brakes DODGE DURANGO 2007 2.G User Guide

WARNING!
Improper towing can lead to an injury accident.
Follow these guidelines to make your trailer towing
as safe as possible:
Make certain that the load is secured in the trailer
and will not shift during travel. When trailering
cargo that is not fully secured, dynamic load shifts
can occur that may be difficult for the driver to
control. You could lose control of your vehicle and
have an accident.
•When hauling cargo or towing a trailer, do not over-
load your vehicle or trailer. Overloading can cause a
loss of control, poor performance or damage to brakes,
axle, engine, transmission, steering, suspension, chas-
sis structure or tires.
•Safety chains must always be used between your
vehicle and trailer. Always connect the chains to the
frame or hook retainers of the vehicle hitch. Cross the
chains under the trailer tongue and allow enough
slack for turning corners.
•Vehicles with trailers should not be parked on a grade.
When parking, apply the parking brake on the tow
vehicle. Put the tow vehicle automatic transmission in
P for Park. With a manual transmission, shift the
transmission into reverse. And with four-wheel-drive
vehicles, make sure the transfer case is not in neutral.
Always, block orchockthe trailer wheels.
•GCWR must not be exceeded.
•Total weight must be distributed between the tow
vehicle and the trailer such that the following four
ratings are not exceeded:
1. GVWR
STARTING AND OPERATING 331
5

2. GTW
3. GAWR
4. Tongue weight rating for the trailer hitch utilized
(This requirement may limit the ability to always
achieve the 10% to 15% range of tongue weight as a
percentage of total trailer weight).
Towing Requirements — Tires

Do not attempt to tow a trailer while using a compact
spare tire.
Proper tire inflation pressures are essential to the safe
and satisfactory operation of your vehicle. Refer to the
Tires–General Information section of this manual on
Tire Pressures for proper tire inflation procedures.
Also, check the trailer tires for proper tire inflation
pressures before trailer usage.
Check for signs of tire wear or visible tire damage
before towing a trailer. Refer to the Tires–General
Information section of this manual on Tread Wear
Indicators for the proper inspection procedure.
When replacing tires refer to the Tires–General Infor-
mation section of this manual on Replacement Tires for
proper tire replacement procedures. Replacing tires
with a higher load carrying capacity will not increase
the vehicle’s GVWR and GAWR limits.
Towing Requirements — Trailer Brakes

Donotinterconnect the hydraulic brake system or
vacuum system of your vehicle with that of the trailer.
This could cause inadequate braking and possible
personal injury.
An electronically actuated trailer brake controller is
required when towing a trailer with electronically
332 STARTING AND OPERATING

actuated brakes. When towing a trailer equipped with
a hydraulic surge actuated brake system, an electronic
brake controller is not required.
Trailer brakes are recommended for trailers over 1,000
lbs (454 kg) and required for trailers in excess of 2,000
lbs (907 kg).
CAUTION!
If the trailer weighs more than 1,000 lbs (454 kg)
loaded, it should have its own brakes and they
should be of adequate capacity. Failure to do this
could lead to accelerated brake lining wear, higher
brake pedal effort, and longer stopping distances.
WARNING!
Do not connect trailer brakes to your vehicle’s hy-
draulic brake lines. It can overload your brake sys-
tem and cause it to fail. You might not have brakes
when you need them and could have an accident.
Towing any trailer will increase your stopping dis-
tance. When towing you should allow for additional
space between your vehicle and the vehicle in front
of you. Failure to do so could result in an accident.
Towing Requirements — Trailer Lights & Wiring
Whenever you pull a trailer, regardless of the trailer size,
stop lights and turn signals on the trailer are required for
motoring safety.
The Trailer Tow Package may includea4and7pin
wiring harness. Use a factory approved trailer harness
and connector.
STARTING AND OPERATING 333
5

Positive Crankcase Ventilation (PCV) Valve
Proper operation of the crankcase ventilation system
requires that the PCV valve be free of sticking or plug-
ging because of deposits. Deposits can accumulate in the
PCV valve and passage with increasing mileage. Have
the PCV valve, hoses, and passages checked for proper
operation at the intervals specified. If the valve is
plugged or sticking, replace with a new valve –Do not
attempt to clean the PCV valve!Check ventilating hose
for indication of damage or plugging with deposits.
Replace if necessary.
Brake System
Power Disc Brakes (Front and Rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake Master Cylinders
The fluid level in the master cylinders should be checked
whenever the vehicle is serviced, or immediately if the
brake system warning light is on. If necessary, add fluid
to bring level to the full mark on the side of the reservoir
of the brake master cylinder. Be sure to clean the top of
the master cylinder area before removing the cap. With
disc brakes, fluid level can be expected to fall as the brake
pads wear. Brake fluid level should be checked when
pads are replaced. If the brake fluid level is abnormally
low, check system for leaks.
Refer to Fluids, Lubricants and Genuine Parts for correct
fluid type.
MAINTAINING YOUR VEHICLE 387
7

