. Tyres not inflated to correct pres-
sures, incorrectly balanced or
damaged. Check the tyre pressures; if this is not the cause, have
their condition checked by an approved dealer.
Coolant boiling in the coolant
reservoir. Mechanical fault: cylinder head
gasket damaged, faulty coolant
pump. Stop the engine.
Contact an approved dealer.
Engine cooling fan not working. Contact an approved dealer.
Smoke under the bonnet. Short circuit or cooling system leak. Stop, switch off the ignition, stand away from the vehi-
cle and contact an approved Dealer.
The oil pressure warning light
comes on: on a bend or under braking The engine oil level is too low. Top up the engine oil (refer to the information on “Engine oil level, topping up/refilling” in Section 4).
at idle speed Low oil pressure. Go to your nearest approved dealer.
The oil pressure warning
light takes a long time to
go out or remains lit during
acceleration. Loss of oil pressure.
Stop the vehicle: contact an approved dealer.

5.36
ENG_UD19739_7
Anomalies de fonctionnement (B90 - U90 - L90 Ph2 - F90 Ph2 - R90 Ph2 - \
Dacia)
ENG_NU_817-10_B90_Dacia_5
Jaune NoirNoir texte
OPERATING FAULTS (3/5)
On the road POSSIBLE CAUSES WHAT TO DO
Abnormal white smoke from the ex-
haust Mechanical fault: damaged cylinder
head gasket.
or Stop the engine.
Contact an approved dealer.
This is not necessarily a fault.
Smoke may be caused by
regeneration of the particle filter. Refer to the information on “Special
features of diesel versions” in Section 2.
The power-assisted steering be-
comes heavy. Belt broken.
Have the belt replaced.
No power-assisted steering oil For maintenance operations on the power-
assisted steering, contact an approved
dealer.
Radiator: If there is a significant lack of coolant, remember that it must never be topped up using cold coolant while
the engine is very warm. After any procedure on the vehicle which has involved even partial draining of the cooling
system, it must be refilled with a new mixture prepared in the correct proportions. Reminder: only products approved
by the Technical Department may be used for this purpose.

JauneNoirNoir texte
5.37
ENG_UD19739_7
Anomalies de fonctionnement (B90 - U90 - L90 Ph2 - F90 Ph2 - R90 Ph2 - \
Dacia)
ENG_NU_817-10_B90_Dacia_5
OPERATING FAULTS (4/5)
On the road POSSIBLE CAUSES WHAT TO DO
Whistling Roof aerial poorly positioned. Position the aerial.
The engine overheats. The coolant
temperature indicator light comes
on. Engine cooling fan not working. Stop the vehicle, switch off the engine and
contact an approved dealer.
Coolant leaks. Stop the vehicle, switch off the engine and
check the coolant reservoir: it should con-
tain fluid. If there is no coolant, consult an
approved dealer as soon as possible.
The oil change warning light remains
lit after an oil change. Warning not reset after oil change. Reset the warning after changing the oil;
refer to the information on “Resetting the
warning after an oil change” in Section 4.
Radiator: If there is a significant lack of coolant, remember that it must never be topped up using cold coolant while
the engine is very warm. After any procedure on the vehicle which has involved even partial draining of the cooling
system, it must be refilled with a new mixture prepared in the correct proportions. Reminder: only products approved
by the Technical Department may be used for this purpose.

6.1
ENG_UD26898_12
Sommaire 6 (B90 - Dacia)
ENG_NU_817-10_B90_Dacia_6
Section 6: Technical specifications
Vehicle identification plates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.2
Engine specifications

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.4
Dimensions
.

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.5
W

eights/Towing weights
.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.6
Replacement parts and repairs


. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.7
Service sheets


. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.8
Anti-corrosion check
.

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.14

JauneNoirNoir texte
6.3
ENG_UD26578_7
Plaques identification (B90 - Dacia)
ENG_NU_817-10_B90_Dacia_6
ENGINE IDENTIFICATION PLATES
The information shown on the ve-
hicle identification plate should be
quoted on all correspondence or
orders.
B

