engine coolant DODGE AVENGER 2010 2.G User Guide

WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposalrules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
Four-Cylinder Engines –
the coolant bottle provides a
quick visual method for determining that the engine
coolant (antifreeze) level is adequate. With the engine
idling and warm to normal operating temperature, the
level of the engine coolant (antifreeze) in the bottle
should be between the “ADD” and “FULL” lines, shown
on the bottle.
Six-Cylinder Engines – the level of the engine coolant
(antifreeze) in the pressurized coolant bottle should be
between the “COLD” and “FULL” range on the bottle
when the engine is cold.
370 MAINTAINING YOUR VEHICLE

The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
engine coolant (antifreeze) freeze point or replacing cool-
ant. Advise your service attendant of this. As long as the
engine operating temperature is satisfactory, the coolant
bottle need only be checked once a month. When addi-
tional engine coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator. If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check engine coolant (antifreeze) freeze point in the
radiator and in the coolant recovery bottle. If engine
coolant (antifreeze) needs to be added, the contents of
the coolant recovery bottle must also be protected
against freezing.
•If frequent engine coolant (antifreeze) additions are
required, or if the level in the coolant recovery bottle
does not drop when the engine cools, the cooling
system should be pressure tested for leaks.
•Maintain engine coolant (antifreeze) concentration at
50% HOAT engine coolant (antifreeze) (minimum)
and distilled water for proper corrosion protection of
your engine, which contains aluminum components.
7
MAINTAINING YOUR VEHICLE 371

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
All Engines — (Except 2.4L PZEV) 16.9 Gallons64 Liters
2.4L PZEV (Partial Zero Emissions Vehicle) 18.5 Gallons70 Liters
Engine Oil with Filter
2.4L Engine (SAE 5W-20, API Certified) 4.5 Quarts4.4 Liters
2.7L Engine (SAE 5W-20, API Certified) 5.5 Quarts5.2 Liters
3.5L Engine (SAE 10W-30, API Certified) 5.5 Quarts5.2 Liters
Cooling System*
2.4L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 7.7 Quarts
7.3 Liters
2.7L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 9.8 Quarts
9.3 Liters
3.5L Engine (MOPAR Antifreeze/Coolant 5
Year/100,000 Mile Formula or equivalent) 11.6 Quarts
11 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
396 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant MOPAR
Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hy-
brid Organic Additive Technology) or equivalent.
Engine Oil – 2.4L and 2.7L Engines Use API Certified SAE 5W-20 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to your engine oil filler cap for
correct SAE grade.
Engine Oil – 3.5L Engine Use API Certified SAE 10W-30 Engine Oil, meeting the requirements of
Chrysler Material Standard MS-6395. Refer to your engine oil filler cap for
correct SAE grade.
Engine Oil Filter MOPAREngine Oil Filter or equivalent.
Spark Plugs – 2.4L Engine except
PZEV* ZFR5F-11 (Gap 0.043 in [1.11 mm])
Spark Plugs – 2.4L Engine with
PZEV* ZFR5AP (Gap 0.031 in [0.8 mm])
Spark Plugs – 2.7L Engine TE10PMC5 (Gap 0.050 in [1.27 mm])
Spark Plugs – 3.5L Engine ZFR5LP-13G (Gap 0.050 in [1.27 mm])
7
MAINTAINING YOUR VEHICLE 397

Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S402 MAINTENANCE SCHEDULES

102,000 Miles (170,000 km) or
102 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏ Rotate tires.
❏ Replace the spark plugs (2.4L PZEV*,
2.7L and 3.5L Engines).
❏ Replace the timing belt (3.5L Engine).
❏ Flush and replace the engine coolant.
❏ Inspect accessory drive belt, replace if
necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
108,000 Miles (180,000 km) or 108 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏ Rotate tires.
❏ If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and
replace if necessary.
❏ Inspect the brake linings, and replace as necessary.
❏ Replace the air conditioning filter (if equipped).
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order #Dealer Code
Signature Authorized Chrysler Dealer
8
M
A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 411

About Your Brakes....................... 259
ABS (Anti-Lock Brake System) .............. 262
Adding Engine Coolant (Antifreeze) .......... 368
Adding Fuel ........................... 309
Adding Washer Fluid ..................... 364
Additives, Fuel ......................... 303
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 358
Air Conditioner Maintenance ............... 360
Air Conditioning ........................ 225
Air Conditioning Controls ................. 225
Air Conditioning Filter .................236,361
Air Conditioning, Operating Tips ............ 237
Air Conditioning Refrigerant .............360,361
Air Conditioning System .............225,229,360
Air Pressure, Tires ....................... 283
Airbag .............................. 53,63
Airbag Deployment ....................... 64
Airbag Light ..................... 62,67,82,151
Airbag Maintenance ....................... 66 Airbag, Side
........................ 56,60,63
Airbag, Window (Side Curtain) ...........57,60,63
Alarm System (Security Alarm) ............17,158
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 216
Antifreeze (Engine Coolant) ..............368,396
Disposal ............................ 370
Anti-Lock Brake System (ABS) .............. 262
Anti-Lock Warning Light .................. 262
Anti-Theft Security Alarm (Theft Alarm) ........ 17
Appearance Care ........................ 377
Ashtray ............................... 132
Auto Down Power Windows ................ 34
Auto Unlock, Doors ....................... 31
Auto Up Power Windows ................35,129
Automatic Dimming Mirror ................. 90
Automatic Door Locks ................... 30,31
Automatic Oil Change Indicator ........156,166,400
Automatic Temperature Control (ATC) ......... 229
428 INDEX

