transmission fluid DODGE CHALLENGER 2018 User Guide

Routine fluid and filter changes are not required. However,
change the fluid and filter if the fluid becomes contami-
nated (with water, etc.), or if the transmission is disas-
sembled for any reason.
All Wheel Drive (AWD) — If Equipped
The all wheel drive system consists of a transfer case and
front differential. The exterior surface of these components
should be inspected for evidence of fluid leaks. Confirmed
leaks should be repaired as soon as possible.
The transfer case fluid fill/inspection plug is located in the
middle of the rear housing. To inspect the transfer case
fluid level, remove the fill/inspection plug. The fluid level
should be even with the bottom of the hole. Use this plug
to add fluid as required.
The front differential fill plug is located on the outer cover
near the halfshaft attachment. To inspect the differential
fluid level, remove the fill plug. The fluid level should be
even with or slightly below the bottom of the hole.
Fluid Changes
Refer to “Scheduled Servicing” in “Servicing And Mainte-
nance” for the proper maintenance intervals.
Rear Axle
Fluid Level Check
Checking the fluid level while the vehicle is on level
ground and has been stationary for 15 minutes will im-
prove the accuracy of the fluid level reading.
Check the fluid level by removing the fill plug on the axle.
The fluid level should be 1-2.5 mm below the fill plug. Add
fluid, if necessary, to maintain the proper level. Refer to
“Fluids And Lubricants” inServicing And Maintenance”
for further information.
Change Axle Fluid
Refer to “Scheduled Servicing” in “Servicing And Mainte-
nance” for the proper maintenance intervals.
8
SERVICING AND MAINTENANCE 357

TECHNICAL SPECIFICATIONS
CONTENTS
IDENTIFICATION DATA ...................388
▫ Vehicle Identification Number .............388
 BRAKE SYSTEM ....................... .389
 WHEEL AND TIRE TORQUE SPECIFICATIONS . .389
▫ Torque Specifications ....................390
 FUEL REQUIREMENTS ...................391
▫ 3.6L Engine ......................... .391
▫ 5.7L Engine (With Automatic Transmission) . . . .391
▫ 5.7L Engine (With Manual Transmission) ......392
▫ 6.4L Engine .......................... .392
▫ Reformulated Gasoline ..................393 ▫
Materials Added To Fuel .................393
▫ Gasoline/Oxygenate Blends ...............394
▫ Do Not Use E-85 In Non-Flex Fuel Vehicles . . . .394
▫ CNG And LP Fuel System Modifications ......394
▫ MMT In Gasoline ...................... .395
▫ Fuel System Cautions ....................395
▫ Carbon Monoxide Warnings ...............396
 FLUID CAPACITIES ..................... .396
 FLUIDS AND LUBRICANTS ................398
▫ Engine ............................. .398
▫ Chassis ............................ .400
9

Carbon Monoxide Warnings
WARNING!
Carbon monoxide (CO) in exhaust gases is deadly.
Follow the precautions below to prevent carbon mon-
oxide poisoning:
•Do not inhale exhaust gases. They contain carbon
monoxide, a colorless and odorless gas, which can
kill. Never run the engine in a closed area, such as a
garage, and never sit in a parked vehicle with the
(Continued)
WARNING! (Continued)
engine running for an extended period. If the vehicle
is stopped in an open area with the engine running
for more than a short period, adjust the ventilation
system to force fresh, outside air into the vehicle.
• Guard against carbon monoxide with proper main-
tenance. Have the exhaust system inspected every
time the vehicle is raised. Have any abnormal condi-
tions repaired promptly. Until repaired, drive with
all side windows fully open.
FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)
3.6L Engine (87 Octane, 0-15% Ethanol.) 18.5 Gallons70 Liters
5.7L Engine (Automatic Transmission: 87 Octane or 89 Octane, 0-15%
Ethanol. Manual Transmission: 91 Octane or higher, 0-15% Ethanol.) 18.5 Gallons
70 Liters
6.4L Engine (91 Octane or higher, 0-15% Ethanol.) 18.5 Gallons70 Liters
396 TECHNICAL SPECIFICATIONS

