steering DODGE CALIBER 2007 1.G Owner's Guide

8. Start the engine in the vehicle that has the booster
battery, let the engine idle a few minutes, then start the
engine in the vehicle with the discharged battery.
9. When removing the jumper cables, reverse the se-
quence exactly. Be careful of the moving belts and fan.
FREEING A STUCK VEHICLE
NOTE:
If your vehicle is equipped with Traction Con-
trol, turn the system OFF before attempting to “rock” the
vehicle.
If your vehicle becomes stuck in mud, sand or snow, it
can often be moved by a rocking motion. Turn your
steering wheel right and left to clear the area around the
front wheels. Then shift back and forth between Reverse
and First gear. Usually the least accelerator pedal pres-
sure to maintain the rocking motion without spinning the
wheels is most effective.
WARNING!
Fast spinning tires can be dangerous. Forces gener-
ated by excessive wheel speeds may cause axle, tire
damage or failure. A tire could explode and injure
someone. Do not spin your vehicle’s wheels faster
than 30 mph (48 km/h) or for longer than 30 seconds
continuously without stopping when you are stuck.
And don’t let anyone near a spinning wheel, no
matter what the speed.
CAUTION!
Racing the engine or spinning the wheels too fast
may lead to transaxle overheating and failure. It can
also damage the tires. Do not spin the wheels above
30 mph (48 km/h). Do not spin the wheels continu-
ously for more than 30 seconds.
274 WHAT TO DO IN EMERGENCIES

TOWING A DISABLED VEHICLE
With Ignition Key
Automatic And Manual Transaxle
Front-wheel-drive vehicles must have the front wheels
elevated; all-wheel-drive vehicles must be hauled on a
flatbed truck.
All Transaxles
CAUTION!
If the vehicle being towed requires steering, the
ignition switch must be in the ACCESSORY posi-
tion, not in the LOCK position.
Do not attempt to use sling type equipment when
towing. When securing vehicle to flat bed truck, do
not attach to front or rear suspension components.
Damage to your vehicle may result from improper
towing.
If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transaxle remains in NEUTRAL.
WHAT TO DO IN EMERGENCIES 275
6

MAINTAINING YOUR VEHICLE
CONTENTS

Engine Compartment — Gasoline Engines...279

Onboard Diagnostic System — OBD II......280
▫Loose Fuel Filler Cap Message............280

Emissions Inspection And
Maintenance Programs
..................281

Replacement Parts.....................282

Dealer Service........................282

Maintenance Procedures.................283
▫Engine Oil..........................283
▫Drive Belt – Check Condition.............286
▫Spark Plugs.........................286
▫Catalytic Converter....................287▫Crankcase Emission Control System........288
▫Fuel Filter..........................288
▫Air Cleaner Element (Filter)..............288
▫Maintenance-Free Battery................289
▫Air Conditioner Maintenance.............290
▫Power Steering — Fluid Check............291
▫Front Suspension Ball Joints..............291
▫Body Lubrication.....................292
▫Windshield Wiper Blades................292
▫Windshield Washer Reservoir.............292
▫Exhaust System......................293
7

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, or Refrigerants.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid types.
Front Suspension Ball Joints
There are two front suspension lower ball joints that are
permanently lubricated. Inspect these ball joints when-
ever under vehicle service is done. Damaged seals and
their corresponding potentially damaged ball joints must
be replaced.
MAINTAINING YOUR VEHICLE 291
7

WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake And Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard and
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling suggest deterioration of the rubber. Particu-
lar attention should be made to examining those hose
surfaces nearest to high heat sources, such as the exhaust
manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
Insure nylon tubing in these areas has not melted or
collapsed.
NOTE:Often, fluids such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to ease the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not neces-
sarily an indication of leakage. Actual dripping of hot
fluid when systems are under pressure (during vehicle
operation) should be noted before a hose is replaced
based on leakage.
NOTE:Inspection of brake hoses should be done
whenever the brake system is serviced and at every
engine oil change.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
MAINTAINING YOUR VEHICLE 299
7

Cavity Cartridge
FuseMini
FuseDescription
1 Empty Empty
2 15 Amp
Lt. BlueAWD/4WD ECU
Feed
3 10 Amp
RedCHMSL Brake Switch
Feed
4 10 Amp
RedIgnition Switch Feed
5 20 Amp
YellowTrailer Tow
6 10 Amp
RedIOD Sw/Pwr Mir/
Ocm Steering Cntrl
Sdar/Hands Free
Phone
7 30 Amp
GreenIOD Sense1
8 30 Amp
GreenIOD Sense2
9 40 Amp
GreenPower SeatsCavity Cartridge
FuseMini
FuseDescription
10 20 Amp
YellowCCN Power Locks
11 15 Amp
Lt BluePower Outlet
12 20 Amp
YellowIgn Run/Acc Inverter
13 20 Amp
YellowPwr run/Acc Outlet
RR
14 10 Amp
RedIOD CCN/ Interior
Lighting
15 40 Amp
GreenRAD Fan Relay Bat-
tery Feed
16 15 Amp
Lt. BlueIGN Run/Acc Cigar
Ltr/Sunroof
17 10 Amp
RedIOD Feed Mod-Wcm
18 40 Amp
GreenASD Relay Contact
PWR Feed
19 20 Amp
YellowPWR Amp 1 & Amp
2 Feed
308 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transaxle (CVT) Fluid MoparCVTF + 4
Manual Transaxle Fluid MoparATF+4 MS9602
Rear Drive Assembly (RDA) MoparGear & Axle Lubricant SAE 80W-90 API GL 5 or equivalent non-
synthetic product.
Power Transfer Unit (PTU) MoparGear & Axle Lubricant SAE 80W-90 API GL 5 or equivalent non-
synthetic product.
Brake Master Cylinder MoparDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids or equivalent.
Power Steering Reservoir MoparPower Steering Fluid +4 or MoparATF+4 Automatic Transmis-
sion Fluid.
318 MAINTAINING YOUR VEHICLE