Automatic Transaxle..............12,243,246,374
Adding Fluid ................... 375,376,398
Filter ............................... 376
Fluid and Filter Changes ................. 376
Fluid Level Check ................... 375,376
Interlock System ....................... 249
Reset Mode .......................... 252
Selection Of Lubricant ................... 398
Shifting ............................. 249
Special Additives ...................... 376
Autostick ............................. 253
Battery ............................... 358
Keyless Transmitter Replacement (RKE) ....... 25
Location ............................ 358
Belts, Seat .............................. 82
Beverage Cooler ........................ 140
Body Mechanism Lubrication ............... 362B-Pillar Location
........................ 278
Brake Assist System ...................... 265
Brake, Parking .......................... 259
Brake System ........................... 372
Anti-Lock (ABS) ....................... 262
Fluid Check ....................... 372,398
Master Cylinder ....................... 372
Parking ............................. 259
Warning Light ........................ 152
Brakes ............................... 372
Brake/Transmission Interlock ............... 248
Break-In Recommendations, New Vehicle ........ 79
Bulb Replacement ..................... 388,389
Bulbs, Light .......................... 84,388
Calibration, Compass ..................... 169
Capacities, Antifreeze (Engine Coolant) ......... 19
Capacities, Fluid ........................ 396
10
INDEX 429

Caps, FillerFuel ............................... 309
Oil (Engine) .................. 347,348,349,356
Power Steering ........................ 259
Radiator (Coolant Pressure) ............... 369
Car Washes ............................ 378
Carbon Monoxide Warning ...............81,304
Cargo Area Features ...................... 135
Cargo Compartment ...................... 135
Cargo Load Floor ........................ 135
Cargo (Vehicle Loading) ................... 135
Cellular Phone ........................ 93,224
Center High Mounted Stop Light ............ 394
Chains, Tire ............................ 289
Changing A Flat Tire ..................... 329
Chart, Tire Sizing ........................ 274
Check Engine Light
(Malfunction Indicator Light) ............... 351
Checking Your Vehicle For Safety ............. 80Checks, Safety
........................... 80
Child Restraint .................... 69,71,75,78
Child Restraint Tether Anchors .............73,75
Child Safety Locks ........................ 32
Cigar Lighter ........................... 132
Clean Air Gasoline ....................... 301
Cleaning Wheels ............................. 379
Windshield Wiper Blades ................ 363
Climate Control ......................... 224
Clock ..................... 176,190,192,195,204
Coin Holder ........................... 136
Compact Disc (CD) Maintenance ............. 224
Compact Spare Tire ...................... 285
Compass .............................. 169
Compass Calibration ..................... 169
Compass Variance ....................... 170
Computer, Trip/Travel .................. 19,167
Console ............................ 104,136
Console, Floor ....................... 104,136
430 INDEX

Contract, Service........................ 421
Coolant Pressure Cap (Radiator Cap) .......... 369
Cooler, Beverage ........................ 140
Cooling System ......................... 367
Adding Coolant (Antifreeze) .............. 368
Coolant Capacity ...................... 396
Coolant Level ...................... 367,370
Disposal of Used Coolant ................ 370
Drain, Flush, and Refill .................. 367
Inspection ........................... 370
Points to Remember .................... 371
Pressure Cap ......................... 369
Radiator Cap ......................... 369
Selection of Coolant (Antifreeze) ......368,396,397
Corrosion Protection ..................... 377
Crankcase Ventilation Module ............... 19
Cruise Control (Speed Control) .............. 118
Cruise Light ........................... 157
Cupholders ...................... 104,133,382Customer Assistance
..................... 419
Customer Programmable Features ............ 171
Daytime Running Lights ................... 110
Dealer Service .......................... 353
Defroster, Rear Window ................... 139
Defroster, Windshield ................82,227,233
Delay (Intermittent) Wipers ................. 114
Diagnostic System, Onboard ................ 350
Dimmer Switch, Headlight ................. 109
Dipsticks Automatic Transaxle ................. 375,376
Oil (Engine) .......................... 354
Power Steering ........................ 259
Disabled Vehicle Towing ................... 341
Disposal Antifreeze (Engine Coolant) ............... 370
Engine Oil ........................... 357
Door Locks ............................. 29
10
INDEX 431