FLUIDS AND LUBRICANTS
Engine
ComponentFluid, Lubricant, or Genuine Part
Engine Coolant We recommend you use Mopar Antifreeze/Coolant 10 Year/
150,000 Mile Formula OAT (Organic Additive Technology).
Engine Oil – 3.6L & 5.7L Engine We recommend you use API Certified SAE 5W-20 Engine Oil,
meeting the requirements of FCA Material Standard MS-6395
such as Mopar, Pennzoil, and Shell Helix. Refer to your en-
gine oil filler cap for correct SAE grade.
Engine Oil – 6.4L Engine For best performance and maximum protection under all
types of operating conditions, the manufacturer only recom-
mends full synthetic engine oils.
The manufacturer recommends the use of Pennzoil Ultra
Platinum 0W-40 or equivalent Mopar engine oil meeting the
requirements of FCA Material Standard MS-12633 for use in
all operating temperatures.
Engine Oil Filter We recommend you use Mopar Engine Oil Filters.
Spark Plugs We recommend you use Mopar Spark Plugs.
Fuel Selection – 3.6 Engine 87 Octane, 0-15% Ethanol.
Fuel Selection – 5.7 Engine With Automatic Trans-
mission
89 Octane recommended – 87 Octane acceptable, 0-15% Ethanol.
Fuel Selection – 6.4L Engine & 5.7 Engine With
Manual Transmission 91 Octane or higher, 0-15% Ethanol.
398 TECHNICAL SPECIFICATIONS

Chassis
ComponentFluid, Lubricant, or Genuine Part
8-Speed Automatic Transmission Use only Mopar ZF 8&9 Speed ATF Automatic Transmission Fluid, or equiva- lent. Failure to use the correct fluid may affect the function or performance of
your transmission.
Manual Transmission – If Equipped We recommend you use Mopar ATF+4 Automatic Transmission Fluid.
Brake Master Cylinder We recommend you use Mopar DOT 3, SAE J1703. If DOT 3 brake fluid is
not available, then DOT 4 is acceptable.
Front Axle We recommend you use Mopar Synthetic Gear Lubricant SAE 75W90
(API GL-5).
Rear Axle – 3.6L/5.7L Engine With
Automatic Transmission We recommend you use Mopar OD Synthetic Gear Lubricant SAE 75W85
(API GL-5).
Rear Axle – 6.4 Engine or 5.7 With
Manual Transmission We recommend you use Mopar LSD Synthetic Gear Lubricant SAE 75W85
(API GL-5).
Transfer Case — AWD (If Equipped)
We recommend you use Mopar Transfer Case Lubricant for BorgWarner 44–40.
400 TECHNICAL SPECIFICATIONS

Apple CarPlay........................... .487
Arming System Security Alarm ...........................31
Assist, Hill Start .......................... .129
Audio Systems (Radio) ...................... .403
Auto Down Power Windows ...................74
Automatic Door Locks .....................38, 39
Automatic Headlights ........................56
Automatic High Beams .......................55
Automatic Temperature Control (ATC) ............70
Automatic Transmission ..................... .209
Adding Fluid .....................356, 398, 400
Fluid And Filter Change ...................356
Fluid Change .......................... .356
Fluid Level Check .....................355, 356
Fluid Type ...................... .355, 398, 400
Special Additives ........................ .356
Automatic Transmission Limp Home Mode .....38, 214
Autostick Operation ............................. .215
AW D Towing ............................... .314
Axle Fluid ........................... .398, 400
Axle Lubrication ....................... .398, 400Back-Up
................................ .248
Battery ...............................110,333
Charging System Light .....................110
Keyless Key Fob Replacement ................20
Location .............................. .333
Belts, Seat ............................... .188
Blind Spot Monitoring ...................... .132
Body Mechanism Lubrication ..................344
B-Pillar Location .......................... .364
Brake Assist System ........................ .123
Brake Control System ....................... .123
Brake Fluid ....................... .353, 398, 400
Brake System ......................... .353, 389
Fluid Check ..................... .353, 398, 400
Master Cylinder ........................ .353
Parking .............................. .202
W

arning Light ...................... .109, 389
Brake/Transmission Interlock ..................209
Break-In Recommendations, New Vehicle ..........200
Brightness, Interior Lights .....................59
Bulb Replacement ......................... .275
Bulbs, Light .......................... .191, 275
Camera, Rear ............................ .248
Capacities, Fluid .......................... .396
12
INDEX 499