Axle Lubrication (Axle Fluid)............... 392
BallJoints ............................. 377
Battery.......................360,361,362,374
Charging............................ 353
Emergency Starting..................... 353
Gas Caution.......................... 353
Keyless Transmitter Replacement (RKE)....... 25
Saving Feature (Protection)............... 132
Belts,Drive ............................ 371
Belts, Seat.............................. 39
Body Mechanism Lubrication............... 378
B-Pillar Location........................ 289
Brake Assist System...................... 276
Brake Control System, Electronic............. 275
Brake Fluid............................ 419
Brake System........................271,387
Anti-Lock (ABS)....................271,275
Disc Brakes.......................... 387Fluid Check.......................... 387
Hoses.............................. 388
Master Cylinder....................... 387
Parking............................. 269
Warning Light.....................188,191
Brakes............................... 271
Brake/Transmission Interlock............... 254
Break-In Recommendations, New Vehicle........ 71
Bulb Replacement....................... 408
Bulbs,Light ............................ 407
Calibration, Compass..................... 158
Capacities, Fluid........................ 417
Caps, Filler
Fuel................................ 314
Oil (Engine).......................... 369
Power Steering........................ 377
Radiator (Coolant Pressure)............... 383
Car Washes............................ 393
INDEX 459
10

Pressure Cap......................... 383
Radiator Cap......................... 383
Selection of Coolant (Antifreeze)......382,417,418
Temperature Gauge..................... 185
Cruise Control (Speed Control).............. 143
CupHolder ............................ 173
Customer Assistance..................... 448
Data Recorder, Event...................... 60
Daytime Running Lights................... 134
Dealer Service.......................... 366
Defroster, Rear Window................... 246
Defroster, Windshield................ 73,232,238
Delay (Intermittent) Wipers................. 138
Diagnostic System, Onboard................ 363
Dimmer Switch, Headlight................. 186
Dipsticks
Automatic Transmission................. 389
Oil (Engine).......................... 367Power Steering........................ 377
Disarming, Theft System................... 18
Disc Brakes............................ 387
Disposal
Antifreeze (Engine Coolant)............... 384
Door Locks............................. 27
Door Opener, Garage..................... 160
DriveBelts ............................ 371
Drive Shaft Universal Joints................ 378
DVD Player (Video Entertainment System)...... 223
E-85 Fuel............................. 317
Electric Remote Mirrors.................... 81
Electrical Power Outlets................... 169
Electronic Brake Control System............. 275
Electronic Speed Control (Cruise Control)...... 143
Electronic Stability Program (ESP).........191,279
Electronic Vehicle Information Center (EVIC).... 152
INDEX 461
10

Parking On Hill......................... 269
Passing Light........................... 137
Pedals, Adjustable....................... 142
Personal Settings........................ 155
Pets.................................. 71
Pets, Transporting........................ 71
Phone, Cellular.......................... 84
Phone, Hands-Free (UConnect™)............. 84
Placard, Tire and Loading Information......... 289
Positive Crankcase Valve.................. 387
Power
Brakes.............................. 387
Distribution Center (Fuses).......360,361,362,402
Door Locks......................... 19,28
Lift Gate............................. 35
Mirrors .............................. 81
Outlet (Auxiliary Electrical Outlet).......169,170
Steering..........................273,377
Steering Filler Cap................360,361,362Sunroof............................. 167
Windows............................. 31
Power Steering Fluid..................... 419
Pregnant Women and Seat Belts.............. 50
Preparation for Jacking.................... 348
Pretensioners
Seat Belts............................. 48
Programmable Electronic Features......155,162,165
Programming Transmitters
(Remote Keyless Entry)............... 23,162,165
Radial Ply Tires......................... 297
Radiator Cap (Coolant Pressure Cap).......381,383
Radio Broadcast Signals................... 196
Radio, Navigation....................... 219
Radio Operation...................197,205,229
Radio, Satellite.......................219,223
Radio (Sound Systems).................197,205
Rear Axle (Differential).................... 392
INDEX 469
10