–

Engine pla
te or engine label
(Location varies depending on engine)
1


Engine type 2


Engine suf
fix
3


Engine num
ber
B
B
B
B
B
3
21

engine specifications ............................ (up to the end of the DU)
technical specifications ......................... (up to the end of the DU)
fuel grade ............................................... (up to the end of the DU)
engine technical specifications ................... (up to the end of the DU)
6.4
ENG_UD18029_4
Caractéristiques moteur (B90 - Dacia)
ENG_NU_817-10_B90_Dacia_6
Engine specifications
ENGINE SPECIFICATIONS
Versions 1.2 16V1.41.61.6 16V 1.5 dCi
Engine type
(see engine plate) D4F
K7JK7M K4M K9K Turbo
Cubic capacity (cc) 1,1491,390 1,5981,461
Type of fuel
Octane rating It is
essential that you use unleaded petrol of the octane rating stated on
the label inside the fuel filler flap.
If not available, for a limited time only, use unleaded fuel:
–

with an octane rating of 91 for a label with the ratings 95 or 98
;
–

with an octane rating of 87 for a label showing 91, 95 or 98. Diesel.
The label
located in the fuel filler flap
indicates the
authorised fuels.
Spark plugs Only use the spark plugs specified for your vehicle’

s engine.
The type should be marked on a label affixed inside the engine compart-
ment. If it is not, contact an approved dealer.
Fitting spark plugs which are not to specification may damage the engine.

technical specifications ......................... (up to the end of the DU)
weight ................................................... (up to the end of the DU)
towing ................................................... (up to the end of the DU)
towing a caravan ................................................... (current page)
towing weights ....................................................... (current page)
weights .................................................................. (current page)
6.6
ENG_UD26579_7
Masses (en kg) (B90 - Dacia)
ENG_NU_817-10_B90_Dacia_6
Weights/Towing weights
WEIGHTS (in kg)
The weights indicated for a basic vehicle without options: they vary depending on the your vehicle’s equipment.
Consult your approved Dealer.
Maximum permissible all-up weight (MMAC)
Maximum permissible all-up weight (MMTA)
Total train weight (MTR) Weights are indicated on the vehicle identification plate (refer to
the information on “Vehicle identification plates” in Section 6)
Braked Trailer Weight* obtained by calculating: MTR - MMAC
Unbraked Trailer Weight* 525
Permissible nose weight* 60
Maximum permissible load on roof 80
kg (including carrying device)
* Towing weight (towing a caravan, boat, etc.)
Towing is prohibited when the GTW - MAM calculation is equal to zero, or when the GTW is equal to zero (or is not listed) on the identification plate.
–

It
is important to comply with the towing weights, governed by local legislation in each country and, in particular, laid down in
the Road Traffic Regulations. Contact an approved Dealer about any towing equipment.
–

When
towing, under no circumstances may the total train weight (vehicle + trailer) be exceeded . However the following is
permitted:
–

the Maximum permissible wei
ght at the rear may be exceeded by no more than 15%,
–

the maximum permissible all-
up weight may be exceeded by no more than 10% or 100 kg (whichever occu\
rs first).
In

either case, the maximum speed of the towing assembly must not exceed 60 mph (100 km/h) and the tyre pressure must
be increased by 0.2 bar (3 PSI).
–

The
engine output and climbing capability are reduced with altitude. We recommend that the maximum load be reduced by
10% at an altitude of 1,000 metres and by an additional 10% for each 1,0\
00 metres thereafter.
Weight transfer on (except utility version) depending on local laws
If the Maximum Authorised Mass of the vehicle has not been reached, up to 300 kg can be transferred to the braked trailer,
within the limits of the Gross Train Weight.

7.1
FRA_UD26899_12
Index (B90 - Dacia)
ENG_NU_817-10_B90_Dacia_7
AlphAbeticAl index (1/4)
A
ABS
........................................................................\
2.12 – 2.13
accessories.............................................................\
........... 5.33
accessories - installation
................................................... 5.33
accessories socket ............................................................ 3.14
adjusting your driving position ...................... 1.1

1 → 1.14,   3.17
advice on antipollution
........................................... 5.22 → 5.24
air bag.................................................................... 1.15 → 1.20
activating the front passenger air bags
.......

................. 1.34
deactivating the front passenger air bags
.......

............. 1.32
air conditioning
.................................................... 3.4 – 3.5,

  3.9
air vents

...................................................................... 3.2
– 3.3
anti-corrosion check
.............................................. 6.14 → 6.18
anti-corrosion protection .................................................... 4.13
anti-lock braking system:

ABS
................................ 2.12
– 2.13
antipollution advice
......

............................................................ 2.6 → 2.8
ashtrays

........................................................................\
..... 3.14
automatic gearbox (use) ........................................ 2.14 → 2.16
automatic gearbox selector lever...........................

2.14 → 2.16
bbattery........................................................................\
........ 4.12troubleshooting ......

........................................... 5.25 – 5.26
battery (remote control)
..................................................... 5.27
bonnet........................................................................\
. 4.2

– 4.3
brake fluid
........................................................................\
.... 4.7
bulbs changing
......