Park Release........................... .309
Rearward ...............................40
Tilt ...................................40
Manual, Service ........................... .496
Manual Transmission .................204, 355, 357
Fluid Level Check .....................355, 357
Map/Reading Lights .........................58
Memory Feature (Memory Seats) ................39
Memory Seat ..............................39
Memory Seats And Radio .....................39
Methanol ............................... .394
Mirrors ..................................50
Electric Powered ..........................52
Electric Remote ...........................52
Heated .................................52
Outside ................................51
Rearview ........................... .50, 269
Vanity .................................53
Modifications/Alterations, Vehicle ................6
Monitor, Tire Pressure System ..................141
Mopar Parts ............................. .495
Multi-Function Control Lever ...................54
New Vehicle Break-In Period ..................200 Occupant Restraints
........................ .147
Octane Rating, Gasoline (Fuel) ..............391, 398
Oil Change Indicator ....................... .101
Reset ................................ .101
Oil, Engine ........................... .335, 398
Capacity .............................. .396
Change Interval ........................ .335
Checking ............................. .332
Dipstick .............................. .332
Disposal .............................. .339
Filter ............................. .339, 398
Filter Disposal .......................... .339
Identification Logo ...................... .336
Materials Added To ...................... .339
Pressure Warning Light ....................110
Recommendation .....................335, 396
Synthetic ............................. .337
V
iscosity ....................... .336, 337, 396
Oil Filter, Change ......................... .339
Oil Filter, Selection ......................... .339
Oil Pressure Light ..........................110
Onboard Diagnostic System ...................118
Operating Precautions .......................118
Operator Manual (Owner’s Manual) ...............4
Outside Rearview Mirrors .....................51
506 INDEX

Wheel Nut Torque....................... .389
Tire Safety Information ...................... .358
Tire Service Kit ............297, 298, 299, 301, 304, 305
Tongue Weight/Trailer Weight .................257
To Open Hood .............................78
Towing ................................. .253
Disabled Vehicle ........................ .313
Guide ................................ .256
Recreational ........................... .262
Weight ............................... .256
Towing Behind A Motorhome ..................262
Traction ................................ .263
Traction Control .......................... .131
Trailer Towing ............................ .253
Cooling System Tips ..................... .262
Hitches ............................... .256
Minimum Requirements ....................257
Tips ................................. .261
Trailer And Tongue Weight ..................257
Wiring ............................... .260
Trailer Towing Guide ....................... .256
Trailer Weight ............................ .256
Transfer Case ............................ .357
Fluid .......................... .357, 398, 400
Maintenance ........................... .357Transmission
............................. .209
Automatic ...................... .207, 209, 355
Fluid ............................. .398, 400
Maintenance ........................... .355
Manual ............................... .204
Shifting .............................. .207
Transporting Pets ......................... .187
Tread Wear Indicators ...................... .372
Trunk Lid (Deck Lid) .........................79
Trunk Release Remote Control ..................79
Turn Signals ........................... .58,
117
Uconnect Uconnect Settings .................18, 19, 29, 418
Uconnect 4C/4C Nav With 8.4-Inch Display ........427
Uconnect 4 With 7-Inch Display ................406
Uconnect Settings Customer Programmable Features ..........29, 418
Uniform Tire Quality Grades ..................381
Unleaded Gasoline ........................ .391
Untwisting Procedure, Seat Belt ................154
Vanity Mirrors .............................53
Vehicle Certification Label ....................251
Vehicle Identification Number (VIN) .............388
12
INDEX 511