belt DODGE DURANGO SRT 2019 Repair Manual

Maintenance Plan
Miles:6,000
12,000
18,000
24,000
30,000
36,000
42,000
48,000
54,000
60,000
66,000
72,000
78,000
84,000
90,000
96,000
102,000
108,000 114,000
120,000
126,000
132,000
138,000
144,000
150,000
Or Months: 6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102 108 114 120 126 132 138 144 150
Or Kilometers:
10,000
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
160,000
170,000
180,000
190,000
200,000
210,000
220,000
230,000
240,000
250,000
Change the engine oil and en-
gine oil filter. XXXXXXXXXXXXXXXXXXXXXXXXX
Rotate the tires, rotate at the first
sign of irregular wear, even if it
occurs before scheduled mainte-
nance. XXXXXXXXXXXXXXXXXXXXXXXXX
If using your vehicle for any of
the following: dusty or off-road
conditions. Inspect the engine air
cleaner filter; replace if neces-
sary. XXXXXXXXXXXX
Inspect the brake linings; replace
if necessary. XXXXXXXXXXXX
Inspect the CV joints. X X X X X X X X X X X X
Inspect the exhaust system. X X X X X X X X X X X X
Adjust the parking brake on ve-
hicles equipped with four wheel
disc brakes. XXXXX
Drain the transfer case and refill. X X X X X
Inspect the accessory drive belts
replace if necessary. XX
8
SERVICING AND MAINTENANCE 395

Engine Oil Filter
The engine oil filter should be replaced with a new filter at
every engine oil change.
Engine Oil Filter Selection
This manufacturer’s engines have a full-flow type dispos-
able oil filter. Use a filter of this type for replacement. The
quality of replacement filters varies considerably. Only
high quality filters should be used to assure most efficient
service. Mopar engine oil filters are high quality oil filters
and are recommended.
Engine Air Cleaner Filter
Refer to the “Maintenance Plan” in this section for the
proper maintenance intervals.
WARNING!
The air induction system (air cleaner, hoses, etc.) can
provide a measure of protection in the case of engine
backfire. Do not remove the air induction system (air
cleaner, hoses, etc.) unless such removal is necessary
for repair or maintenance. Make sure that no one is
(Continued)
WARNING!(Continued)
near the engine compartment before starting the ve-
hicle with the air induction system (air cleaner, hoses,
etc.) removed. Failure to do so can result in serious
personal injury.
Engine Air Cleaner Filter Selection
The quality of replacement engine air cleaner filters varies
considerably. Only high quality filters should be used to
assure most efficient service. Mopar engine air cleaner
filters are a high quality filter and are recommended.
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the
start of each warm season. This service should include
cleaning of the condenser fins and a performance test.
Drive belt tension should also be checked at this time.
8
SERVICING AND MAINTENANCE 403

7. Install the A/C air filter with the arrow on the filterpointing toward the floor. When installing the filter
cover, make sure the retaining tabs fully engage the
cover.
CAUTION!
The cabin air filter is identified with an arrow to
indicate airflow direction through the filter. Failure to
properly install the filter will result in the need to
replace it more often.
8. Reinstall the glove compartment door on the door hinge and reattach the tension tether by inserting the tether
clip in the glove compartment and sliding the clip away
from the face of the glove compartment door.
9. Push the door to the near closed position to reengage the glove compartment travel stops.
NOTE: Ensure the glove compartment door hinges and
glove compartment travel stops are fully engaged.
Accessory Drive Belt Inspection
WARNING!
• Do not attempt to inspect an accessory drive belt
with vehicle running.
• When working near the radiator cooling fan, discon-
nect the fan motor lead. The fan is temperature
controlled and can start at any time regardless of
ignition mode. You could be injured by the moving
fan blades.
• You can be badly injured working on or around a
motor vehicle. Only do service work for which you
have the knowledge and the proper equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent me-
chanic.
When inspecting accessory drive belts, small cracks that
run across ribbed surface of belt from rib to rib, are
considered normal. These are not a reason to replace belt.
However, cracks running along a rib (not across) are not
normal. Any belt with cracks running along a rib must be
replaced. Also have the belt replaced if it has excessive
wear, frayed cords or severe glazing.
8
SERVICING AND MAINTENANCE 407

Conditions that would require replacement:
•Rib chunking (one or more ribs has separated from belt
body)
• Rib or belt wear
• Longitudinal belt cracking (cracks between two ribs)
• Belt slips
• “Groove jumping (belt does not maintain correct posi-
tion on pulley)
• Belt broken (note: identify and correct problem before
new belt is installed) •
Noise (objectionable squeal, squeak, or rumble is heard
or felt while drive belt is in operation)
Some conditions can be caused by a faulty component such
as a belt pulley. Belt pulleys should be carefully inspected
for damage and proper alignment.
Belt replacement on some models requires the use of
special tools, we recommend having your vehicle serviced
at an authorized dealer.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, door hinge pivot points and rollers, liftgate,
tailgate, decklid, sliding doors and hood hinges, should be
lubricated periodically with a lithium based grease, such as
Mopar Spray White Lube to assure quiet, easy operation
and to protect against rust and wear. Prior to the applica-
tion of any lubricant, the parts concerned should be wiped
clean to remove dust and grit; after lubricating excess oil
and grease should be removed. Particular attention should
also be given to hood latching components to ensure
proper function. When performing other underhood ser-
vices, the hood latch, release mechanism and safety catch
should be cleaned and lubricated.
Accessory Belt (Serpentine Belt)
408 SERVICING AND MAINTENANCE

