fuel DODGE CARAVAN 2007 4.G Service Manual

•Taxi, police, or delivery service (commercial ser-
vice). \b
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE: Most vehicles are operated under the conditions
listed for Schedule B.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
MAINTENANCE SCHEDULES 467
8
M A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 96 000
km (60,000 miles) if the vehicle is usually operated under
one or more of the conditions marked with an \b.
•Day or night temperatures are below 0° C (32° F).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 16 km (10 miles).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 32° C (90° F).
•Trailer towing. \b
•Taxi, police, or delivery service (commercial ser-
vice). \b
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
SCHEDULE “B” 469
8
M
A I
N T
E
N A
N C E
S
C
H E
D
U L
E
S

Adding Fuel........................... 357
Adding Washer Fluid .................. 303,432
Additives, Fuel ......................... 355
Adjustable Pedals ....................... 163
Air Conditioner Maintenance ............... 428
Air Conditioning ..................... 278,284
Air Conditioning Controls ................. 278
Air Conditioning Filter .................301,429
Air Conditioning, Operating Tips ............ 301
Air Conditioning, Rear Zone .............286,296
Air Conditioning Refrigerant ............... 428
Air Conditioning System ..........278,284,289,428
Air Conditioning System, Zone Control ........ 279
Air Pressure, Tires ....................... 337
Airbag ................................ 57
Airbag Deployment ....................... 69
Airbag Light ................... 62,63,72,90,214
Airbag Maintenance ....................... 71
Airbag, Window (Side Curtain) ............... 58 Alarm Light
........................... 216
Alarm (Security Alarm) .................... 18
Alignment and Balance ................... 344
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 274
Antifreeze (Engine Coolant) ...........435,436,461
Disposal ............................ 437
Anti-Lock Brake System (ABS) .............. 321
Anti-Lock Warning Light .................. 214
Anti-Theft System ........................ 18
Appearance Care ........................ 446
Ashtray ............................... 188
Auto Down Power Windows ................ 33
Automatic Dimming Mirror ................. 96
Automatic Door Locks ................... 29,30
Automatic Headlights .................... 153
Automatic Temperature Control (ATC) ......... 289
Automatic Transaxle .................... 12,315
Interlock System ..................... 15,316
496 INDEX

Reset Mode.......................... 317
Selection Of Lubricant ................443,463
Shifting ............................. 317
Special Additives ...................... 445
Automatic Transmission ................... 442
Adding Fluid ......................... 444
Fluid and Filter Changes ................. 445
Fluid Change ......................... 445
Fluid Level Check ...................... 444
Fluid Type ........................ 443,463
Ball Joints ............................. 430
Battery ............................... 427
Gas Caution .......................... 427
Jump Starting ......................... 405
Keyless Transmitter Replacement (RKE) ....... 26
Saving Feature (Protection) ............... 153
Bearings .............................. 446
Belts, Drive ............................ 423 Body Mechanism Lubrication
............... 431
B-Pillar Location ........................ 332
Brake Fluid ............................ 463
Brake, Parking .......................... 319
Brake System ........................ 321,439
Anti-Lock (ABS) ....................... 321
Fluid Check .......................... 441
Hoses .............................. 440
Warning Light ........................ 213
Brakes ............................. 321,439
Brake/Transmission Interlock ............... 316
Break-In Recommendations, New Vehicle ........ 88
Bulb Replacement ....................... 456
Bulbs, Light ............................ 455
Calibration, Compass ..................... 169
Capacities, Fluid ........................ 461
Caps, Filler Fuel ................................ 357
INDEX 497
10

Door Ajar Light......................... 213
Door Locks ............................. 27
Door Locks, Automatic .................... 29
Door Opener, Garage ..................... 177
Drive Belts ............................ 423
Drive Shaft Universal Joints ................ 431
Driving On Slippery Surfaces .................... 326
DVD Player (Video Entertainment System) ...... 259
E-85 Fuel ............................. 360
Electric Remote Mirrors .................... 98
Electrical Power Outlets ................... 185
Electronic Speed Control (Cruise Control) ...... 164
Electronic Vehicle Information Center (EVIC) .... 172
Emergency, In Case of Hazard Warning Flasher ................. 384
Jacking ........................ 386,387,399
Jump Starting ......................... 405 Overheating
.......................... 385
Emission Control System Maintenance ......417,466
Engine ............................ 414,415
Air Cleaner .......................... 425
Air Cleaner Filter ...................... 424
Block Heater ......................... 315
Break-In Recommendations ................ 88
Checking Oil Level ..................... 420
Compartment ...................... 414,415
Coolant (Antifreeze) .................... 462
Cooling ............................. 434
Exhaust Gas Caution .................. 43,356
Flooded, Starting ...................... 313
Fuel Requirements .................. 353,461
Oil ........................... 420,461,462
Oil Change Interval .................... 421
Oil Disposal .......................... 423
Oil Filler Cap ......................... 422
Oil Filter Disposal ...................... 423
500 INDEX