Oil Pressure......................... 145
Rear Fog............................ 152
Seat Belt Reminder.................... 145
Security Alarm (Theft Alarm)............. 25
Theft Alarm (Security Alarm)............ 145
Traction Control...................... 119
Turn Signal.................103,105,149,312
Voltage ............................. 145
Warning (Instrument Cluster Description) . . . 144
Loading Vehicle........................ 254
Tires ............................... 229
Locks
ChildProtection ....................... 18
Door............................... 14
Power Door.......................... 15
Steering Wheel........................ 13
Lubrication, Body....................... 292
Luggage Rack (Roof Rack)................ 134
Lumbar Support........................ 95
Maintenance Free Battery................. 289
Maintenance, General.................... 283
Maintenance Procedures.................. 283Maintenance Schedule................... 320
Schedule “A”........................ 332
Schedule “B”........................ 323
Malfunction Indicator Light
(Check Engine)......................148,281
Manual, Service........................ 341
Manual Transaxle.................208,215,302
Downshifting........................ 217
Fluid Level Check..................302,303
Frequency of Fluid Change...........302,303
Lubricant Selection.................302,303
Map/Reading Lights.................... 102
Master Cylinder (Brakes)................. 300
Mirrors ............................... 69
Electric Powered....................... 70
Outside ............................. 69
Rearview............................ 69
Vanity .............................. 71
Modifications/Alterations, Vehicle............ 6
Monitor, Tire Pressure System............. 241
Mopar Parts........................282,340
Multi-Function Control Lever.............. 103
INDEX 353
10

Navigation Radio....................... 192
Navigation System...................... 192
New Vehicle Break-In Period............... 61
Occupant Classification System (OCS)........ 44
Occupant Restraints (Sedan)................ 28
Octane Rating, Gasoline (Fuel)............. 248
Odometer............................ 147
Trip ............................147,148
Oil, Engine.........................283,316
Capacity............................ 316
Change Interval...................... 284
Checking........................... 283
Disposal............................ 286
Filter.............................. 286
Identification Logo.................... 285
Materials Added to.................... 286
Recommendation..................285,316
Synthetic........................... 285
Viscosity............................ 285
Oil Pressure Light...................... 145
Onboard Diagnostic System............280,281
Opener, Garage Door (HomeLink) ......... 112Operator Manual (Owner’s Manual).......... 4
OutsideAirIntake ...................... 204
Overdrive............................ 213
Overheating, Engine..................... 266
Owner’s Manual (Operator Manual)....... 4,341
PaintCare ............................ 303
Panic Alarm........................... 21
Parking Brake......................... 218
Passing Light.......................... 106
Performance........................... 213
Personal Settings....................... 155
Pets .................................. 60
Phone, Cellular......................... 72
Phone, Hands-Free (UConnect™)............ 72
Placard, Tire and Loading Information....... 229
Power
Distribution Center (Fuses).............. 307
Door Locks.......................... 15
Mirrors ............................. 70
Outlet (Auxiliary Electrical Outlet)........ 124
Steering .........................223,291
Steering, Checking.................... 291
354 INDEX

Sunroof............................ 122
Transfer Unit........................ 303
Windows............................ 27
Power Steering Fluid.................... 318
Power Transfer Unit..................... 303
Pregnant Women and Seat Belts............. 39
Preparation for Jacking................... 269
Pretensioners
Seat Belts............................ 37
Programmable Electronic Features..... 113,116,155
Programming Transmitters
(Remote Keyless Entry).............. 22,113,116
Radial Ply Tires........................ 236
Radio Broadcast Signals.................. 160
Radio, Navigation...................... 192
Radio Operation...............162,169,180,198
Radio, Satellite......................192,193
Radio (Sound Systems).............162,169,180
Rear Axle (Differential)................... 302
Rear Drive Assembly.................... 302
Rear Fog Lights........................ 152
Rear Liftgate (Sedan)..................... 26Rear Seat, Folding....................... 99
Rear Window Defroster.................. 134
Rear Window Features................... 132
Rear Wiper/Washer..................... 132
Recorder, Event Data..................... 52
Recreational Towing..................... 264
Refrigerant ............................ 291
Reminder, Seat Belt...................... 37
Remote Control
Door Locks.......................... 19
Security Alarm........................ 24
Remote Keyless Entry (Sedan).............. 19
Remote Sound System (Radio) Controls...... 196
Replacement Bulbs...................... 310
Replacement Keys....................... 12
Replacement Parts...................... 282
Replacement Tires...................... 239
Reporting Safety Defects................. 341
Restraints,Child ...................... 54,59
Restraints,Infant ........................ 54
Retractable Cargo Area Cover.............. 130
Roof Rack (Luggage Rack)................ 134
Rotation,Tires ......................... 247
INDEX 355
10