.................................................... 5.14 → 5.21
ccapacity of mechanical components........................... 4.4,

  4.12
catalytic converter................................................................ 2.4
central door locking
............................................................. 1.5
changing a bulb ..................................................... 5.14 → 5.21
changing a wheel...................................................... 5.9

– 5.10changing gear ........................................................
2.14 → 2.16
child booster seat .................................................. 1.21 → 1.23
child restraint/seat ................................................. 1.21 → 1.31
child safety............................................... 1.2,

  1.6,   1.21 → 1.31
child seats.............................................................. 1.21 → 1.31
children
.............................................................. 1.5 – 1.6,

  1.14
cigar lighter
........................................................................\
3.14
clock


........................................................................\
.......... 1.10
closing the doors ................................................................. 1.6
control instruments ....................................... 1.10,

  1.40 → 1.50
controls

..................................................................1.36 → 1.39
courtesy light ..................................................................... 3.10
ddashboard.............................................................. 1.36 → 1.39
de-icing .................................................................. 1.53 → 1.55
rear screen .......

............................................................ 1.55
demisting rear screen
.......

.............................................................. 3.7
dimensions
........................................................................\
.. 6.5
dipstick

........................................................................\
......... 4.4
doors........................................................................\
... 1.5
– 1.6
driver’s position
..................................................... 1.36 → 1.39
driving .................................................. 2.2 → 2.8,

  2.11 → 2.16
eelectric door locking ............................................................. 1.5
electric windows ..................................................... 3.1

1 – 3.12
emergency brake assist..................................................... 2.13 emergency spare wheel
................................. 5.3,

  5.11 → 5.13
engine technical specifications
......

............................................ 6.4
engine coolant
..................................................................... 4.8
engine immobiliser

............................................................... 1.7
engine immobiliser (switch)
................................................. 2.2
engine oil ........................................................................\
..... 4.4

7.2
FRA_UD26899_12
Index (B90 - Dacia)
ENG_NU_817-10_B90_Dacia_7
Jaune NoirNoir texte
AlphAbeticAl index (2/4)
engine oil grade .......................................................... 4.5 – 4.6
engine specifications ........................................................... 6.4
environment ........................................................................\
. 2.9
F
faults operating faults
......

.......................................... 5.34 → 5.38
filter

........................................................................\
............ 4.10
air filter


......
................................................................... 4.10
diesel filter
.......

.................................................... 1.58,
  4.10
oil filter

......
..................................................................... 4.6
particle filter
......

............................................................. 2.5
passenger compartment filter
......

................................ 4.10
fitting a radio
...................................................................... 5.32
fittings


..................................................................... 3.15
– 3.16
fog lights

........................................................................\
.... 1.50
front passenger air bag deactivation ................................. 1.32
front seat adjustment


........................................................... 1.9
front seats adjustment
......

............................................................... 1.9
fuel advice on fuel economy
......

.................................2.6 → 2.8
grade
.......

.............................................................. 1.56,
  6.4
fuel economy
............................................................. 2.6 → 2.8
fuel filler cap ...................................................................... 1.56
fuel grade........................................................................\
... 1.56
fuel level
........................................................................\
.... 1.44
fuel priming bulb ................................................................ 1.58
fuel tank


................................................................. 1.56 → 1.58
fuel tank capacity ............................................................... 1.56
fuses


...................................................................... 5.22 → 5.24
G
gear lever........................................................................\
... 2.10
glove box
........................................................................\
... 3.15
grab handle........................................................................\
3.13
hhandbrake........................................................................\
.. 2.1 1
hands-free telephone integrated control
............................ 3.22
hazard warning lights signal .............................................. 1.52
headlight beam adjustment ............................................... 1.51
headlight flashers .............................................................. 1.52
headrest...................................................................... 1.8,

  3.17
heating and air conditioning system
................... 3.2 → 3.5,

  3.9
heating system
.......................................................... 3.2 → 3.9
horn


........................................................................\
........... 1.52
iignition switch ...................................................................... 2.2
indicator lights.................................................................... 5.18
indicators
.................................................................. 1.52,

  5.14
indicators: direction indicators
.......

................................................ 1.52
instrument panel
.................................................... 1.40 → 1.44
interior trim maintenance
......

............................................... 4.15 – 4.16
J
jack

....................................................................5.2,

  5.9 – 5.10
K
keys

........................................................................\
.... 1.2
– 1.3
replacing the battery
......

.............................................. 5.27
llevels ..................................................................4.4,

  4.7 → 4.9
levels: engine oil
......

................................................................. 4.5
lifting the vehicle changing a wheel
.......

........................5.2 – 5.3,
  5.7 → 5.10
lighting: exterior

.......
..................................1.49 – 1.50,
  5.14 → 5.18