INTERIORS
Seats And Fabric Parts
Use Mopar Total Clean to clean fabric upholstery and
carpeting.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in closed
areas they may cause respiratory harm.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical solvents
or abrasive cleaners. This will weaken the fabric. Sun
damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the vehicle
to wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
Plastic And Coated Parts
Use Mopar Total Clean to clean vinyl upholstery.
CAUTION!
•Direct contact of air fresheners, insect repellents,
suntan lotions, or hand sanitizers to the plastic,
painted, or decorated surfaces of the interior may
cause permanent damage. Wipe away immediately.
• Damage caused by these type of products may not be
covered by your New Vehicle Limited Warranty.
450 SERVICING AND MAINTENANCE

Anti-Lock Warning Light.....................161
Apple CarPlay ........................... .543
Arming System Security Alarm ...........................32
Assist, Hill Start .......................... .172
Audio Systems (Radio) ...................... .466
Auto Down Power Windows ...................98
Automatic Headlights ........................72
Automatic High Beams .......................71
Automatic Temperature Control (ATC) ............94
Automatic Transmission ..................258, 269
Adding Fluid ....................... .422, 462
Autostick ............................. .275
Fluid And Filter Change ...................422
Fluid Change .......................... .422
Fluid Level Check .....................421, 422
Fluid Type ......................... .421, 462
Gear Ranges ........................... .270
Special Additives ........................ .421
Automatic Transmission Limp Home Mode ........274
Autostick ............................... .275
Auxiliary Driving Systems ....................180
Auxiliary Electrical Outlet (Power Outlet) .........122
Auxiliary Power Outlet ..................... .122Axle Lubrication
.......................... .462
Battery .............................. .155, 399
Charging System Light ....................155
Keyless Key Fob Replacement ................21
Battery Saver Feature .........................74
Belts, Seat ............................... .251
Blind Spot Monitoring ...................... .180
Body Mechanism Lubrication ..................408
B-Pillar Location .......................... .429
Brake Assist System ........................ .172
Brake Control System, Electronic ................171
Brake Fluid .......................... .420, 462
Brake System ......................... .420, 455
Anti-Lock

(ABS) ........................ .455
Fluid Check ........................ .420, 462
Master Cylinder ........................ .420
Parking .............................. .265
Warning Light .......................... .154
Brake/Transmission Interlock ..................268
Bulb Replacement ...................... .360, 361
Bulbs, Light ............................. .254
Camera, Rear ............................ .329
Capacities, Fluid .......................... .460
12
INDEX 555

Caps, FillerOil (Engine) ..................... .398, 401, 402
Radiator (Coolant Pressure) .................418
Carbon Monoxide Warning ................251, 460
Cargo Area Cover ......................... .107
Cargo Compartment ....................... .107
Light ................................ .107
Luggage Carrier ........................ .128
Cargo Light ............................. .107
Cargo Tie-Downs .......................... .108
Car Washes .............................. .448
Cellular Phone ........................... .530
Center High Mounted Stop Light ...............364
Chains, Tire ............................. .444
Changing A Flat Tire ....................... .423
Chart, Tire Sizing .......................... .425
Check Engine Light (Malfunction Indicator Light). . . .166
Checking Your Vehicle For Safety ...............250
Checks, Safety ............................ .250
Child Restraint ........................... .225
Child Restraints Booster Seats ........................... .228
Child Seat Installation .....................244
How To Stow An unused ALR Seat Belt ........241
Infant And Child Restraints .................227 Locating The LATCH Anchorages
.............234
Lower Anchors And Tethers For Children .......231
Older Children And Child Restraints ...........228
Seating Positions ........................ .230
Child Safety Locks ..........................40
Clean Air Gasoline ........................ .457
Cleaning Wheels ............................... .443
Climate Control ............................82
Automatic ..............................83
Cold Weather Operation ..................... .263
Compact Disc (CD) Maintenance ................545
Compact Spare Tire ........................ .441
Contract,
Service.......................... .550
Cooling Pressure Cap (Radiator Cap) ............418
Cooling System ........................... .415
Adding Coolant (Antifreeze) .................417
Coolant Level .......................... .418
Cooling Capacity ........................ .460
Disposal Of Used Coolant ..................418
Drain, Flush, And Refill ....................416
Inspection ......................... .415, 418
Points To Remember ..................... .419
Pressure Cap ........................... .418
Radiator Cap .......................... .418
556 INDEX