Oil Selection....................... 421,461
Oil Synthetic ......................... 423
Overheating .......................... 385
Temperature Gauge ..................... 216
Event Data Recorder ...................... 73
Exhaust Gas Caution ..............43,89,356,433
Exhaust System ......................... 433
Extender, Seat Belt ........................ 56
Exterior Folding Mirrors ................... 98
Filters Air Cleaner .......................... 424
Air Conditioning .................... 301,429
Automatic Transaxle .................... 445
Engine Oil ........................ 423,462
Engine Oil Disposal .................... 423
Flashers Hazard Warning ....................... 384
Turn Signal ..................... 212,458,459 Flat Tire Stowage
........................ 395
Flexible Fuel Vehicles Cruising Range ........................ 363
Engine Oil ........................... 362
Fuel Requirements .................. 360,361
Maintenance .......................... 363
Replacement Parts ..................... 363
Starting ............................. 362
Flooded Engine Starting ................... 313
Fluid Capacities ......................... 461
Fluid Leaks ............................. 90
Fluid Level Checks Automatic Transmission ................. 444
Brake ............................... 441
Power Steering ........................ 430
Fluids ................................ 462
Fluids, Lubricants and Genuine Parts .......... 462
Fog Light Service ........................ 459
Fog Lights .......................... 154,459
INDEX 501
10

Fold in Floor (Stown Go) Seating........... 129
Freeing A Stuck Vehicle ................... 407
Fuel ................................. 353
Adding ............................. 357
Additives ............................ 355
Clean Air ............................ 354
Filler Cap (Gas Cap) .................... 357
Gasoline ............................ 353
Gauge .............................. 211
Hoses .............................. 442
Light ............................... 212
Octane Rating ...................... 353,462
Requirements ...................... 353,461
Tank Capacity ........................ 461
Fuel, Flexible ............. See Flexible Fuel Vehicles
Fuel System Caution ..................... 356
Fueling ............................... 357
Fuses ................................ 452 Garage Door Opener (HomeLink
) ........... 177
Gas Cap (Fuel Filler Cap) ............357,359,416
Gasoline, Clean Air ...................... 354
Gasoline (Fuel) ......................... 353
Gasoline, Reformulated ................... 354
Gauges Coolant Temperature .................... 216
Fuel ................................ 211
Speedometer ......................... 213
Tachometer .......................... 215
Gearshift .............................. 317
General Information ...............18,25,123,353
Glass Cleaning .......................... 449
Grocery Bag Retainer ..................... 144
Gross Axle Weight Rating ...............364,368
Gross Vehicle Weight Rating .............364,368
Hands-Free Phone (UConnect™) ............. 100
Hazard Warning Flasher ................... 384
502 INDEX

Headlights On Reminder................. 153
High Beam Indicator .................... 217
High Beam/Low Beam Select ............. 156
Illuminated Entry ....................... 20
Interior .......................... 151,152
License ............................. 461
Liftgate Ajar .......................... 212
Lights On Reminder .................... 153
Low Fuel ............................ 212
Malfunction Indicator (Check Engine) ........ 218
Oil Pressure .......................... 217
Park ............................. 151,458
Passing ............................. 156
Reading ............................. 168
Rear Servicing ........................ 459
Rear Tail ............................ 459
Seat Belt Reminder ..................... 215
Security Alarm (Theft Alarm) .............. 216
Service ........................... 455,456 Service Engine Soon (Malfunction Indicator) . . . 218
Side Marker
.......................... 459
Theft Alarm (Security Alarm) .............. 216
Turn Signal ..................... 155,458,459
Voltage ............................. 215
Warning (Instrument Cluster Description) ..... 211
Washer Fluid ......................... 217
Load Leveling System .................... 201
Loading Vehicle ................... 198,363,366
Capacities ........................... 366
Tires ............................... 332
Locks Door ................................ 27
Steering Wheel ......................... 14
Lower Anchors and Tether for CHildren (LATCH) . 79
Lubrication, Body ....................... 431
Luggage Rack (Roof Rack) ................. 199
Lumbar Support ........................ 128
INDEX 505
10

Maintenance, Airbag...................... 71
Maintenance Free Battery .................. 427
Maintenance Procedures ................... 419
Maintenance Schedule .................... 466
Light Duty Schedule “B” ................. 469
Schedule “A” ......................... 478
Schedule “B” ......................... 469
Maintenance, Sunroof ..................... 185
Malfunction Indicator Light (Check Engine) . . 218,417
Manual, Service ......................... 490
Map/Reading Lights ..................... 168
Memory Seat ........................... 99
Mini-Trip Computer ...................... 171
Mirrors ................................ 96
Automatic Dimming ..................... 96
Electric Remote ........................ 98
Exterior Folding ........................ 98
Heated .............................. 99
Outside .............................. 97 Rearview
............................. 96
Vanity ............................... 99
Modifications/Alterations, Vehicle ............. 7
Monitor, Tire Pressure System ............... 347
Mopar Parts ......................... 418,489
Multi-Function Control Lever ............... 155
Navigation Radio ........................ 257
Navigation System ....................... 257
New Vehicle Break-In Period ................ 88
Occupant Restraints ....................... 46
Octane Rating, Gasoline (Fuel) .............. 353
Odometer ............................. 219
Oil, Engine ......................... 420,462
Capacity ............................ 461
Change Interval ....................... 421
Checking ............................ 420
Disposal ............................ 423
506 INDEX