Immobilizer (Sentry Key)......................30
Inside Rearview Mirror ....................66, 354
Instrument Cluster ..................... .138, 139
Descriptions ........................... .163
Display .............................. .140
Menu Items ........................... .145
Instrument Panel Lens Cleaning ................451
Integrated Trailer Brake Control ................343
Interior And Instrument Lights ..................75
Interior Appearance Care .....................450
Interior Lights ..............................75
Intermittent Wipers (Delay Wipers) ...............79
Introduction ................................4
In Vehicle Help Vehicle User Guide ........................17
Inverter Power ............................... .127
iPod/USB/MP3 Control ..................... .513
Jacking And Tire Changing Instructions ...........375
Jacking Instructions ........................ .375
Jack Location ............................ .372
Jack Operation ........................ .375, 423
Jump Starting ............................ .382KeyFob..................................19
Arm The System ..........................32
Disarm The System ........................32
Programming Additional Key Fobs ..........24, 31
Key Fob Battery Service (Remote Keyless Entry) .....21
Key Fob Programming (Remote Keyless Entry) ......24
Key-In Reminder ............................26
Keyless Enter-N-Go ........................ .259
Passive Entry ............................35
Passive Entry Programming ..................35
Keys ....................................19
Replacement ......................... .24, 31
Sentry (Immobilizer) .......................30
Lane Change Assist ..........................74
LaneSense ............................... .324
Lap/Shoulder Belts ........................ .200
Latches ................................. .254
Hood ................................ .104
Leaks, Fluid ............................. .254
Life
Of Tires ............................. .437
Liftgate ................................. .105
Liftgate Window Wiper/Washer .................82
Light Bulbs .............................. .254
Lights .................................. .254
560 INDEX

AirBag .........................154, 213, 251
Automatic Headlights......................72
Brake Assist Warning ..................... .178
Brake Warning ......................... .154
Bulb Replacement .....................360, 361
Cargo................................ .107
Center Mounted Stop ..................... .364
Cruise ............................ .163, 164
Daytime Running .........................71
Dimmer Switch, Headlight ...................70
Electronic Stability Program(ESP) Indicator ......156
Exterior ............................ .70, 254
Fog ................................. .363
Hazard Warning Flasher ...................354
Headlights ......................... .361, 362
Headlights On With Wipers ..................73
High Beam/Low Beam Select .................71
Interior ................................75
Lights On Reminder .......................73
Malfunction Indicator (Check Engine) ..........158
Park .............................. .72, 163
Passing ................................72
Reading ................................76
Rear Servicing .......................... .363
Rear Tail Lamps ........................ .363Seat Belt Reminder
...................... .154
Security Alarm ......................... .158
Service ............................ .360, 361
Side Marker ........................... .363
Traction Control ........................ .178
Turn Signals ................70, 163, 254, 362, 363
Vanity Mirror ............................69
Warning Instrument Cluster Descriptions . . . .156, 163
Loading Vehicle ........................... .333
Tires................................. .429
Load Shed Battery Saver Mode .................151
Load Shed Battery Saver On ...................151
Load Shed Electrical Load Reduction .............151
Load Shed Intelligent Battery Sensor .............151
Locks Child

Protection ..........................40
Manual ................................34
Power Door .............................35
Lubrication, Body ......................... .408
Luggage Carrier .......................... .128
Lug Nuts/Bolts ........................... .455
Maintenance ............................. .103
Maintenance Free Battery .....................399
Maintenance Schedule ...................... .393
12
INDEX 561

ParkSense System, Rear...................306, 315
Passive Entry ..............................35
Performance ............................. .147
Pets ................................... .250
Pinch Protection .......................... .102
Placard, Tire And Loading Information ...........429
Power Brakes ............................... .455
Distribution Center (Fuses) ..................365
Door Locks ..............................35
Inverter .............................. .127
Liftgate ............................... .105
Mirrors ................................68
Outlet (Auxiliary Electrical Outlet) ............122
Seats ..................................49
Steering .............................. .281
Sunroof .............................. .101
Tilt/Telescoping Steering Column ..............64
Windows ...............................98
Power Seats Down .............................. .50, 52
Forward ............................ .50, 52
Rearward ........................... .50, 52
Up ................................ .50, 52
Pregnant Women And Seat Belts ................206Preparation For Jacking
..................... .375
Pretensioners Seat Belts ............................. .206
Radial Ply Tires ........................... .435
Radiator Cap (Coolant Pressure Cap) .............418
Radio Frequency General Information ................24, 30, 31, 40
Radio Operation .......................... .530
Radio Remote Controls ..................... .512
Rain Sensitive Wiper System ...................81
Rear Air Conditioning ........................91
Rear Axle (Differential) ..................... .422
Rear Camera ............................. .329
Rear Cross Path ........................... .185
Rear Cupholders .......................... .121
Rear

ParkSense System ...................306, 315
Rear Seats, Folding ..........................42
Rear Wiper/Washer ..........................82
Recreational Towing ........................ .349
Reformulated Gasoline ...................... .457
Refrigerant .............................. .404
Release, Hood ............................ .104
Reminder, Seat Belt ........................ .199
12
INDEX 563